PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 4
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. A-A9-J http://www.xiaoyu163.com...
6. ADJUSTMENT ..............................54 7. GENERAL INFORMATION ..........................55 7.1 TROUBLE SHOOTIG..........................55 L 13942296513 7.2 SPECIFICATION OF PROTECTIVE OPERATION ...................56 7.3 DISCHARGE OF POWER AMPLIFIER....................56 7.4 PCB LOCATION ............................57 7.5 DISASSEMBLY............................58 7.6 IC INFORMATION ............................62 8. PANEL FACILITIES ............................66 u163 A-A9-J http://www.xiaoyu163.com...
: A9 model THD 1.0%, 4Ω............73 W + 73 W • Remote Control Unit : A9 model THD 1.0%, 8Ω............53 W + 53 W (A-A9-J : 8300746900010-IL) • Lithium Battery (A-A6-J : 8300747200010-IL) (CR2025) Total harmonic distortion** 20 Hz to 20 kHz, 25 W, 8Ω..........0.05%* >...
3 7 63 1515 0 IC513 IC510 A-A9 TYPE ONLY IC108 L 13942296513 A-A9 only IC104, IC105 Sound Retriever (Analogue) IC106 FLAT AMP A-A9 : 8.8 dB A-A6 : 7.7 dB A-A9 TYPE ONLY IC101 V601 u163 IC109 A-A9-J http://www.xiaoyu163.com...
Page 19
÷ When ordering service parts, be sure to refer to "EXPLODED VIEWS and PARTS LIST" or "PCB PARTS LIST". ÷ The > mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. A-A9-J http://www.xiaoyu163.com...
J605 R9605 J656 R9656 J658 R9658 J659 R659 J660 R660 CN680 CN608 REMOCON ASSY (A-A9:7028065356060-IL) (A-A6:7028065356010-IL) MOTOR VR ASSY (A-A9:7028065355060-IL) CN680 SCHEMATIC PCB PARTS DIAGRAM LIST REMO601 CN606 SCHEMATIC PCB PARTS DIAGRAM LIST VR601 u163 B C D A-A9-J http://www.xiaoyu163.com...
POWER SW ASSY (A-A9:7028065357060-IL) (A-A6:7028065357010-IL) CN708 CN709 CN801 SUB TRANS ASSY (A-A9:702806535A060-IL) To. Power trans L (A-A6:702806535A010-IL) CN802 To. Power trans R CN653 LIVE SCHEMATIC PCB PARTS u163 DIAGRAM LIST NEUTRAL CN804 RLY651 RY651 CN301 0000 K L M A-A9-J http://www.xiaoyu163.com...
Page 29
CN852 CN818 SCHEMATIC PCB PARTS DIAGRAM LIST J811 R811 J812 R9812 u163 J866 R866 • NOTE FOR FUSE REPLACEMENT J867 R867 FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. CAUTION - REPLACE WITH SAME TYPE AND RATINGS OF FUSE. A-A9-J http://www.xiaoyu163.com...
Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator L 13942296513 u163 A-A9-J http://www.xiaoyu163.com...
L 13942296513 To. Power To. Power CN852 trans R trans L SIDE B SIDE B SUB TRANS ASSY CN802 CN801 CN804 POWER SW ASSY u163 PCB PARTS DIAGRAM LIST SW801 S801 PCB PARTS DIAGRAM LIST RLY651 RY651 0000 A-A9-J http://www.xiaoyu163.com...
J658 R9658 REMO601 J659 R659 J660 R660 CN682 CN680 FRONT ASSY CN680 CN681 L 13942296513 CN608 CN9914 CN9915 VR ASSY A-A6 only CN607 PCB PARTS DIAGRAM LIST LED602 D602 SW601 S601 u163 VR602 S602 B D F G A-A9-J http://www.xiaoyu163.com...
Page 35
DIAGRAM LIST J660 R660 CN682 REMO601 CN680 FRONT ASSY CN680 CN681 L 13942296513 CN608 VR ASSY A-A6 only CN607 PCB PARTS DIAGRAM LIST LED602 D602 SW601 S601 u163 VR602 S602 B D F G B D F G A-A9-J http://www.xiaoyu163.com...
CN104 CN903 CN904 CN905 CN906 CN907 CN908 CN909 CN910 CN106 CN110 STATION ASSY SIDE B CN909 CN910 L 13942296513 CN903 CN904 CN905 CN906 CN907 CN908 SIDE A MOTOR VR ASSY (A-A9 Only) u163 PCB PARTS DIAGRAM LIST VR601 A-A9-J http://www.xiaoyu163.com...
Page 37
3 7 63 1515 0 SIDE A CN107 CN803 CN703 CN702 CN705 CN912 CN9913 CN914 CN915 CN916 CN913 CN113 SIDE B L 13942296513 CN912 CN9913 CN914 CN914 CN916 MOTOR VR ASSY (A-A9 Only) SIDE B u163 PCB PARTS DIAGRAM LIST VR601 A-A9-J http://www.xiaoyu163.com...
Q717 Q716 Q706 Q715 Q771 Q765 Q718 Q767 Q766 Q769 Q770 Q720 PROTECTION L-CH ASSY Q704 Q708 Q705 Q707 Q722 CN753 CN705 CN703 u163 CN702 To. Power trans L CN916 CN914 I P R I P R CN915 A-A9-J http://www.xiaoyu163.com...
