Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Thelin Parlour Direct Vent
Summary of Contents for Thelin Parlour Direct Vent
- Page 1 GAS HEATER SERVICE MANUAL Please familiarize yourself with entire manual before attempting a repair or adjustment of the heaters. Parlour Direct Vent Gnome Direct Vent Echo Direct Vent Thelin Co. Inc. (800) 949-5048 or (530) 273-1976 Fax (530) 273-3707 TH-REF-GEN-200 Rev. A...
-
Page 2: Table Of Contents
THELIN HEARTH PRODUCTS TABLE OF CONTENTS Introduction ..........................5 Venting ..........................5 III. Clearances ..........................6 Gas Hook Up........................6 Log Installation ........................6 Gas Valve – Millivolt Check ....................7 VII. Air Shutter Adjustment, Correct Flame, and Removal of Burner ........7 VIII. Restrictor Disks ........................8 Thermostat Hook Up......................8... - Page 3 Figure 16 – Echo Laboratory Listing Label (to 3/6/2007) .................26 Figure 17 – Echo Laboratory Listing Label (3/7/2007 to Present) ............27 Figure 18 – Parlour Direct Vent Vertical Pipe Installation – Air Intake Restrictor Disks ......28 Figure 19 - Parlour Direct Vent Stove with Burner ...................29 Figure 20 - Pyrotech Log Placement ......................30...
- Page 4 THELIN HEARTH PRODUCTS Figure 45 – Parlour B Vent Wiring Diagram – SIT Valve ................58 Figure 46 – Echo Venting Chart ........................59 Figure 47 – Direct Vent Wiring Diagram (1995 – 2004) ................60 Figure 48 – Direct Vent Dimensions ......................61...
-
Page 5: Introduction
Thelin Hearth Products manufactures three Figure 1 through Figure 10 will give you the models of free-standing gas heaters: the Parlour recommended venting systems for all Thelin Direct Vent, Gnome Direct Vent, and Echo Hearth Products gas heaters. Venting properly is Direct Vent. -
Page 6: Clearances
Figure 11 through Figure 22 will give you the the stove, always test the pressure before proper clearances to combustible surfaces, both lighting the pilot. All Thelin Hearth for the stove and surrounding areas including Products gas valves are equipped with walls, windows, porches, etc. -
Page 7: Gas Valve - Millivolt Check
AIR SHUTTER ADJUSTMENT, CHECK CORRECT FLAME, AND REMOVAL OF BURNER Thelin Hearth Products uses two gas valves on their heaters. Early stoves from 1994 to 1998 Both B Vent and Direct Vent stoves are have Robert Shaw valves. All current models equipped with air shutters that allow for fine are equipped with SIT valves. -
Page 8: Viii. Restrictor Disks
INSTALLATION Thelin Hearth Products Direct Vent stoves are equipped with incoming air Restrictor disks so All Thelin Hearth Products gas stoves can be you can fine tune the combustion air and converted from LP gas to natural gas, or from prevent air turbulence at the pilot light. -
Page 9: General Maintenance
In conclusion, we would like to remind you that these can accumulate dust and lint, affecting Thelin Hearth Products can provide support via the performance of the fan. Clean as telephone. Service personnel are welcome to use necessary. -
Page 10: Warranty Replacement Program
Some Any replacement parts required may be obtained states do not allow the exclusions or limitation from Thelin Hearth Products and will require a or incidental consequential damages, so the purchase order. Parts will be invoiced to the... - Page 11 THELIN HEARTH PRODUCTS Thelin Hearth Products warrants the Pellet & Gas Heater against defects in material and workmanship for a period of five (5) years from the date of purchase with the exception of the electrical components, gaskets, logs, moving parts, gas valve and control, and burner which are warranted for a period of one (1) year from date of purchase.
