Related Manuals for Bukh DV36 ME
Summary of Contents for Bukh DV36 ME
- Page 1 OWNER'S HANDBOOK BUKH MARINE DIESEL LIFEBOAT ENGINE TYPE DV36 ME BUKH A/S Aabenraavej 13 - 17 DK - 6340 Krusaa Tel: +45 74 62 20 88 Fax: +45 74 62 74 07 E-mail: bukh@bukh.dk www.bukh.dk 009W0327-R03...
-
Page 2: Table Of Contents
OPERATING MANUAL FOR BUKH DV36ME ENGINES CONTENTS Page Pictures for recognition of engine ..........3 Introduction .................. 4 Standard equipment ..............4 Operating manual ................. 4 Preparation for the first start............5 Before start ................... 5 Electric start ................. 5 Hand start .................. -
Page 3: Pictures For Recognition Of Engine
OPERATING MANUAL FOR BUKH DV36ME ENGINES Lubricating oil filling plug Valve cover Electric stop solenoid Air filter with noise suppression Fuel filter Cooling water drain plug Dipstick for engine oil Oil pressure switch Lubricating oil filter 10. Fuel pump 11. Control lever 12. -
Page 4: Introduction
If a problem with the engine should arise, we ask you to apply to one of our distributors, who will always be ready to help you, having skilled personnel, necessary tools etc., and at the same time you will be sure that only original BUKH spare parts are used. -
Page 5: Preparation For The First Start
Unscrew the filler plug and pour in oil until the bearing is full. Important:The stuffing box shall under no circumstances be force-lubrica- ted. These instructions are only valid for propeller equipment supplied by BUKH. If other equipment is mounted, we refer to the instructions given for this. -
Page 6: After Start
OPERATING MANUAL FOR BUKH DV36ME ENGINES After Start When the engine has started, the RPM should be 900-1000 RPM when idling. Check the oil pressure. Normally this should be 2-4.5 bar. With cold engine the RPM should be kept down so that the oil pressure does not exceed 4.5 bar. -
Page 7: Fuel Lift Pump
OPERATING MANUAL FOR BUKH DV36ME ENGINES Fuel lift pump The fuel lift pump is a cam shaft driven sealed type diaphragm pump, which cannot be dismantled for repair or cleaning. It is recommended to install a water/dirt accumulating filter in the suction line to the pump. -
Page 8: Freshwater Cooling
OPERATING MANUAL FOR BUKH DV36ME ENGINES Freshwater cooling When using freshwater cooling it will be possible to reach a higher operating temperature of 70-95°C which will prolong the life of the engine. This cooling system is recommended for engines operating for more than 500 hours a year. -
Page 9: Propeller Equipment
OPERATING MANUAL FOR BUKH DV36ME ENGINES Propeller equipment (As supplied by BUKH – for other types consult individual manufacturer’s instructions) Flexible stern tube: Every three years replace the three seal rings in the stuffing box “A” and the rubber hose “B” connecting stuffing boxand inter- mediate tube “C”... -
Page 10: Galvanic Corrosion
Starting instructions for BUKH Diesel Engine type DV36ME Electric start: Switch on the main switch. -
Page 11: Winter Storage Of The Engine
OPERATING MANUAL FOR BUKH DV36ME ENGINES WINTER STORAGE OF THE ENGINE 1. Carry out the following whilst the boat is still in the water: Run the engine until normal workingtemperature is reached. Drain off engine and gear oil with the oil bilge pump. -
