Page 1
Operator’s Manual WY 36 Commercial Mower Worldlawn Power Equipment, Inc. 422 Turnbull Canyon Road, City of Industry, CA 91744 Toll Free Number:1-866-9-Mowers(1-866-966-9377)
Page 2
OPERATOR’S MANUAL This manual contains assembly, operating, maintenance, adjustment and safety instructions for your WY36 lawn mower. Before operating your mower, carefully read this manual in its entirety. By following the operating, maintenance, adjustment and safety instructions, you will prolong the life of your mower, maintain its maximum efficiency and promote safe operation .
Only use accessories and be followed to avoid accidents. This symbol attachments approved by means: Worldlawn Power Equipment, Inc. ATTENTION! BECOME ALERT! 1.3.2 The use of personal protective equipments, YOUR SAFETY IS INVOLVED! safety...
area where dangerous carbon monoxide fumes can · Purchase and store gasoline only in an approved collect. container. · Always place gasoline containers on the ground away from your vehicle while filling. · Do not fill gasoline containers inside a vehicle or on a truck or trailer bed because interior carpets or POTENTIAL HAZARD plastic truck bed liners may insulate the container...
Page 7
Although hazard control and accident prevention 1.4.2 Mow only in daylight or good artificial light, partially are dependent upon the design and keeping away from holes and hidden hazards. configuration of the equipment, these factors are also NEVER carry passengers.DO not operate the mower dependent upon the awareness, concern, prudence, when children or others are in the area! and proper training of the personnel involved in the...
that change the operating angle, as rough terrain Keep all others away from mower during operation. could overturn the machine. 1.4.15 DO NOT mow with the discharge deflector Use extreme care with grass catchers or raised, removed, or altered unless there is a grass attachments.
Page 9
Location 3:On the Mower Deck 1.6.4 New safety signs may be obtained from your authorized equipment dealer or distributor or from Worldlawn Power Equipment, Inc. 1.6.5 Safety signs may be affixed by peeling off the backing to expose the adhensive surface. Apply only to clean, dry surface.
Page 10
Location 13:On the Mower Deck Location 8:On the Mower Deck Location 14:Rear of Console Location 9:Top Front of Console Location 10:On the Console (Electric) Location 15:On the cover Location 11:Rear of LH console frame Location 16:on the console Location 12:Rear of RH console frame Location 17:In the front of the mower deck...
Transmissions: Peerless 5-speed transmission, Model #700-079 Steering/Travel Control: Clutch/brake fingertip steering, key lock switch. Brakes: 6″brake drum,band brake, one on each wheel. Safety Group: Hand actuated operator presence Location 18:In the front of the fuel tank system with blade clutch and transmission interlock to engine kill.
steering lever switch with both hands, release right and left neutral latched,release right and left steering lever to make move forward. When the steering levers are released, the mower will travel straight forward. To make right turn, squeeze the steering lever RH. To turn left, squeeze the steering lever LH.
Throttle control lever Operator presence lever Blade drive lever Latch, right Key switch 2.8 Approximate Dimensions: Steering lever 2.8.1 Width: Discharge chute down 46.6in (118cm) Fuel tank Latch, left Discharge chute up 39.3in (100cm) Clamp Steering lever Handle bar assembly 2.8.2 Overall Length: 71.6in (182.0cm)...
catcher mount weldment to the pin on the mower necessary inspection and maintenance steps. deck,turn the pin at a 90 degree angle, insert it Check tire pressure in drive wheels. Proper into the hole on the grass catcher mount inflation pressure for tires is 20psi(140kpa) weldment.See FIG8 Check tire pressure in caster wheels.
POTENTIAL HAZARD POTENTIAL HAZARD While maintenance or adjustments are being · An uncovered discharge opening will allow objects · made, someone could start the engine. to be thrown in an operator’s or bystander’s direction. Also, contact with the blade could occur. WHAT CAN HAPPEN Accidental starting of the engine could ·...
POWER EQUIPMENT SERVICE DEALER. It is Start the engine and check for leaks. Stop engine essential that operator safety mechanisms and recheck oil lever. connected and in proper operating condition prior to 5.1.9 Check tire pressures: use for mowing. Service Interval:40hrs. 5.1.6 Check for loose hardware.
FIG11 FIG10 Remove the belt cover. Adjust the mower deck belt using a belt tension gauge. The blade drive lever is 5.2 ADJUSTMENTS IMPORTANT: Disengage the blade drive lever, shut engaged, tension the mower belt, and adjust the belt so off engine, wait for all moving parts to that the belt moves 1/4”...
control rod beside the mower of the same Make sure there is fuel in the fuel tank and that strength. the fuel valve is open. Adjusting control rod: Remove hair pin on the Check that blade drive lever top of control rod, pull out the control rod from disengaged.The key switch is in the “ON”...
Page 20
consumption ENGINE TROUBLESHOOTING TABLE Will not Start 5 6 7 1→NO FUEL Hard starting 5 6 7 2→IMPROPER FUEL 3→DIRT IN FUEL LINE Stops suddenly 6 7 8 4→DIRTY AIR FILTER Lacks power 5 6 7 8 5→FAULTY SPARK PLUG 6→ENGINE OVERLOADED Operates 5 6 7...
During warranty no claim of breach of warranty shall be cause for period ,Worldlawn will repair or replace, at its option, recision , cancellation ,or voiding the contract of sale any Mower or part thereof which is found to be of the Mower.
Page 23
Worldlawn Power Equipment, Inc 422 Turnbull Canyon Road, City of Industry, CA 91744 Phone:(626) 934-8552 Fax: (626) 934-8162 E-mail: worldlawnmower@adelphia.net Form NO.36101-20080308...