-
Page 12: Figure 1 - Parlour B Vent Exterior Vent (1994 - 2001)
THELIN HEARTH PRODUCTS FIGURE 1 – PARLOUR B VENT EXTERIOR VENT (1994 - 2001) Gas Heater Service Manual... -
Page 13: Figure 2 - Parlour Direct Vent Exterior Vent
THELIN HEARTH PRODUCTS FIGURE 2 – PARLOUR DIRECT VENT EXTERIOR VENT Gas Heater Service Manual... -
Page 14: Figure 3 - Gnome Direct Vent Exterior Vent
THELIN HEARTH PRODUCTS FIGURE 3 – GNOME DIRECT VENT EXTERIOR VENT Gas Heater Service Manual... -
Page 15: Figure 4 - Echo Venting Requirements
THELIN HEARTH PRODUCTS FIGURE 4 – ECHO VENTING REQUIREMENTS Gas Heater Service Manual... -
Page 16: Figure 5 - Echo Venting Requirements
THELIN HEARTH PRODUCTS FIGURE 5 – ECHO VENTING REQUIREMENTS FIGURE 6 – ECHO CO-LINEAR FLEX SYSTEM Gas Heater Service Manual... -
Page 17: Figure 7 - Parlour Direct Vent Pipe Configuration
THELIN HEARTH PRODUCTS FIGURE 7 – PARLOUR DIRECT VENT PIPE CONFIGURATION Gas Heater Service Manual... -
Page 18: Figure 8 - Gnome Direct Vent Pipe Configuration
THELIN HEARTH PRODUCTS FIGURE 8 – GNOME DIRECT VENT PIPE CONFIGURATION Gas Heater Service Manual... -
Page 19: Figure 9 - Echo Pipe Configurations
THELIN HEARTH PRODUCTS FIGURE 9 – ECHO PIPE CONFIGURATIONS Gas Heater Service Manual... -
Page 20: Figure 10 - Vent Termination For B Vent And Direct Vent
THELIN HEARTH PRODUCTS FIGURE 10 – VENT TERMINATION FOR B VENT AND DIRECT VENT Roof Pitch H (Min.) Ft. Flat to 6/12 ..........1.0 Over 6/12 to 7/12 ........1.25 Over 7/12 to 8/12 ........1.5 Over 8/12 to 9/12 ........2.0 Over 9/12 to 10/12 ........2.5 Over 10/12 to 11/12 ........3.25... -
Page 21: Figure 11 - Parlour B Vent Laboratory Listing Label (1994 - 2001)
THELIN HEARTH PRODUCTS FIGURE 11 – PARLOUR B VENT LABORATORY LISTING LABEL (1994 – 2001) Gas Heater Service Manual... -
Page 22: Figure 12 - Parlour Direct Vent Laboratory Listing Label (1995 - 2004)
THELIN HEARTH PRODUCTS FIGURE 12 – PARLOUR DIRECT VENT LABORATORY LISTING LABEL (1995 – 2004) Gas Heater Service Manual... -
Page 23: Figure 13 - Parlour Direct Vent Laboratory Listing Label (Omni) (2004+)
THELIN HEARTH PRODUCTS FIGURE 13 – PARLOUR DIRECT VENT LABORATORY LISTING LABEL (OMNI) (2004+) Gas Heater Service Manual... -
Page 24: Figure 14 - Gnome Direct Vent Laboratory Listing Label (1995 - 2004)
THELIN HEARTH PRODUCTS FIGURE 14 – GNOME DIRECT VENT LABORATORY LISTING LABEL (1995 – 2004) Gas Heater Service Manual... -
Page 25: Figure 15 - Gnome Direct Vent Laboratory Listing Label (Omni) (2004+)
THELIN HEARTH PRODUCTS FIGURE 15 – GNOME DIRECT VENT LABORATORY LISTING LABEL (OMNI) (2004+) Gas Heater Service Manual... -
Page 26: Figure 16 - Echo Laboratory Listing Label (To 3/6/2007)
THELIN HEARTH PRODUCTS FIGURE 16 – ECHO LABORATORY LISTING LABEL (TO 3/6/2007) Gas Heater Service Manual... -
Page 27: Figure 17 - Echo Laboratory Listing Label (3/7/2007 To Present)
THELIN HEARTH PRODUCTS FIGURE 17 – ECHO LABORATORY LISTING LABEL (3/7/2007 TO PRESENT) Gas Heater Service Manual... -
Page 28: Figure 18 - Parlour Direct Vent Vertical Pipe Installation - Air Intake Restrictor Disks
THELIN HEARTH PRODUCTS FIGURE 18 – PARLOUR DIRECT VENT VERTICAL PIPE INSTALLATION – AIR INTAKE RESTRICTOR DISKS Gas Heater Service Manual... -
Page 29: Figure 19 - Parlour Direct Vent Stove With Burner
THELIN HEARTH PRODUCTS FIGURE 19 - PARLOUR DIRECT VENT STOVE WITH BURNER Gas Heater Service Manual... -
Page 30: Figure 20 - Pyrotech Log Placement
THELIN HEARTH PRODUCTS FIGURE 20 - PYROTECH LOG PLACEMENT 1. Ember bed installed with brick panel. 2. Install rear log #2 against brick panel and center right to left. 3. Place small log, #3, with the notch on the 4. Rest the “Y” log, #4, on top of the small... - Page 31 THELIN HEARTH PRODUCTS FIGURE 20 – PYROTECH LOG PLACEMENT (CONTINUED) 5. Place the front log #5 against the “Y” log in the notch shown in the illustration with the bottom end up against the lip of the door opening. Note: The bottom of the log has the taper cut.
