Maintenance - Polaris ATV 2001 Owner's Manual

Spark Arrestor
When cleaning the spark arrestor, you must follow the safe-
guards listed below to avoid serious injury or death.
D Do not perform this operation immediately after the en-
gine has been run because the exhaust system be-
comes very hot.
D Because of the increased fire hazard, make sure that
there are no combustible materials in the area when
purging the spark arrestor.
D Wear eye protection.
D Do not stand behind or in front of the vehicle while
purging the carbon from the spark arrestor.
D Never run the engine in an enclosed area. The exhaust
contains poisonous carbon monoxide gas.
D Do not go under the machine while it is inclined.
D Keep combustible materials away from exhaust system.
Fire may result.
Spark Arrestor
The exhaust pipe must be periodically purged of accumulated car-
bon as follows:
1. Remove the clean out plugs (1) located on the bottom of the
muffler as shown above.
2. Place the transmission in neutral and start the engine. Purge
accumulated carbon from the system by momentarily revving
the engine several times.
3. If some carbon is expelled, cover the exhaust outlet and rap on
the pipe around the clean out plugs while revving the engine
several more times.

MAINTENANCE

96