Transmission Oil - RIEJU CITY LINE 125 User Manual

5.3 TRANSMISSION OIL

Check level every 10,000 km (6,200 mi) or 20 months
1) Place vehicle on a level surface on its centre stand.
2) Unscrew dipstick (A - Fig. 26), clean it and refit it, wrenching it
tightly.
3) Pull it out again and check that oil level is between MIN and
MAX notches.
4) If level is insufficient, top up until oil is touching MAX notch.
5) Fill crankcase with oil of following type: Q8 T35 - 80W
Crankcase capacity approx.: 250 cm
after first 1,000 km (620 mi) and every 20,000
Renew
km (12,400 mi)
• Carry out operations described above at points 1-2, without
refitting dipstick; then put a container under engine crankcase
and unscrew drain screw (B - Fig. 27), paying attention to gas-
ket.
• Let oil flow into container (pay attention to avoid scorching).
• Refit drain screw with gasket and fill with approximately 250 cm
of new oil (Q8 T35 - 80W), then refit cap and dipstick (A - Fig.
26)
• Now repeat checks 3-4-5.
If the drain screw gasket is damaged, replace it.
Regularly check for oil leakages near drain screw at the
rear wheel. If you notice any leaks, contact an Author-
ised RIEJU Service Centre.
english
3
3
A
Prevent foreign matters from getting into transmission
crankcase during checks or oil changes. Prevent oil drip-
ping on tires or wheels.
__
MAX
1
Fig. 26
2
3
B
4
Fig. 27
5
6
32