Pelpro HSPP2 Owner's Manual page 30

WARNING:
Regular maintenance must be conducted for safe and efficient operation.
Disconnect power to the stove if maintenance requires the opening of service panels.
Conduct maintenance on a COLD appliance only.
Proper care of your PelPro SERIES pellet appliance is required for peak, sustained performance. The need
for and frequency of cleaning depends on the amount of pellets burned, pellet quality, length of time since last
cleaning and the quality of the fire. While becoming acquainted with your new stove and the types of local
pellets, inspect your BURN GRATE, BURN POT, HEAT EXCHANGE, ASH PIT, and WINDOW daily and
clean until a pattern of cleaning re-quirement is determined. As heating demands increase the need for
stove and exhaust system cleaning and ash removal will increase.
EVERY 2 –3 DAYS / WEEKLY
CHECK BURN GRATE FOR CLINKERS
If the flames seem to be coming only from the sides,
or are orange/black in color, turn the stove off and check
for build up in the grate.
The most likely causes are:
Poor quality pellets, exhaust system requires cleaning
The air-inlet damper requires adjustment
To Clean: (Cold Stove Only)
Open door, remove the burn grate, knock out any debris.
It may be necessary to scrape the holes clean.
Clean between the Burn Grate and Burn Pot as well.
BURN POT: (A)
[COLD STOVE ONLY]
Remove the burn grate. Clean out the burn pot area of all
debris.
CAUTION: When replacing the grate make sure it fits
properly in the burn pot.
DISPOSALE OF ASHES
Ashes should be placed in a metal container with a tight fitting
lid The closed container of ashes should be placed on a
noncombustible floor or on the ground, well away from all
combustible materials, pending final disposal. If the
ashes are disposed of by burial in
Soil or otherwise locally dispersed, they should be retained in the
closed container until all cinders have thoroughly cooled.
WINDOW CLEANING:
[COLD STOVE ONLY as hot glass may cause serious burns]
To enjoy a clear view of the fire you should clean your window
as needed with a soft cloth or paper towel. You may use a
Fireplace glass cleaner or vinegar water to remove heavy build
up on the window.
Mirror cleaners and oven cleaners will leave a film on the
glass and attract smoke like a magnate.
DO NOT OPERATE STOVE WITH BROKEN GLASS AS
LEAKAGE OF FLUE GASES MAY RESULT.
DOOR & TRIM CLEANING:
Fingerprints or other marks left on gold surfaces may become
etched in place, if they are not wiped clean prior to turning
the stove on. Use a damp cloth to wipe clean.
DO NOT USE ABRASIVE CLEANERS AS YOU WILL REMOVE OR SCRATCH THE PLATING!
PelPro Home & Shop Heater
M —
M —
AINTENANCE
AINTENANCE
(COLD STOVE ONLY]
R C
R C
OUTINE LEANING
OUTINE LEANING
(B)
:
B
www.pelprostoves.com
G
C
A
30 30