Table Of Contents - Warmland PS45 Classic Series A Installation And Operating Instructions Manual

PLEASE READ THIS ENTIRE OWNER'S MANUAL BEFORE INSTALLING OR OPERATING
YOUR WARMLAND PELLET STOVE.
Introduction ................................................. 3
Specifi cations ............................................. 3
Listing information .......................................... 3
Heating Specifi cations .................................... 3
Electrical ......................................................... 3
Negative Pressure Warning........................ 4
Pellet Fuel Specifi cations .......................... 4
Stove Dimensions ....................................... 5
Installation ................................................... 6
Before You Begin ............................................ 6
Installation Options .................................... 6
Selecting a Location ....................................... 6
Hearth Protection ....................................... 6
Clearances to Combustibles ..................... 7
Clearances ..................................................... 7
Alcove Installations ......................................... 7
Vent Termination Requirement .................. 9
Venting........................................................10
Installing into a Wood Stove Pipe ................. 10
Installing into a Masonry Chimney ................ 10
Outside Air ................................................10
Thermostat installation ............................ 12
Operation ................................................... 12
Filling the Hopper ......................................... 12
Control Board ................................................ 12
General Operation ........................................ 13
Thermostat Operation ................................... 13
Manual Mode ................................................ 13
Paint Curing .............................................. 13
Plated Surfaces ......................................... 13
Routine Checks and Maintenance .......... 14
Fire-Pot and Liner Cleaning .......................... 14
Cleaning Glass ............................................. 15
Ash Pan Removal and Cleaning ................... 15
Inspect Gaskets ............................................ 15
Cleaning the Heat Exchanger ....................... 15
Cabinet Side Removal .................................. 16
Cleaning the Flue Gas Passages ................. 16
Cleaning the Firebox Passage: ..................... 16
Cleaning the Vent Pipe ................................. 16
Cleaning the Combustion Blower: ................ 17
Cleaning the Convection Blower: .................. 17
Door Removal ............................................... 17
Back Grill Removal ....................................... 17
PELLET STOVES
Contents
Component Information ........................... 18
Igniter ............................................................ 18
Vacuum Switch ............................................. 18
Auger and Auger Motor ................................. 18
High Limit Snap Switch (Manual Reset) ....... 18
Proof of Fire Snap Switch ............................. 18
Draft Damper ................................................ 18
Burn-PotMixer Motor ..................................... 18
Hopper Switch...............................................18
Wiring Diagram ......................................... 19
Components List
Components List ..................................... 21
Rating Label .............................................. 23
2
........................
PS45 CLASSIC 151211-24
20