-
Page 32: Figure 21 - Direct Vent Gas Heater Vent Termination Locations (1994 - 2004)
THELIN HEARTH PRODUCTS FIGURE 21 – DIRECT VENT GAS HEATER VENT TERMINATION LOCATIONS (1994 – 2004) The horizontal run must have a 1/4” rise on an G. Do not install above a meter/regulator exterior wall and must meet all local and national... -
Page 33: Figure 22 - Vent Termination Locations (Omni) (2004+)
THELIN HEARTH PRODUCTS FIGURE 22 – VENT TERMINATION LOCATIONS (OMNI) (2004+) Gas Heater Service Manual... -
Page 34: Figure 23 - Parlour B Vent Sit Valve (Serial # 543-Om)
THELIN HEARTH PRODUCTS FIGURE 23 – PARLOUR B VENT SIT VALVE (SERIAL # 543-OM) Pressure Test Taps Gas Heater Service Manual... -
Page 35: Figure 24 - Parlour B Vent Robert Shaw Valve (Serial # 100-542)
THELIN HEARTH PRODUCTS FIGURE 24 – PARLOUR B VENT ROBERT SHAW VALVE (SERIAL # 100-542) Gas Heater Service Manual... -
Page 36: Figure 25 - Parlour And Gnome Direct Vent Sit Valve
THELIN HEARTH PRODUCTS FIGURE 25 – PARLOUR AND GNOME DIRECT VENT SIT VALVE Gas Heater Service Manual... -
Page 37: Figure 26 - Parlour And Gnome Direct Vent Robert Shaw Valve
THELIN HEARTH PRODUCTS FIGURE 26 – PARLOUR AND GNOME DIRECT VENT ROBERT SHAW VALVE Gas Heater Service Manual... -
Page 38: Figure 27 - Diagram Of Echo Control Components (Sit Valve)
THELIN HEARTH PRODUCTS FIGURE 27 – DIAGRAM OF ECHO CONTROL COMPONENTS (SIT VALVE) Gas Heater Service Manual... -
Page 39: Figure 28 - Diagram Of Echo Control Components (Air Restrictor)
THELIN HEARTH PRODUCTS FIGURE 28 – DIAGRAM OF ECHO CONTROL COMPONENTS (AIR RESTRICTOR) 1. 15% Open 2. 25% Open 3. 85% Open Position 1: Use Only When 2 or More Elbows in Pipe Run Position 2: 1 – 12 Ft. -
Page 40: Figure 29 - Parlour B Vent Air Shutter And Manifold/Valve - Sit Valve (Bottom View)
Factory installed orifices are as follows: Natural Gas #36 (up to 4,500’ elevation) LP Gas #52 (up to 4,500’ elevation) Recommendation: If installing at higher altitudes, Thelin Hearth Products recommends, at the discretion of the installer: Natural Gas #37 (5,000’ to 7,000’ elevation) LP Gas #53 (5,000’... -
Page 41: Figure 30 - Parlour B Vent Log Placement And Air Shutter Adjust
THELIN HEARTH PRODUCTS FIGURE 30 – PARLOUR B VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Gas Heater Service Manual... -
Page 42: Figure 31 - Parlour Direct Vent Log Placement And Air Shutter Adjust
THELIN HEARTH PRODUCTS FIGURE 31 – PARLOUR DIRECT VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Gas Heater Service Manual... -
Page 43: Figure 32 - Gnome Direct Vent Log Placement And Air Shutter Adjust
THELIN HEARTH PRODUCTS FIGURE 32 – GNOME DIRECT VENT LOG PLACEMENT AND AIR SHUTTER ADJUST Gas Heater Service Manual... -
Page 44: Figure 33 - Echo Stove With Log & Ember Tray Placement
