Doors & Locks; Trailer Frame; Chrome Parts; Stone Guard - Jayco 2012 Jay Feather Ultralite Owner's Manual

TOWABLE
Do not allow plastic to come into contact
with brake fluid, engine oil, grease, paint
thinner, or battery acid. These will damage
plastic. Use a soft cloth and a mild
detergent solution to wipe away any such
contact.
Chrome parts (if so equipped)
To prevent chrome parts from spotting or
corroding, wash with water, dry thoroughly,
and apply a non-abrasive automotive wax. If
the chrome is severely damaged or pitted,
use a commercially available chrome polish
product.
Stone Guard (if so equipped)
Wash the stone guard with mild liquid
dishwashing soap or liquid car washing soap
and water. Do not use powdered detergent,
powdered soap, liquid and spray cleaners or
pressure washing. Wax frequently to protect
the surface and make cleaning easier.
E R & S
XTERIOR OOF
While you are cleaning the exterior roof, also
inspect the roof vents (including sealants) for
cracks and keep them clean. Inspect the
refrigerator and holding
blockages from bird nests, spider webs,
leaves, etc. Water heater, furnace and
refrigerator exterior doors need to be kept
clean and free of obstructions (i.e., insect
nests, mud daubers,
appliances (if so equipped) are in use.
W
INDOWS
Any ventilating window may permit water
inside, especially during heavy rainstorms.
Condensation will also cause water to
accumulate on windows and in the tracks.
The window "glass" can normally be cleaned
with a sponge and water. Use glass cleaner
to remove wax, oil, grease, dead insects, etc.
After washing the glass, wipe it dry with a
clean, soft cloth.
V
IDEWALL ENTS
tank vents for
etc.) while the
STORAGE & MAINTENANCE
D & L
OORS OCKS
Locks on entrance and baggage doors need
biannual lubrication using a light coat of
silicone spray. Do not permit the spray to
come into contact with the tent. Conditions
such as rain, salt, dust and pollution may
increase the maintenance needs.
T F
RAILER RAME
Sand, pebbles, objects on the highway,
climate (salt air exposure) or ice inhibiting
chemicals used during the winter months will
damage the paint, inviting rust and other
deterioration. Periodically inspect the exterior
exposed areas, clean and repaint the steel
members occasionally and whenever you
notice rust or paint chipped away, to insure
protection.
E-Z L A
UBE XLE
The E-Z lube feature on your axles provides
the ability for the bearings to be periodically
lubricated without removing the hubs from the
axle. This feature consists of axle spindles
that have been specially drilled and fitted with
grease zerks in their ends. When grease is
pumped into the zerk, it is channeled to the
inner bearing and then flows back to the outer
bearing and eventually back out the grease
cap hole. If you have further questions,
consult with your dealer.

NOTE: The
provisions of the E-Z lube must not replace
periodic inspection and maintenance of the
bearings. Use a hand-operated grease gun;
improper use of a commercial grease gun
may damage the seals.
R B
EAR UMPER
Do not add items to the RV rear bumper.
Add-on items will eventually damage your
bumper. Damage
aftermarket equipment
improper loading
Limited Warranty.
SECTION 11
convenient lubrication
caused by such
installation or
voids the Towable
11 - 5