Table of Contents
Advertisement
CHASSIS SERVICE &
MAINTENANCE
Consult the appropriate sections in your
chassis operating guide for specific information
regarding operating safety, service recommenda-
tions and maintenance schedules for the chassis
section of your motor home.
OIL CHANGE REMINDER -
Workhorse Chassis
The engine controller monitors the engine oil
life remaining and will display the message
"Change Engine Oil" on the Odometer/Message
Center display when an oil change is due. This
'counter' must be reset at the time the oil change
service is performed to be able to alert you for
the next change.
To Reset Oil Change Reminder:
•
Turn the ignition switch to "ON" but Do Not
Start the engine.
•
Fully press-and-release the accelerator pedal
3 times within 5 seconds, then turn ignition
"OFF" for at least 10 seconds.
•
The 3000-mile oil life counter on the engine
controller will be reset to start a new cycle.
ENGINE COVER
• Remove the beverage tray from the engine
cover. Remove the drawer to expose the wing
nut fasteners that hold the tray to the motor
cover.
• Insert the supplied hex wrench into the hole
in the rear top or edge of the engine cover.
SECTION 15
CHASSIS
Unlatch
• Turn the hex wrench to the left (counter-
clockwise) to unlatch.
NOTE: There may be a screw at each front lower
corner.
• Lift the rear end of the cover upward and pull
the cover from the opening.
• To reinstall the cover, position the front end
of the cover first, then lower the rear end. It is
important to be sure the front edge is pushed
completely forward to the radiator cover to
ensure an air-tight seal.
• Press the rear end of the cover down and turn
the hex wrench to the right (clockwise) until
the latch pulls the cover downward and stops.
• Refasten the beverage tray to the motor
cover.
Removal of the engine cover allows service
access to the engine.
ENGINE COOLING SYSTEM
Refer to your chassis operating guide and
diesel engine manual for information and precau-
tions on filling, servicing and checking the fluid
level.
NOTE: Your chassis engine cooling system is
filled with special extended-life coolant
that is not the same as common anti-
freeze available at retail outlets.
15-1
Advertisement
Table of Contents
