Porter-Cable PCC510 Instruction Manual page 8

90582820 PCC510 18V OScillating Tool manual.qxd:??????-00 Cir Saw book
• Do not place any object on top of charger or place the charger on a soft surface that might
sure each individual extension contains at least the minimum wire size.
block the ventilation slots and result in excessive internal heat. Place the charger in a
position away from any heat source. The charger is ventilated through slots in the top and the
• Do not mount charger on wall or permanently affix charger to any surface. The charger is
bottom of the housing.
• Do not operate charger with damaged cord or plug — have them replaced immediately.
intended to use on a flat, stable surface (i.e., table top, bench top).
• Do not operate charger if it has received a sharp blow, been dropped, or otherwise
• Do not disassemble charger; take it to an authorized service center when service or repair is
damaged in any way. Take it to an authorized service center.
• Disconnect the charger from the outlet before attempting any cleaning. This will reduce the
required.Incorrect reassembly may result in a risk of electric shock, electrocution or fire.
• NEVER attempt to connect 2 chargers together.
risk of electric shock.Removing the battery pack will not reduce this risk.
• The charger is designed to operate on standard household electrical power (120Volts). Do
not attempt to use it on any other voltage.
IMPORTANT SAFETY INSTRUCTION FOR BATTERY PACKS
:
The battery pack is not fully charged out of the carton. Before using the battery pack
with tool before using the charger.
and charger, read the safety instructions below. Then follow charging procedures outlined.
• Do not incinerate the battery pack even if it is severely damaged or is completely
worn out. The battery pack can explode in a fire. Toxic fumes and materials are
• Do not charge or use battery in explosive atmospheres,such as in the presence of flammable
created when LI-ION battery packs are burned.
• If battery contents come into contact with the skin, immediately wash area with
liquids,gases or dust. Inserting or removing the battery from the charger may ignite the dust or fumes.
mild soap and water. If battery liquid gets into the eye, rinse water over the open eye
for 15 minutes or until irritation ceases. If medical attention is needed, the battery
electrolyte for LI-ION batteries is composed of a mixture of liquid organic carbonates
• Contents of opened battery cells may cause respiratory irritation. Provide fresh
and lithium salts. For NI-CD batteries it is a 25-35% solution of potassium hydroxide.
air. If symptoms persists, seek medical attention.
• Charge the battery packs only in PORTER-CABLE chargers.
:
Burn hazard. Battery liquid may be flammable if exposed to spark or flame.
• DO NOT splash or immerse in water or other liquids. This may cause premature cell failure.
• Do not store or use the tool and battery pack in locations where the temperature may reach
or exceed 105°F (40˚C) (such as outside sheds or metal buildings in summer).
:
Never attempt to open the battery pack for any reason.If battery pack case is
cracked or damaged, do not insert into charger.Do not crush, drop or damage battery pack.Do not
use a battery pack or charger that has received a sharp blow, been dropped, run over or damaged
in any way (i.e., pierced with a nail, hit with a hammer, stepped on).Damaged battery packs should
be returned to service center for recycling.
Battery storage and carrying caps are provided for use
BATTERY CAP INFORMATION
whenever the battery is out of the tool or charger. Remove
cap before placing battery in charger or tool.
:
battery so that metal objects can contact exposed battery terminals. For example,
do not place battery in aprons, pockets, tool boxes, product kit boxes, drawers, etc., with
loose nails, screws, keys, etc. Transporting batteries can possibly cause fires if the
battery terminals inadvertently come in contact with conductive materials such as
keys, coins, hand tools and the like. The US Department of Transportation Hazardous
SAVE THESE INSTRUCTIONS
For safe operation, read this manual and manuals originally supplied
READ ALL INSTRUCTIONS
Fire hazard. Do not store or carry
8
12/13/11
Battery Cap
9:12 AM