Table of Contents
Advertisement
Read and follow all safety
statements, assembly
instructions, and use and
care directions before
attempting to assemble
and cook.
Installer/assembler:
Leave these instructions
with consumer.
Consumer: Keep this
manual for future
reference.
Model Number 465630003
WARNING
Failure to follow all manufacturer's instructions could
result in fire or explosion which could cause property
damage, personal injury or death.
CAUTION
Some parts may contain sharp edges – especially as
noted in the manual! Wear protective gloves if necessary.
Fire+Ice 465630003-E / 00-0000-000-000 (10-29-02)
Owner's Manual
Assembly, Operation,
Use and Care
Advertisement
Table of Contents
Related Manuals for Thermos 465630003
Summary of Contents for Thermos 465630003
- Page 1 CAUTION Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary. Fire+Ice 465630003-E / 00-0000-000-000 (10-29-02) Owner’s Manual Assembly, Operation, Use and Care...
-
Page 2: Safety Symbols
FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance. -
Page 3: Lp (Liquefied Petroleum Gas)
LP (Liquefied Petroleum Gas) • Is nontoxic, odorless and colorless when produced. given an odor (similar to rotten cabbage) so that it can be smelled. • LP gas is highly flammable and may ignite unexpectedly when mixed with air. For residential use only. Do not use for commercial cooking. Call Grill Service Center for Help and Parts •... -
Page 4: Warranty
(4) All other parts, for a period of one (1) year from date of purchase. Thermos will, at its option, refinish or replace any product or part found to be defective during the warranty period. Thermos will require you to return the part(s) claimed to be defective, for its inspection, freight or postage prepaid. -
Page 5: Table Of Contents
For Your Safety............. 2 Safety Symbols LP (Liquefied Petroleum Gas) . -
Page 6: Grill Features
Bottle opener Level indicator Cooler lid Foot pedal 6 • Fire & Ice FEATURES Cooler shelf support Pull handle/Cooler shelf Heat indicator Viewing glass Ignitor Lift handle... - Page 7 Tool holders Match lighting stick Cup/can holders Storage net FEATURES Tool Grease bottle Lift handle Fire & Ice • 7...
-
Page 8: Parts List
Quantity 8 • Fire & Ice PARTS LIST Description Torsion Bar Upper Hinge Grill Lid Side Lid Spacer Center Lid Spacer Upper Latch Handle Assembly Heat Shield Grate Burner Collector Box Electrode Lower Heat Shield Side Shelf - Left Pivot Pin Lower Hinge Ignitor Wire Side Shelf - Right... -
Page 9: Parts Diagrams
PARTS DIAGRAM Fire & Ice • 9... -
Page 10: Parts Diagrams
PARTS DIAGRAM 10 • Fire & Ice... -
Page 11: Assembly
ASSEMBLY RELEASE To raise grill . . . PRESS and foot pedal on front of cooler. Foot pedal MUST BE RELEASED once the grill begins to rise so that the grill will lock into position. Release Pedal Press Slide cooler lid back to open and lift grill lid to remove packed components. - Page 12 To lower grill and begin assembly . . . Make sure cooler lid is in the closed position. PRESS foot pedal and push grill down by pressing on OUTER EDGES of grill lid. foot pedal BEFORE grill reaches the cooler so that it will lock into position.
- Page 13 Attach grease bottle by sliding bottle bracket over tabs on left side of plinth. Grease bottle Twist 1 lb. LP gas cylinder (sold separately) into regulator. Regulator 1 lb. LP gas cylinder Fire & Ice • 13...
- Page 14 RELEASE PRESS and MUST BE RELEASED cooler. Foot pedal once the grill begins to rise so that the grill will lock into position. To install regulator/cylinder . . . 1. Push and hold regulator lock to right. 2. Push and hold the gas interlock downward.
- Page 15 Attach side shelves by sliding shelf rods into holes on each side of grill. NOTE: Shelf with regulator cut-out attaches to right side. Fire & Ice • 15...
- Page 16 The pull handle on your cooler may converted for use as a shelf by utlizing the built-in support in the handle. To use the pull handle as a shelf . . . 1. Raise pull handle to horizontal position. 2. Lower the support wire (built into handle). 3.