THELIN HEARTH PRODUCTS FIGURE 33 – ECHO STOVE WITH LOG & EMBER TRAY PLACEMENT Following is a step-by-step procedure for installing the Echo log set: 1. Remove top lid and top from stove. 2. Install Log #1 as per picture below. - Page 45 THELIN HEARTH PRODUCTS ECHO STOVE WITH LOG PLACEMENT (CONTINUED) 7. Install Ember Basket as per picture below. 8. Install Embers as per picture below. Make sure all logs are secure and not impinging on the burner tubes. Re-install glass door, top, and lid.
-
Page 46: Figure 34 - Echo Stove With Log & Ember Tray Placement
THELIN HEARTH PRODUCTS FIGURE 34 - ECHO STOVE WITH LOG & EMBER TRAY PLACEMENT Following is a step-by-step procedure for installing the Echo log set: 1. Remove top lid and top from stove. 2. Install Log #1 as per picture below. - Page 47 THELIN HEARTH PRODUCTS FIGURE 34 - ECHO STOVE WITH LOG & EMBER TRAY PLACEMENT (CONT’D) 7. Make sure all logs are secure and not impinging on the burner. Re-install glass door, top, and lid. You are ready to light your Echo!
-
Page 48: Figure 35 - Parlour B Vent Manifold/Valve - Robert Shaw Valve (Bottom View)
Factory installed orifices are as follows: Natural Gas #36 (up to 4,500’ elevation) LP Gas #52 (up to 4,500’ elevation) Recommendation: If installing at higher altitudes, Thelin Hearth Products recommends, at the discretion of the installer: Natural Gas #37 (5,000’ to 7,000’ elevation) LP Gas #53 (5,000’... -
Page 49: Figure 36 - Parlour And Gnome Stove With Burner Removed
THELIN HEARTH PRODUCTS FIGURE 36 – PARLOUR AND GNOME STOVE WITH BURNER REMOVED Gas Heater Service Manual... -
Page 50: Figure 37 - Location Of Echo Pilot, Burners, And Air Shutter
THELIN HEARTH PRODUCTS FIGURE 37 – LOCATION OF ECHO PILOT, BURNERS, AND AIR SHUTTER Gas Heater Service Manual... -
Page 51: Figure 38 - Directions For Enabling Echo Door Opening And Securing Door
THELIN HEARTH PRODUCTS FIGURE 38 – DIRECTIONS FOR ENABLING ECHO DOOR OPENING AND SECURING DOOR 1. Remove stove top to access glass door (Figure 39). 2. Unhook latch at bottom of door. 3. Lift door up and out. Gas Heater Service Manual... -
Page 52: Figure 39 - Delayed Echo Ignition Safety Shut Down
THELIN HEARTH PRODUCTS FIGURE 39 – DELAYED ECHO IGNITION SAFETY SHUT DOWN Gas Heater Service Manual... -
Page 53: Figure 40 - Location Of Restrictor Disks In Parlour And Gnome (1995 - 2004)
THELIN HEARTH PRODUCTS FIGURE 40 – LOCATION OF RESTRICTOR DISKS IN PARLOUR AND GNOME (1995 – 2004) 1. Burner must be removed to access restrictor disks. 2. Loosen 7/16 nut and adjust disk to cover air intake tube opening. 3. The higher the vertical pipe run the more the restriction (See Below). -
Page 54: Figure 41 - Location Of Restrictor Disks In Parlour And Gnome (2004+)
THELIN HEARTH PRODUCTS FIGURE 41 – LOCATION OF RESTRICTOR DISKS IN PARLOUR AND GNOME (2004+) Gas Heater Service Manual... -