Page 41
VR702 RELAY701 RY701 ZD701 D9701 ZD702 D9702 ZD703 D9703 ZD704 D9704 LED701 D8701 AMP LCH ASSY LED702 D8702 ZD707 D707 ZD708 D708 L 13942296513 PROTECTION L-CH ASSY u163 CN703 CN705 CN753 CN702 I P R I P R A-A9-J http://www.xiaoyu163.com...
R811 J812 R9812 J866 R866 CN810 CN811 CN812 CN813 J867 R867 Q803 Q807 Q806 Q801 L 13942296513 Q808 Q802 IC804 IC807 CN708 CN818 IC808 IC809 u163 CN803 CN852 CN804 To. Power trans L To. Power trans R CN804 A-A9-J http://www.xiaoyu163.com...
Page 45
SIDE B REG IC ASSY CN801 CN815 CN802 CN803 CN817 CN819 CN818 CN820 PCB PARTS DIAGRAM LIST POWER ASSY J811 R811 J812 R9812 J866 R866 J867 R867 CN813 CN812 CN811 CN810 L 13942296513 CN818 u163 CN804 CN852 CN803 A-A9-J http://www.xiaoyu163.com...
Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k Ω 562 x 10 5621 RN1/4PC 5 6 2 1 LIST OF ASSEMBLIES Mark Symbol and Description A-A9-J A-A6-J 1..PCB TOTAL ASSY 7025HA0604010-IL 7025HA0603010-IL 2.SUB TRANS ASSY 702806535A060-IL 702806535A010-IL 2.HEADPHONE ASSY...
Page 47
D040183083001-IL Not used C857, C858 D040101083070-IL Not used R811 RS1/8S0R0J Not used 7 7 7 7 PCB PARTS LIST FOR A-A9-J UNLESS OTHER WISE NOTED Mark No. Description Part No. Mark No. Description Part No. Q0101, Q0102, Q0104, Q0105 J5410369G0010-IL...
AMP Rch Assy [fig 1.] u163 Caution when transistors (Q713, Q714, Q739 and Q746) are replaced Please cover the leads of the transistors at Silicon bond for the variation prevention of DC Offset when you have exchanged transistors. A-A9-J http://www.xiaoyu163.com...
HEAT SINK is overheated. Check whether IDLE is adjusted at 52mv+/-10mV without load. MOTOR VOLUME is not functioning. Check whether +9V is output at OUT PUT of IC807. Check whether MOTOR DRIVE IC of IC650 is functioning properly. u163 A-A9-J http://www.xiaoyu163.com...
2. Discharge both ends of capacitor of Power Assy by short-circuiting (connector GND and +, connector GND and -) using a resistor with 200Ω/10W (and above) for 30 seconds. Resistor with 200Ω/10W Resistor with 200Ω/10W Resistor to be used REG IC Assy u163 A-A9-J http://www.xiaoyu163.com...
POWER SW POWER SW ASSY ASSY ASSY ASSY HEAD PHONE HEAD PHONE ASSY ASSY L 13942296513 MOTOR VR MOTOR VR ASSY ASSY • Top view REMOCON ASSY FRONT ASSY VR ASSY POWER LED ASSY • Front view u163 A-A9-J http://www.xiaoyu163.com...
Cabinet top cover Remove 13 screws. Remove the cabinet top cover. Cabinet top cover L 13942296513 FUNCTION Ass'y Remove spacers (2 locations) on the board. Remove 7 screws. Remove XM-READY/USB Assy. Remove 2 screws. Remove FUNCTION Assy. Rear view u163 A-A9-J http://www.xiaoyu163.com...
Page 59
3 7 63 1515 0 Front Panel Remove the 6 screws. Remove the 6 screws. Remove the front panel section. L 13942296513 Front panel section u163 A-A9-J http://www.xiaoyu163.com...
Page 60
Remove 4 screws. (Left, Right) the cabinet top cover separates. Remove 4 screws. (Rear section) ×3 L 13942296513 FUNCTION Ass'y Remove 8 screws. Remove spacers (2 locations) on the board. Remove XM-READY/USB Assy. Remove 2 screws. Remove FUNCTION Assy. Rear view u163 A-A9-J http://www.xiaoyu163.com...
Page 61
Front Panel Remove the 2 screws. Remove the 2 screws. (Left, Right) Remove the 5 screws. (Botoom side) Remove the 1 screws. (Botoom side) Remove the flexible cable. Remove the Front panel. ×3 L 13942296513 Bottom view u163 A-A9-J http://www.xiaoyu163.com...
Page 65
VOLUME ENCODER B P21/ANI1 FUNCTION ENCODER A P20/ANI0 FUNCTION ENCODER B P130 POWER LED P04/SCK11 VOLUME CLOCK P03/SI11 USB ON P02/SO11 VOLUME DATA P01/TI010/TO00 TUNER MUTE P00/TI000 DAC MUTE P141/BUZ/INTP7 H/P MUTE P140/PCL/INTP6 H/P DETECT L 13942296513 u163 A-A9-J http://www.xiaoyu163.com...
Selects an input source. Standby indicator MASTER VOLUME Character display Remote sensor DIRECT Press to switch the Direct listening feature on PHONES jack or off. Use to connect headphones (when connected, there is no sound output from speakers). L 13942296513 u163 A-A9-J http://www.xiaoyu163.com...
Page 67
TREBLE BASS - Lights when low-range tone BASS adjustment is applied. 2 Sound Retriever indicator Lights when the Sound Retriever function is enabled. 3 Master volume level 4 Character display Displays various system information. u163 A-A9-J http://www.xiaoyu163.com...