WARNING WARNING WARNING WARNING WARNING FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance 2. An LP Tank not connected for use shall not be stored in the vicinity of this or any other appliance.
LP (Liquefied Petroleum Gas) • Is nontoxic, odorless and colorless when produced. For Your Safety, LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. • LP gas is highly flammable and may expect ignite unexpectedly when mixed with air.
(3) All other parts, for a period of one (1) year from the date of purchase. Thermos will, at its option, refinish or replace any product or part found to be defective during the warranty period. Thermos will require you to return the part(s) claimed to be defective, for its inspection, freight or postage prepaid.
Table of Contents For Your Safety ........................2 Safety Symbols ........................2 LP (Liquefied Petroleum Gas) ..................... 3 Call Grill Service Center For Help And Parts .................. 3 Installation Safety Precautions ..................... 3 Warranty Information ....................... 3 Warranty ..........................4 Table of Contents .........................
Assembly NOTE: Your grill will require minimal assembly The Grill2Go™ is packaged in three major components. Additional parts are stored within grill body and legs. Spacers Remove all protective packaging and Product Information Cards before assemby. Spacers NOTE: The twelve Rubber Spacers located on the grill lid are designed to help protect the non-stick Body...
Page 7
Carriage bolt fits completely through holes in Base and Legs. NOTE: Use square hole not round hole when assembling Legs to Base. Washer Plastic Hand Qty: 4 Fastener Qty: 4 Carriage Bolt Qty: 4 NOTE: Do not fully tighten fasteners at this time. Top View Unfold legs to locked position.
Page 8
Grill body fits firmly on to base. Grease container slides onto slot on left side of base. Cap on Grease container should be open when installing Ignitor fits into slot in base. With legs fully extended, hand-tighten fasteners. NOTE: 1lb tank sold separately. Regulator slides straight into burner.
Page 9
Shelf with (Valve) hole attaches to the right side of grill. For transporting grill, store side shelves by stacking shelves together (shelf with cut out for regulator must be on bottom) and placing them on screw(A) using the center tool holders(B). Once in place, use Plastic hand fastener(C) to secure.
Page 10
The Grill2Go™ can be used with the legs fully extended or folded. Turn counter-clockwise To use in Table Top mode, fully loosen Plastic hand fasteners(A), fold legs upward until leg latch engages and locks in place(B). Then tighten hand fastener to secure in closed position(C).
Key Qty Description Part # Plastic Base 11-6047-004-200 Left Leg 11-6047-036-200 CC 1 Right Leg 69-6047-005-200 DD 1 Leg Lock Assembly 63-9047-900-200 Locking Bracket 21-6047-067-200 Leveling Blocks 11-6047-065-200 Hardware Key Qty Description Part # Plastic Fasteners 11-6047-033-200 Coach Bolt 41-9000-561-000 Stand Offs 13-6047-026-200 Coach Bolt Bracket...
Propane Cylinder Use (1lb Disposable) • Use only cylinder marked “Propane Fuel”. • Size should be 4” Diameter, 8” Height. • Save cylinder cap and reinstall when not in use. • Cylinder supply system must be arranged for vapor withdrawal-Gas cylinder must be upright in use.
Operation WARNING WARNING WARNING WARNING WARNING For Safe Use Of Your Grill: • Do not leave the appliance unattended. Keep children and pets away from the appliance at all times. • When cooking, the appliance must be on a level surface in an area clear of combustible material •...
Safety Tips The use of alcohol, prescription or nonprescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1lb cylinder or turn off 20lb cylinder. Never move grill while in operation or still hot. Allow the appliance to cool before moving or storing.
MATCH LIGHTING FOR THIS GRILL 1. Push Regulator/Valve in and turn counterclockwise to LIGHTING POSITION. 2. Wait 3 seconds and place lit match at the mouth of the FLASH TUBE on front of grill. Flash Tube WARNING WARNING WARNING WARNING WARNING •...
Leveling your Grill for Proper Grease Drainage • For best grease drainage the grill should be level left to right and angled slightly to the front. Use bubble level indicator on grill base to judge levelness right to left. • If ground is uneven, use leveling blocks provided and place as needed under feet to level cooking surface.
CA UTION UTION UTION UTION UTION Clean burner prior to use after storing, at the beginning of grilling season or a • period of one month not being used. Spiders and insects like to build nests in burner tubes (especially during colder months). These nests can cause fires in burner tubes or under grill.
Cooking Food Safety • Food safety is an important part of enjoying the outdoor cooking experience. To keep food safe from harmful bacteria, follow these four basic steps: Clean: Wash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry.
Check to see if LP tank is empty. No gas flow. Clear burner tubes. Obstruction of gas flow. Burner(s) will not Does Regulator/valve cap stay Replace with Thermos parts. match down. light Disengagement of burner to Check steps in assembly valve.
20lb Cylinder Use. • The 20lb LP tank used with your grill must meet the following requirements: • Purchase LP tanks only with these required measurements:12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity maximum. •...
LP Tank Leak Test For your safety • Leak test must be repeated each time LP tank is exchanged or refilled. • Do not smoke during leak test. • Do not use an open flame to check for gas leaks. •...
Page 24
5. Hold hose end, insert nipple (C) into LP tank valve. Hand tighten coupling nut, holding connector in a straight line (D) with LP tank valve so as not to cross thread the connection. C C C C C D D D D D Nipple has to be centered into the LP tank valve Hold coupling nut and hose end as shown...
Page 25
WARNING WARNING WARNING WARNING WARNING • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, immediately close LP tank valve and call LP gas supplier or your fire department! Leak Testing Valves, Hoses and Regulator 1.
Page 26
WARNING WARNING WARNING WARNING WARNING For Safe Use Of Your Grill: • Do not leave the appliance unattended. Keep children and pets away from the appliance at all times. • When cooking, the appliance must be on a level surface in an area clear of combustible material.
Recreational Vehicles THERMOS GRILLS has approved use of the Grill2Go with specific recreational vehicles subject to the following provisions: • The Grill2Go is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV. The Grill2Go cannot be attached to any part of the gas system of the RV except directly to the tank itself.
Page 28
P. O. Box 1240 Columbus, GA 31902-1240 Thermos® is a registered trademark of the Thermos Company and its affiliates. Quantum® and Limited® are registered trademarks of W.C. Bradley Co. VIP™, Millennium™, Traditional™, TruFlame™, VaporShield™, and PowerSpark™ are trademarks of W. C. Bradley Co. Grills protected for W.C. Bradley under one or more of these U.S. Patents: 5,109,834;...