-
Page 17: Tabletop Mode
To remove grill from cooler for tabletop use . . . Begin with grill in the lowered position. Grasp the plinth on each side (see arrows) and lift grill from cooler. NOTE: • Grill should not be removed when grill is in raised position. - Page 18 Align posts beneath plinth with holes on top of cooler and slide grill downward onto cooler. 18 • Fire & Ice To close legs and return grill to cooler . . . Press legs inward to release from locked position, then fold legs under plinth.
-
Page 19: Use & Care
Propane Cylinder Use (1 lb. Disposable) • Use only cylinder marked “Propane Fuel”. • Size should be 4” diameter, 8” height, or 3” diameter, 10” height. • Save cylinder cap and reinstall when not in use. • Cylinder supply system must be arranged for vapor withdrawal. Gas cylinder must be upright in use. - Page 20 Propane Cylinder Use (20 lb. Refillable) The 20 lb. LP tank used with your grill must meet the following requirements: • Purchase LP tanks only with these required measurements:12" (30.5cm) (diameter) x 18" (45.7 cm) (tall) with 20 lb. (9 kg.) capacity maximum. •...
- Page 21 Leak Testing (20 lb. Refillable) For your safety • Leak test must be repeated each time LP tank is exchanged or refilled. • Do not smoke during leak test. • Do not use an open flame to check for gas leaks. •...
- Page 22 Connecting The Adapter Hose To The LP Tank (continued) 5. Hold hose end, insert nipple (A) into LP tank valve. Hand tighten coupling nut, holding connector in a straight line the connection. 6. Turn the coupling nut clockwise to tighten to a full solid stop. The hose-end will seal on the back-check feature in the LP tank valve, resulting in some resistance.
- Page 23 • Do not use grill until leak checked. • If leak is detected at any time, STOP and call the Fire Department. • If you cannot stop a gas leak, supplier or your fire department! Leak Testing Valves, Hoses and Regulator Turn grill control knob to off.
- Page 24 For Safe Use Of Your Grill: • Do not leave the appliance unattended. Keep children and pets away from the appliance at all times. • Never use regulator from this grill with any other LP appliance. • When cooking, the appliance must be on a level surface in an area clear of combustible material.
- Page 25 Safety Tips The use of alcohol, prescription or nonprescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance. When grill is not in use, disconnect 1 lb. cylinder or turn off 20 lb. cylinder. Never move grill while in operation or still hot. Allow the appliance to cool before moving or storing.
- Page 26 Match Lighting 1. Push Regulator/Valve in and turn counterclockwise to LIGHTING POSITION. 2. Attach match to match lighting stick, light match. 3. Insert match lighting stick into vent hole at rear of grill. If burner does not light within 5 seconds, turn knob to OFF, wait 5 minutes, try again. Burner Flame Check Light burner.
- Page 27 General Grill Cleaning • Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry.
-
Page 28: Use & Care
Non-Stick Cooking Surface Use and Care. • Use only plastic tools. • Do not cut food on surface. • Do not put pots or pans on surface. • Do not leave lid down for more than 10 minutes without food on the grill. Non-stick surface may be damaged. -
Page 29: Troubleshooting
Reconnect or replace ignitor wire. Reconnect or replace ignitor wire. Replace ignitor. Check to see if LP tank is empty. Clear burner. Replace with Thermos parts. Check steps in assembly instructions. Turn front of grill to face wind or increase flame height. - Page 30 Recreational Vehicles THERMOS GRILLS has approved use of the Fire & Ice with specific recreational vehicles subject to the following provisions: • The Fire & Ice is to be directly connected to an additional 20 lb. or 30 lb. DOT/TC LP tank mounted on the RV.
- Page 31 Fire & Ice • 31...
- Page 32 VIP®, PrecisionFlame and Design®, Sierra®, and TruFlame® are registered Trademarks of the W.C. Bradley Company. Thermos® is a registered trademark of the Thermos Company and its affiliates. Artisan Collection by Char-Broil ™, C3 and Design™, Char-Broil and Design™, Flame Design™, FlavorTents™, Grill 2 Go™, Grillin’...