Table of Contents
Advertisement
Quick Links
Convertible from Natural Gas to Propane/LP Gas
ANSI Z21.60a-2000
CSA 2.26a-2000
APPROVED
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result caus-
ing property damage, personal injury, or loss of life.
— Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's in-
structions.
• If you cannot reach your gas supplier, call the
fire department.
— Installation and service must be performed by a
qualified installer, service agency, or the gas
supplier.
WARNING: This is a gas-fired appliance. It uses air (oxygen) from the room in which it is
installed. Provisions for adequate combustion and ventilation air must be provided. Refer to
National Fuel Gas Code, ANSI Z233.1/NFPA 54 , Section 5.3, Air for Combustion and Ventilation .
NATURAL GAS LOG
VENTED DECORATIVE APPLIANCE
OWNER'S MANUAL
Save this manual for future reference.
Save this manual for future reference.
Models BVDA18M, BVDA24M,
and BVDA30M
For Use with Log Sets
Mossy Maple
Models BMM18, BMM24 and BMM30
Twisted Pine
Models BTP18 and BTP24
Premium Pear
Models BPP18 and BPP24
Black Walnut
Models BBW18 and BBW24
Aspen Birch
Models BWB18 and BWB24
WARNING: Improper installation,
adjustment, alteration, service, or
maintenance can cause injury or
property damage. Refer to this
manual for correct installation and
operational procedures. For assis-
tance or additional information con-
sult a qualified installer, service
agency, or the gas supplier.
WARNING: This appliance is for
installation only in a solid-fuel burn-
ing masonry or UL127 factory-built
fireplace, constructed of noncom-
bustible material, and connected to
a working flue. (See page 4 for mini-
mum flue opening.)
Advertisement
Table of Contents
Related Manuals for Barbeques Galore BVDA18M
Summary of Contents for Barbeques Galore BVDA18M
- Page 1 NATURAL GAS LOG VENTED DECORATIVE APPLIANCE OWNER’S MANUAL Convertible from Natural Gas to Propane/LP Gas Models BVDA18M, BVDA24M, and BVDA30M ANSI Z21.60a-2000 CSA 2.26a-2000 For Use with Log Sets Mossy Maple APPROVED Models BMM18, BMM24 and BMM30 Twisted Pine Models BTP18 and BTP24...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SAFETY INFORMATION TABLE OF CONTENTS SAFETY INFORMATION ............2 INSPECTING BURNERS ............10 LOCAL CODES ................3 CLEANING AND MAINTENANCE ..........10 PRODUCT IDENTIFICATION ............. 3 TROUBLESHOOTING ............... 11 UNPACKING ................3 ILLUSTRATED PARTS BREAKDOWN AND PARTS LIST ..14 PRODUCT FEATURE .............. -
Page 3: Local Codes
SAFETY INFORMATION LOCAL CODES PRODUCT IDENTIFICATION UNPACKING PRODUCT FEATURE SAFETY INFORMATION PRODUCT IDENTIFICATION Continued Grate Steps Grate Do not use a blower insert, heat exchanger insert or other ac- cessory not approved for use with this log set. 10. The installation and provisions for combustion and ventilation air must conform with the National Fuel Gas Code, ANSI Z233.1/ NFPA 54, Section 5.3, Air for Combustion and Ventilation. -
Page 4: Installation
DESCRIPTION LP Gas Plumber or Gas Fitter. Massachusetts state code re- BVDA18M 18" Dual Burner 55,000 45,000 .116 32 .082 45 quires all vent dampers be welded open or removed. BVDA24M 24" Dual Burner 65,000 55,000 .138 29 .086 44 BVDA30M 30"... -
Page 5: Connecting To Gas Supply
INSTALLATION Venting Specifications for Installation Installing Damper Clamp Connecting to Gas Supply INSTALLATION Continued VENTING SPECIFICATIONS FOR CONNECTING TO GAS SUPPLY INSTALLATION WARNING: A qualified service person must con- The fireplace chimney flue and vent must be drafting properly. To nect log set to gas supply. -
Page 6: Checking Gas Connections
INSTALLATION Connecting to Gas Supply (Cont.) Checking Gas Connections Hearth Pan Installation INSTALLATION Continued Apply pipe joint sealant lightly to male NPT threads. This will Equipment Shutoff Valve prevent excess sealant from going into pipe. Excess sealant in pipe could result in a clogged burner injector. WARNING: Use pipe joint sealant that is resistant to liquid petroleum (LP) gas. - Page 7 INSTALLATION Hearth Pan Installation (Cont.) INSTALLATION Continued Propane/LP Gas Conversion 8. Thread gas control valve and burner inlet fitting into burner manifold (see Figure 8). Use thread sealant on male threads of To convert to propane/LP gas, the burner inlet fitting and pilot orifice burner inlet fitting.
