Page 1: Table Of Contents
INTRODUCTION Thank you for purchasing a Honda engine. We want to help you to get the best results from your new engine and to operate it safely. This manual contains information on how to do that; please read it OWNER’S MANUAL carefully before operating the engine.
Page 2: Safety Information
SAFETY LABEL LOCATION MUFFLER OIL DRAIN PLUG GXV50 This indication warns you of potential hazards that can cause OIL DRAIN PLUG serious injury. Read it carefully. GXV57...
Page 3: Features
FEATURES BEFORE OPERATION CHECKS Centrifugal Clutch (applicable types) IS YOUR ENGINE READY TO GO? The centrifugal clutch automatically engages and transmits power For your safety, and to maximize the service life of your when engine speed is increased above approximately 2,900 rpm. equipment, it is very important to take a few moments before you At idle speed, the clutch is disengaged.
Page 4: Operation
OPERATION To start a cold engine, move the choke lever to the CLOSED position. SAFE OPERATING PRECAUTIONS To restart a warm engine, leave the choke lever in the OPEN Before operating the engine for the first time, please review the position.
Page 5: Setting Engine Speed
SETTING ENGINE SPEED STOPPING THE ENGINE Position the throttle lever for the desired engine speed. To stop the engine in an emergency, simply turn the engine switch on the equipment to the OFF position. Under normal conditions, The throttle lever shown here will be connected to a remote use the following procedure.
Page 6: Servicing Your Engine
To help you properly care for your engine, the following pages Remember that an authorized Honda servicing dealer knows your include a maintenance schedule, routine inspection procedures, engine best and is fully equipped to maintain and repair it.
Page 7: Refueling
REFUELING Refuel carefully to avoid spilling fuel. Do not fill the fuel tank completely. It may be necessary to lower the fuel level depending Recommended Fuel on operating conditions. After refueling, tighten the fuel filler cap Unleaded gasoline securely. U.S. Pump octane rating 86 or higher Except U.S.
Page 8: Oil Level Check
Oil Level Check With the engine in a level position, fill to the upper limit mark on the dipstick with the recommended oil (see page 7 ). Check the engine oil level with the engine stopped and in a level OIL FILLER CAP/DIPSTICK position.
Page 9: Air Cleaner
AIR CLEANER SPARK PLUG A dirty air cleaner will restrict air flow to the carburetor, reducing Recommended Spark Plugs: CR5HSB (NGK) engine performance. If you operate the engine in very dusty areas, U16FSR-UB (DENSO) clean the air filter more often than specified in the MAINTENANCE SCHEDULE.
Page 10: Spark Arrester
Check local laws and regulations. A spark arrester is available Storage Preparation from authorized Honda servicing dealers. Proper storage preparation is essential for keeping your engine trouble-free and looking good. The following steps will help to The spark arrester must be serviced every 100 hours to keep it keep rust and corrosion from impairing your engine’s function and...
Page 11: Transporting
Draining the Fuel Tank and Carburetor Storage Precautions If your engine will be stored with gasoline in the fuel tank and carburetor, it is important to reduce the hazard of gasoline vapor ignition. Select a well-ventilated storage area away from any Gasoline is highly flammable and explosive, and you appliance that operates with a flame, such as a furnace, water can be burned or seriously injured when handling...
Page 12: Taking Care Of Unexpected Problems
MAX. position. Take engine to Fuel filter Replace or repair an authorized restricted, faulty components Remote Control Linkage Honda carburetor as necessary. servicing malfunction, The throttle lever is provided with a hole for cable attachment. dealer, or refer ignition to shop...
Page 13: Carburetor Modifications For High Altitude Operation
The effect of altitude on horsepower will be greater than The following instructions and procedures must be followed in this if no carburetor modification is made. order to keep the emissions from your Honda engine within the emission standards. When the carburetor has been modified for high altitude operation, Tampering and Altering the air-fuel mixture will be too lean for low altitude use.
Page 14: Emission Control System
Replacement Parts Specifications The emission control systems on your Honda engine were designed, built, and certified to conform with EPA, California and GXV50 (PTO shaft S type) Canadian emission regulations. We recommend the use of Length Width 225 mm genuine Honda parts whenever you have maintenance done.
Page 15: Quick Reference
Quick Reference Information Fuel Unleaded gasoline (Refer to page 7) U.S. Pump octane rating 86 or higher Except Research octane rating 91 or higher U.S. Pump octane rating 86 or higher Engine oil SAE 10W-30, API SJ or later, for general use. Refer to page 7.
Page 16: Consumer Information
If you are dissatisfied with the decision made by the dealership’s All Other Areas: management, contact the Honda Regional Engine Distributor for Please contact the Honda distributor in your area for assistance. your area. If you are still dissatisfied after speaking with the Regional Engine Distributor, you may contact the Honda Office as shown.

This manual is also suitable for:

Gxv57

Honda GXV50 Owner's Manual

Quick Links

INTRODUCTION

SAFETY MESSAGES

Related Manuals for Honda GXV50

Summary of Contents for Honda GXV50

This manual is also suitable for:

Table of Contents