Holman RCS-3 SERIES Installation And Operation Instructions Manual

Holman RCS-3 SERIES Installation And Operation Instructions Manual

Conveyor toaster

Advertisement

®
CONVEYOR
TOASTER
MODEL
QCS-2, QCS-3,
RCS-2, RCS-3 SERIES
Installation and
Operation
Instructions
2M-HG0651 Rev. J 6/18/2007
QCS-2
1

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the RCS-3 SERIES and is the answer not in the manual?

Questions and answers

Summary of Contents for Holman RCS-3 SERIES

  • Page 1 ® CONVEYOR TOASTER MODEL QCS-2, QCS-3, RCS-2, RCS-3 SERIES Installation and Operation Instructions 2M-HG0651 Rev. J 6/18/2007 QCS-2...
  • Page 2: Safety Symbol

    SAFETY SYMBOL These symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. RETAIN THIS MANUAL FOR FUTURE REFERENCE NOTICE Using any part other than genuine Star factory supplied parts relieves the manufacturer of all liability.
  • Page 3: General Installation Data

    GENERAL INSTALLATION DATA CAUTION This equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. Before using your new equipment, read and understand all the instructions &...
  • Page 4: Daily Operation

    WARNING DO NOT CUT OR REMOVE THIS PLUG OR GROUNDING PRONG FROM THE PLUG. WARNING CONNECT/PLUG UNIT INTO DEDICATED A.C. LINE ONLY SPECIFIED ON THE DATA PLATE OF THE UNIT. DAILY OPERATION ROTARY POWER SAVER SWITCH For toasters equipped with a Rotary Power Saver Switch, turn clockwise or counterclockwise to get in the following positions.
  • Page 5 fi lm to carbonize. CLEANING Preventive maintenance for your Holman toaster consists of the following recommended cleaning procedures. To keep your toaster in its top operating condition, these steps should be performed on a daily or weekly as indicated.
  • Page 6: Maintenance Procedures

    MAINTENANCE PROCEDURES A. REPLACING HEATER TUBES 1) DISCONNECT UNIT FROM POWER SOURCE. 2) Remove the enclosure. 3) Remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) Lift heater tube retainers by loosening retaining screws and sliding the retainer plate up. Hand tighten the plate to hold it up so the heater tubes will slide out freely.
  • Page 7: Troubleshooting Guide

    1) Call the Star Service Help Desk at 1-800-807-9054, as speed control should be replaced. F. PRODUCT STICKING TO CONVEYOR OR SLIDE Your Holman conveyor toaster is designed to toast product that is a current room temperature. DO NOT attempt to put frozen, refrigerated, or any butter or a butter substitute material in the toaster.
  • Page 8 Visit our Website at: www.star-mfg.com Email: service@star-mfg.com THOROUGHLY INSPECT YOUR UNIT ON ARRIVAL This unit has been tested for proper operation before leaving our plant to insure delivery of your unit in perfect condition. However, there are instances in which the unit may be damaged in transit. In the event you discover any type of damage to your product upon receipt, you must immediately contact the transportation company who delivered the item to you and initiate your claim with same.
  • Page 9 THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED. ® MODEL: QCS & RCS 4 TUBE - SERIES STAR MANUFACTURING INTERNATIONAL INC. 065264 Rev A 04/16/2001...
  • Page 10 FRONT HEAT MIDDLE HEAT DRIVE REAR HEAT MOTOR FAN SWITCH SPEED CONTROL RESET FAN MOTOR POWER SWITCH SAVER NOTE: DRIVE MOTOR, FOR 240V USE BLACK AND BLUE WIRES, FOR 208V USE BLACK & WHITE WIRES. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED.
  • Page 11 LEFT SIDE CONTROL SIDE TOP HEAT BOTTOM HEAT SPEED CONTROL PILOT TOP HEAT PILOT BOTTOM HEAT FAN MOTOR POWER SUPPLY CORD RESET/HIGH LIMIT POWER SAVER MODELS: QCS2-600, 800, 208/220/240V, 50-60Hz, 6 Tube, Phase Control, wired Series QCS3-950, 1000, 1300, 208/220/240V, 50-60Hz, 6 Tube, Phase Control, wired Series Q3-95ARB, 208/220/240V, 50-60Hz, 6 Tube, Phase Control, wired Series ®...
  • Page 12 LEFT SIDE CONTROL SIDE TOP HEAT BOTTOM HEAT FUSES SPEED CONTROL PILOT TOP HEAT PILOT BOTTOM HEAT FAN MOTOR POWER SUPPLY CORD RESET/HIGH LIMIT POWER SAVER ® MODEL: QCS-3-1300 208/220/240V w/FUSE Q3-95ARB 208/240 w/FUSE STAR MANUFACTURING INTERNATIONAL INC. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. SK2255 Rev - 06/8/2007...
  • Page 13 TOP HEAT BOTTOM HEAT SPEED TOP HEAT CONTROL PILOT PILOT BOTTOM HEAT POWER SAVER FAN MOTOR POWER SUPPLY RESET/HIGH LIMIT MODELS: ® QCS2-600, 800, 220/240V, 50hHz, 6 Tube, Phase Control, wired Series, CE QCS3-950, 1000 220/240V, 50-60Hz, 6 Tube, Phase Control, wired Series, CE STAR MANUFACTURING INTERNATIONAL INC.
  • Page 14 TOP HEAT BOTTOM HEAT SPEED CONTROL TOP HEAT PILOT PILOT BOTTOM HEAT POWER SAVER FAN MOTOR RESET/HIGH LIMIT POWER SUPPLY CORD MODELS: ® QCS2-300, 500, 50-60Hz, 6 Tube, Phase Control, wired Parallel STAR MANUFACTURING INTERNATIONAL INC. THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. 065200 Rev B 12/11/2003...
  • Page 15 TOP HEAT BOTTOM HEAT DRIVE SPEED MOTOR CONTROL TOP HEAT PILOT PILOT BOTTOM HEAT POWER SAVER FAN MOTOR RESET/HIGH LIMIT POWER SUPPLY CORD MODEL: QCS-RCS 14”, 120/208/240V - 6 Tube - Wired Parallel THIS DRAWING CONTAINS INFORMATION CONFIDENTIAL TO STAR MFG. INT'L. INC. NO REPRODUCTION OR DISCLOSURE OF ITS CONTENTS IS PERMITTED.
  • Page 17: Parts List

