Hyundai Powe introduction Attention: Read through the complete manual prior to the initial use of your pressure washer. Using the Operating manual The operating manual is an important part of your pressure washer and should be read thoroughly before initial use, and referred to often to make sure adequate safety and service concerns are being addressed.
er Equipment product identification Record Identification Numbers Pressure Washer If you need to contact an Authorized Dealer or Customer Service line for information on servicing, always provide the product model and identifica- tion numbers. You will need to locate the model and serial number for the machine and record the information in the places provided below.
Page 6
Hyundai Powe safety IMPORTANT SAFETY INSTRUCTIONS SAVE THESE INSTRUCTIONS WARNING – When using this product basic precautions should always be followed, including the following:- 1. Read all the instructions before using the product. 2. To reduce the risk of injury, close supervision is necessary when a product is used near children.
Page 7
er Equipment safety Understanding the Machine Safety Labels The machine safety label shown below is placed on your machine to draw attention to potential safety hazards. WARNING! Do not leave unit running longer than 1 minute without using or the pump will overheat Do not let unit freeze.
Hyundai Powe safety Save these Instructions Safety Rules This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. The safety alert symbol (...
Page 9
er Equipment safety DANGER Risk of electrocution. Contact with power source can cause electric shock or burn. • NEVER spray near power source. WARNING Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death. When Adding or Draining Fuel •...
Page 10
Hyundai Powe safety WARNING Engine exhaust fumes contain carbon monoxide, an odourless, colourless, poison gas. Breathing carbon monoxide can cause headache, fatigue, dizziness, vomiting, confusion, seizures, nausea, fainting or death. Some chemicals or detergents may be harmful if inhaled or ingested, causing severe nausea, fainting, or poisoning.
Page 11
er Equipment safety WARNING Use of pressure washer can create puddles and slippery surfaces. Kickback from spray gun can cause you to fall. • Operate pressure washer from a stable surface. • The cleaning area should have adequate slopes and drainage to reduce the possibility of a fall due to slippery surfaces.
Page 12
Hyundai Powe safety WARNING The high pressure stream of water that this equipment produces can cut through skin and its underlying tissues, leading to serious injury and possible amputation. Spray gun traps high water pressure, even when engine is stopped and water is disconnected, which can cause injury.
Page 13
er Equipment safety WARNING Unintentional sparking can result in fire or electric shock. When Adjusting or Making Repairs to Your Pressure Washer • Disconnect the spark plug cap from the spark plug and place it where it cannot contact spark plug. When Testing for Engine Spark •...
Page 14
Hyundai Powe petrol washer components Read this operating manual and safety rules before operating your pressure washer. 15. 4. 1. Nozzles Detergent, 0°, 15°, 40° & Turbo Nozzle: for high pressure cleaning applications. 2. High Pressure Hose Connect one end to water pump and the other end to spray gun.
er Equipment assembly Your pressure washer requires some assembly and is ready for use after it has been properly serviced with the recommended oil and fuel. If you have any problems with the assembly of your pressure washer, please call the help line. If calling for assistance, please have the model and serial number from the data tag available.
Hyundai Powe operation checklist Follow the Checklist Below Prior to Using the Machine Each Time 1. Check to ensure the engine oil is at the proper level. Use SAE 15W40 Oil 2. Check the 2 handle knobs to ensure they are tight and will not vibrate loose.
er Equipment starting your washer How to Start Your Pressure Washer To start your pressure washer for the first time, follow these instructions step-by-step. This starting information also applies if you have let the pres- sure washer sit idle for at least a day. 1.
Hyundai Powe starting your washer 6. Uncoil high pressure hose and attach quick connect end of hose to base of spray gun. Pull down on collar of quick connect, slide onto spray gun and let go of collar. Tug on hose to be sure of tight connection.
Page 19
er Equipment starting your washer 10. Connect the garden hose to the water inlet. Tighten by hand. 11. To start the machine, locate the engine switch on the side of the engine, and switch it to the ON position. (see component chart to locate switch) Check to ensure fuel valve is in the ON position and if starting cold apply the choke.
Page 20
Hyundai Powe starting your washer WARNING Starter cord kickback (rapid retraction) can result in bodily injury. Kickback will pull hand and arm toward engine faster than you can let go. Broken bones, fractures, bruises, or sprains could result. • NEVER pull starter cord without first relieving spray gun pressure.
er Equipment shutting down your washer WARNING Contact with exhaust area can result in serious burns. Exhaust heat/gases can ignite combustibles, structures or damage fuel tank causing a fire. • DO NOT touch hot parts and AVOID hot exhaust gases. •...
Hyundai Powe quick release nozzles Soap Turbo YELLOW WHITE BLACK BLUE The quick–release on the lance allows you to switch between four different quick-release nozzles. The nozzles can be changed while pressure washer is running once spray gun trigger safety lock is engaged.
er Equipment using black soap nozzle To apply detergent, follow these steps: 1. Fit black soap nozzle. 2. Prepare detergent solution as required by job. 3. Place small filter end of detergent siphoning tube into detergent container. NOTE: Make sure the filter is fully submerged in detergent while applying detergent.
Hyundai Powe troubleshooting Troubleshooting Chart If you are experiencing a problem that is not listed in this chart, or have checked all the possible cause listed and you are still experiencing the problem, see your authorized dealer. PETROL ENGINES Problem...
Page 25
er Equipment troubleshooting Engine runs well Engine speed is too slow Adjust Throttle Lever back to at no load but full throttle. “bogs” down under full load Engine will not Low oil level Fill crankcase to proper level start; or starts and Dirty air cleaner Clean or replace air cleaner runs rough...
Hyundai Powe storage Thermal Relief Water temperature is too Use cool water only. Valve is open and high Pull trigger at least 30 discharging water Pump has operated more seconds every 3 mins from side of pump than 3 mins without pulling trigger.
er Equipment storage Protect Fuel System Fuel Additive: Fuel will become stale when stored over 30 days. Stale fuel causes acids and gum deposits to form in the fuel system or on essential carburetor parts. Prior to storage, if petrol has not been treated with a fuel stabilizer, it must be drained from the engine into an approved container.
Page 32
Hyundai Powe Annovi Reverberi Pump (HYW3000P / HYW4000P) "D" VERSION 3/4” Ø TYPE F25 "D" VERSION 1” Ø TYPE F40 Repair Kits rated up to 3200 psi Unloader Pistons Valves Water Seals O-Rings Oil Seals Support Ring w/o handle Kit 2280...
Page 33
er Equipment www.hyundaipowerequipment.co.uk...
Hyundai Powe declaration of conformity Genpower Ltd confirms that this Hyundai petrol pressure washer conforms to the following CE directives: • 2006/42/EC Machinery directive • 2004/108/EC EMC directive • 2000/14/EC Noise emissions directive • 97/68/EC NRMM Emissions directive...
er Equipment maintenance schedule The user should take the below table into consideration to ensure the engine is kept in perfect working condition. Frequency Item Every Time First Month or 20 Every season or 50 Every 6 months or Every year or 300 hours hours 100 hours...