Page 12: Technical Data For Engine And Gearbox
OPERATING MANUAL FOR BUKH DV36ME ENGINES DV36ME TECHNICAL MAIN DATA WORKING PRINCIPLE………………………………………………………………………..…4-STROKE NUMBER OF CYLINDERS ....................3 CYLINDER BORE/STROKE ..................... 85 mm / 85 mm CYLINDER VOLUME ......................1.447 Litres COMPRESSION RATIO ....................18,5:1 COMPRESSION PRESSURE ... -
Page 13: Recommended Maintenance And Checklist
OPERATING MANUAL FOR BUKH DV36ME ENGINES RECOMMENDED MAINTENANCE AND A CHECK LIST FOR BUKH ENGINES EVERY CHECK RECTIFY IF NEEDED YEARS Tightness of connections through hull: stern tube hull connection change sealing Check of lubricating oil: 2.1 a engine change oil 2.1.b engine... -
Page 14: Irregular Operation
OPERATING MANUAL FOR BUKH DV36ME ENGINES IRREGULAR OPERATION - CAUSES AND REMEDIES 1. Engine does not start SYMPTOM CAUSE REMEDY Insufficient or very little compression Inlet and/or exhaust valves leaking Grind or replace the valves, mill the seats Grease valve stems with 2/3 gas oil and 1/3 Inlet and/or exhaust valves sticking lub. -
Page 15: Lubricating Oil Chart
OPERATING MANUAL FOR BUKH DV36ME ENGINES LUBRICATING OIL CHART Lubricating oil for Auxili- engine: aries temp range OIL COMPANY OIL TYPE HD OIL GRADE & QUALITY BP OIL VISCO 5000 SAE 5W-40 API SJ/CF BP OIL Vanellus C4 Global SAE 15W-40 API CF-4/CF/SG... -
Page 16: El-Diagram
OPERATING MANUAL FOR BUKH DV36ME ENGINES - 16 - 009W0327-R03... -
Page 17: Dv36 Installation
OPERATING MANUAL FOR BUKH DV36ME ENGINES Installation: DV36 - 17 - 009W0327-R03... -
Page 18: List Of Representatives
OPERATING MANUAL FOR BUKH DV36ME ENGINES BUKH DISTRIBUTORS – WORLDWIDE Fiala & Cia. S.R.L. Tel: +54-11-4328-1474 / 6280 Av. Presidente Roque Saenz Peña 710 Fax: +54-11-4328-2838 Piso 3º “D” E-mail: info@fialaycia.ar 1035 Buenos Aires ARGENTINA Bukh Diesel Australia Pty. Ltd. - Page 19 OPERATING MANUAL FOR BUKH DV36ME ENGINES Montmontaza Greben d.o.o. Tel: +385-20-812-028 Obala 4 Br. 50 Fax: +385-20-813-354 20270 Vela Luka E-mail: sales@greben.hr CROATIA Website: www.greben.hr Imocom Ecuatoriana Cia. Ltda. Tel: +593-2-447662 Casilla 17-17-292 Fax: +593-2-447664 Quito E-mail: imocom@uio.satnet.net ECUADOR Contact: Peter Bachmann...
- Page 20 OPERATING MANUAL FOR BUKH DV36ME ENGINES Scandiesel Tel: +39-0321-777880 Via Coloredo 38 Fax: +39-0321-777959 28069 Trecate (NO) E-mail: info@scandiesel.it ITALY Website: www.scandiesel.it Contact: Attilio Origo, Tiziana Dellera Mizuno Marine Co Ltd Tel: +81-6-6863-5233 1-12-15 Meishinguchi Toyonaka-City Fax: +81-6-6863-5029 Osaka 561-0841 E-mail: mizuno@mizuno-marine.co.jp...
- Page 21 OPERATING MANUAL FOR BUKH DV36ME ENGINES Civic International Pte Ltd Tel: +65-6861-7633 38 Benoi Place Fax: +65-6861-5069 Singapoe 629952 E-mail: chee_keong_chia@civic.com.sg SINGAPORE E-mail: civicint@singnet.com.sg Contact: Chia Chee Keong / Han Jock Kwong Keppel Sea Scan Pte Ltd Tel: +65-6863-0788 No. 44 Benoi Road...
-
Page 22: General Terms Of Sale And Delivery
factory and until full payment has been effected. 3. Orders Any order shall be confirmed in writing by Bukh A/S in 7. Remedying Defects order that an agreement on consignments can be If the consignment should prove defective, Bukh A/S considered as binding. undertakes during the first 24 months after the ...