Page 55: Figure 42 - Parlour/Gnome Direct Vent Delayed Ignition, Fan Mount, Snap Disc Sensor (1995-2004)
THELIN HEARTH PRODUCTS FIGURE 42 – PARLOUR/GNOME DIRECT VENT DELAYED IGNITION, FAN MOUNT, SNAP DISC SENSOR (1995-2004) FAN REMOVAL Remove outer jacket (label wires before removing). Disconnect wires to fan motor. Remove two screws at base of a mounting bracket. -
Page 56: Figure 43 - Delayed Ignition Safety Shut Down (2004+)
THELIN HEARTH PRODUCTS FIGURE 43 – DELAYED IGNITION SAFETY SHUT DOWN (2004+) This unit is equipped with a safety shut down system that will disable the stove in the event pressure builds up and the stove ignites with delayed combustion. If this happens, you must have a qualified service person determine the cause of the delayed ignition. -
Page 57: Figure 44 - Parlour B Vent Wiring Diagram - Robert Shaw Valve
THELIN HEARTH PRODUCTS FIGURE 44 – PARLOUR B VENT WIRING DIAGRAM – ROBERT SHAW VALVE Gas Heater Service Manual... -
Page 58: Figure 45 - Parlour B Vent Wiring Diagram - Sit Valve
THELIN HEARTH PRODUCTS FIGURE 45 – PARLOUR B VENT WIRING DIAGRAM – SIT VALVE Gas Heater Service Manual... -
Page 59: Figure 46 - Echo Venting Chart
THELIN HEARTH PRODUCTS FIGURE 46 – ECHO VENTING CHART Gas Heater Service Manual... -
Page 60: Figure 47 - Direct Vent Wiring Diagram (1995 - 2004)
THELIN HEARTH PRODUCTS FIGURE 47 – DIRECT VENT WIRING DIAGRAM (1995 – 2004) Gas Heater Service Manual... -
Page 61: Figure 48 - Direct Vent Dimensions
THELIN HEARTH PRODUCTS FIGURE 48 – DIRECT VENT DIMENSIONS Gas Heater Service Manual... -
Page 62: Appendix A - Sit Valve Troubleshooting Guide
THELIN HEARTH PRODUCTS APPENDIX A SIT VALVE TROUBLESHOOTING GUIDE Gas Heater Repair Manual... -
Page 63: Appendix B - Conversion Kit Instructions
THELIN HEARTH PRODUCTS APPENDIX B CONVERSION KIT INSTRUCTIONS Gas Heater Repair Manual... - Page 64 THELIN HEARTH PRODUCTS CONVERSION KIT PARLOUR 3000 B VENT WITH ROBERT SHAW VALVE Conversion from Natural Gas to Propane or Conversion from Propane to Natural Gas WARNING The Conversion Kit contains: Regulator, Pilot Orifice, Main Orifice, and Gas Type Labels.
- Page 65 THELIN HEARTH PRODUCTS CONVERSION KIT ROBERT SHAW VALVE PARLOUR 3000 DIRECT VENT AND GNOME DIRECT VENT Conversion from Natural Gas to Propane or Conversion from Propane to Natural Gas The conversion kit contains: Regulator, Pilot Orifice, Main Orifice, WARNING and Gas Type Labels.
- Page 66 THELIN HEARTH PRODUCTS CONVERSION KIT SIT VALVE PARLOUR DIRECT VENT, GNOME DIRECT VENT, PARLOUR B VENT, AND ECHO Conversion from Natural Gas to Propane or Conversion from Propane to Natural Gas The conversion kit contains: Regulator, Pilot Orifice, Main Orifice, WARNING and Gas Type Labels.
Need help?
Do you have a question about the Parlour Direct Vent and is the answer not in the manual?
Questions and answers