-
Page 8: Testing Burner For Leaks
INSTALLATION Testing Burner for Leaks Adding Pan Material Installing the Grate and Logs INSTALLATION Continued TESTING BURNER FOR LEAKS Grate Steps Generously apply soapy solution to all connections. Grate WARNING: Never check for gas leaks with open flame. 2. Light the burner with the shut-off valve no more than half open and holding a match slightly in front of the pan (see Lighting Instructions, page 9). -
Page 9: Operating Appliance
OPERATING APPLIANCE For Your Safety Read Before Lighting Curing Logs Lighting Instructions OPERATING APPLIANCE FOR YOUR SAFETY 5. Turn control knob counterclockwise to the PILOT position and press in. Keep control knob pressed in for five READ BEFORE LIGHTING (5) seconds. Note: You may be running this log set for the first time WARNING: Keep flue open when operating unit. -
Page 10: Inspecting Burners
OPERATING APPLIANCE To Turn Off Gas to Appliance INSPECTING BURNERS Pilot Assembly Burner Flame Pattern CLEANING AND MAINTENANCE OPERATING APPLIANCE Continued TO TURN OFF GAS BURNER FLAME PATTERN TO APPLIANCE Burner flames will be steady; not lifting or floating. Flames should go up through the middle of logset. -
Page 11: Troubleshooting
TROUBLESHOOTING TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off log set and let cool before servicing. Only a qualified service person should service and repair log set. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Log set is smoking/sooting excessively 1. - Page 12 TROUBLESHOOTING TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY When ignitor button is pressed, there is 1. Gas supply turned off or equipment 1. Turn on gas supply or open equipment spark at pilot but no ignition shutoff valve closed shutoff valve 2.
- Page 13 TROUBLESHOOTING TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
-
Page 14: Illustrated Parts Breakdown And Parts List
ILLUSTRATED PARTS BREAKDOWN Models BVDA18M, BVDA24M and BVDA30M ILLUSTRATED PARTS BREAKDOWN MODELS BVDA18M, BVDA24M AND BVDA30M Natural Gas Propane/LP 109220-01C... -
Page 15: Parts List
PARTS LIST Models BVDA18M, BVDA24M and BVDA30M PARTS LIST This list contains replaceable parts used in your log set. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. KEY PART NUMBER FOR BVDA18M... - Page 16 ILLUSTRATED PARTS BREAKDOWN Log Set Models BMM18, BMM24,and BMM30 ILLUSTRATED PARTS BREAKDOWN LOG SETS This list contains replaceable parts used in your log set. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. Mossy Maple PART NUMBER FOR BMM18...
- Page 17 ILLUSTRATED PARTS BREAKDOWN Log Set Models BTP18, BTP24, BPP18 and BPP24 ILLUSTRATED PARTS BREAKDOWN LOG SETS This list contains replaceable parts used in your log set. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. Twisted Pine Premium Pear PART NUMBER FOR...
- Page 18 ILLUSTRATED PARTS BREAKDOWN Log Set Models BBW18, BBW24, BWB18, and BWB24 ILLUSTRATED PARTS BREAKDOWN LOG SETS This list contains replaceable parts used in your log set. When ordering parts, follow the instructions listed under Replacement Parts on page 19 of this manual. Black Walnut Aspen Birch PART NUMBER FOR...
-
Page 19: Replacement Parts
Purchase these logset accessories from your local dealer. If they warranty coverage for parts replaced under warranty. can not supply these accessories, call Contact Barbeques Galore at 1-800-673-5206. You can also write to the address listed on the PARTS UNDER WARRANTY back page of this manual. -
Page 20: Warranty Information
BARBEQUES GALORE VENTED GAS LOGS Barbeques Galore warrants this product to be free from defects on burner system for four (4) years and logs for a lifetime from the date of first purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. To make a claim under this warranty the Bill of Sale or cancelled check must be presented.