Front Panel; Controller Assembly - Electrolux IQ-Touch Wave-Touch EIFLW55H Technical & Service Manual

Front Panel Removal
The front panel is secured to the unit frame with
screws along the front bottom edge and top left and
right corners. Two plastic retainers along each side
of the front panel prevent the panels from vibrating
and creating noise.
To remove the front panel:
1. Remove the top panel and control console.
2. Remove the loop spring and release the
bellows from the front panel.
3. Disconnect the Molex connector leading to the
wire harness of the door latch at the upper
right hand corner next to the controller
assembly.
4. Using a #2 square bit screwdriver, extract
the four screws along the bottom front edge.
(See Figure 4-27)
5. Extract the six screws along the top front
edge. (See Figure 4-27)
6. Lift up then pull the front panel off of the
plastic retainers and remove from unit.
Controller Assembly Removal
The controller assembly is secured with a screw to
unit frame along the top right front edge. The wire
harness connects to the controller board with three
Molex connectors through the controller box and
four Molex connectors under the controller box lid.
To remove the controller assembly:
1. Remove the top panel and control console.
2. Disconnect the Molex connector leading to the
wire harness of the door latch at the upper
right hand corner next to the controller
assembly.
3. Disconnect Molex connectors from outside
controller box
4. Release retaining latches of controller box and
open lid.
5. From inside controller box, push back on the
connector retainers and disconnect Molex
connections from controller board.
6. Using a #2 square bit screwdriver, extract
the screw securing the controller box to the
unit frame and remove from unit.
(See Figure 4-28)
7. To remove the circuit board from the controller
box, release the four retaining latches securing
the controller box together and pull apart.
8. Push back the retainers securing the circuit
board and pull carefully from controller box.
Component Teardown
Figure 4-27.
Electrical Connections
Figure 4-28.
4-11
Screws
Screws
Screw