    PARTS LIST June 18, 2007, Rev. J QCS-2-300H, QCS-2-500, RCS-2-500 Conveyor Toasters Number Part Number Description & Model Unit Number HC-101370 ENCLOSURE, QCS2/RCS HF-402449 PANEL, BACK, QCS2/RCS 2U-200559 MOTOR, FAN 2U-200519 MOTOR, DRIVE, FAN BLADE NOT INCLUDED 2R-Z8879 FAN BLADE, MOTOR 2A-202900 SHAFT, DRIVE HA-112261...
  • Page 18 PARTS LIST June 18, 2007, Rev. J QCS-2-600H, QCS-2-800, RCS-2-600 Conveyor Toasters Number Part Description Number Unit Number HC-101370 ENCLOSURE, QCS/RCS-2 HF-402449 PANEL, BACK, QCS/RCS-2 2U-200560 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN BLADE NOT INCLUDED 2U-200590 MOTOR,DRIVE,3286 BB,LOW, FAN BLADE NOT INCLUDED 50Hz CE 2R-Z8879 FAN BLADE, MOTOR...
  • Page 19 PARTS LIST June 18, 2007, Rev. J QCS-3-950H, QCS-3-1000, RCS-3-950, RCS-3-1000 Conveyor Toasters Number Part Description Number Number Unit HH-101371 ENCLOSURE, QCS3 HH-402470 PANEL, BACK, QCS3 2E-200574 SWITCH, FAN CERAMIC HG-402144 BRACKET, FAN SWITCH 2U-200561 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN BLADE NOT INCLUDED 2U-200590 MOTOR, DRIVE, 3286 BB LOW, FAN BLADE NOT INCLUDED 240V CE...
  • Page 20 PARTS LIST June 18, 2007, Rev. J QCS-3-1300, RCS-3-1300 Conveyor Toasters Number Part Description Number Number Unit HH-101371 ENCLOSURE QCS/RCS-3 HH-402470 PANEL, BACK QCS/RCS-3 2E-200574 SWITCH, FAN CERAMIC HG-402144 BRACKET, FAN SWITCH 2U-200561 MOTOR, FAN 2U-200509 MOTOR, DRIVE, FAN BLADE NOT INCLUDED 2R-Z8879 FAN BLADE, MOTOR 2A-202902...
  • Page 21 PARTS LIST RCS Conveyor Toasters HEATER TUBES Number Part Description Number Number Unit R2-50, 120V 2N-209100 RCS-2-600H, 240V 2N-209106 RCS-2-600H, 208V 2N-209197 RCS-2-600HJ, 208V 2N-209199 RCS-2-600HJ, 240V 2N-209216 RCS-2-800, 240V 2N-209106 RCS-2-800, 208V 2N-209197 RCS-2-1200B, 208V 2N-209198 RCS-3-950H, 208V 2N-209130 RCS-3-950H, 240V 2N-209160 RCS-3-1000, 208V 2N-209130...
  • Page 24 STAR MANUFACTURING 10 Sunnen Drive, St. Louis, MO 63143 U.S.A. (800) 807-9054 (314) 781-2777 Parts & Service (800) 807-9054 www.star-mfg.com...

Table of Contents