Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for Worldlawn WY33N11BS
Summary of Contents for Worldlawn WY33N11BS
- Page 1 Operator’s Manual Commercial / Residential 33″Mower Service Information ● Maintenance ● Mower Operation ● Adjustments & Repairs ● Warranty ● Worldlawn Power Equipment, Inc. Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Toll Free Number: 1-800-267-4255...
-
Page 3: Service Information
When calling or writing, or by calling the factory. please provide the Model and Serial Number of your Mower. Contact your local Worldlawn or Engine authorized dealer or WORLDLAWN POWER EQUIPMENT INC. call the Factory where local laws require the Mower to have Phone: ……………………………………(402)228-4255... -
Page 4: Table Of Contents
Table of Contents TABLE OF CONTENTS SAFETY INFORMATION Equipment Safety and Training……………..………………………………………... Preparation to Mow…………………………………………………………………... Operating the Mower ……………………………………………………………..MAINTENANCE Maintenance and Storage…………………………………………………………..Initial Assembly……………………………………………………………………..Blade Care……………………………………………………………………………. Daily Maintenance……………………………………………………………………. Safety Decals ………………………………………………………………………..MOWER OPERATION Operation……………………………………………………………………………... Starting the Engine …………………………………………………….……..……..Stopping the Engine…………………………………………………………………... Blades and Wheel drives………………………………………………………... -
Page 5: Equipment Safety And Training
Engine and immediately contact ● NEVER store the Mower with gasoline in the Tank inside your local Worldlawn authorized dealer or call the factory a building where fumes may reach an open flame or spark. for instructions. DO NOT use the Mower until the Allow the Engine to cool before storing in any enclosure. -
Page 6: Initial Assembly
Engine until the Handlebars and ● Grease all pivots daily, or more often as needed, Control Rods are properly installed, checked for proper depending on operating conditions. ● Use only Worldlawn ® original equipment replacement operation, and you have read and understood the safety, parts. -
Page 7: Operation
OPERATION ● RECOIL START ENGINE 1. Squeeze both Steering Levers on handles and lock both ® Your Worldlawn Mower is equipped with a Brake Latches. Blade Spindle Brake which stops the Blade rotation when 2. Shift the Transmission into neutral. -
Page 8: Adjustments And Repairs
ADJUSTMENTS AND REPAIRS BLADE SPINDLE BELT REPLACEMENT Remove and reinstall the Belt Cover for any service of FIG 6 Spindles, Blades, Blade Brake Pad, and Blade Drive Belts. FIG 4. Knob Knob Grease Fittings FIG 6 Blade Spindle Belt Caster Wheel 1. -
Page 9: Transmission Drive Belt Replacement
WHEEL DRIVE BELT REPLACEMENT 1. Be sure that Mower Blade Drive Lever is disengaged and FIG 9 both Brake Latches are locked. FIG 2 2. Remove both Center Spindle Pulley Belt Guards, FIG 6, and loosen and remove Belt Guard from Engine Pulley. Nuts Transmission Filler Port Handle Bar are shown in FIG 9. -
Page 10: Wheel Brake Adjustment
2. Lengthen or shorten the Control Rod a few turns so that 5. When properly adjusted, the Blade Drive Lever will stay the Mower will "brake" when the Brake Latches are locked engaged when pushed forward to engaged position. SHIFT CONTROL ROD ADJUSTMENT with both Steering Levers squeezed tight to handles. -
Page 11: Transmission Adjustment
2. Rotate the Spacer to align with flat in the Yoke Shaft and slide the Spacer onto the shaft. 3. No Spacer at the bottom reflects a cutting height of 1-1/2”. Each spacer added to or removed from the bottom will adjust the cutting height 1/2”. -
Page 12: Connecting The Negative Battery Cables
Chart 1 Note: If time does not permit charging the battery, or if charging equipment is not available, connect the negative Voltage Percent Maximum Charging battery cables and run the vehicle continuously for 20 to 30 Reading Charge Charger Interval minutes to sufficiently charge the battery. -
Page 13: Wiring Harness Diagram
WIRING HARNESS DIAGRAM... -
Page 14: Accessory
ACCESSORY Nylon Grass Catcher Nylon Grass Catcher: Model # WY33N-NGC (2.07 Bushel) -
Page 15: Limited Warranty
Worldlawn Power Equipment, Inc, (“Worldlawn”) warrants Worldlawn’s sole responsibility with any claim made under that the Worldlawn 33” Mower (“Mower”) will be free from this warranty is limited only to repairing or replacing the defects in material and workmanship for a period of one year mower or a defective part thereof, and no claim of breach of commercial from the original date of purchase. - Page 16 NOTES...
- Page 17 NOTES...
- Page 20 Worldlawn Power Equipment, Inc Industrial Park 2415 Ashland Ave. Beatrice, NE 68310 Phone: (402) 228-4255 Fax: (402) 223-4103 www.worldlawnpowerequip.com Form No. 33122-201111...