Lennox Hearth Products CI1500DVF Care And Operation Instructions Manual
Direct-vent serefina elite series
Hide thumbs
Also See for CI1500DVF:
- Installation instructions manual (26 pages) ,
- Care and operation instructions manual (20 pages) ,
- Homeowner's care and operation instructions manual (20 pages)
Table of Contents
Advertisement
P/N 775,148M REV. D 03/2010
Portland
US
Ce manuel d'installation est disponible en francais, simplement
en faire la demande. Numéro de la pièce 775,148CF.
WARNING
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN TO
TOUCH GLASS.
WARNING: If the information in these instructions is
not followed exactly, a fire or explosion may result
causing property damage, personal injury or death.
- Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appli-
ance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
- Installation and service must be performed by a quali-
fied installer, service agency or the gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
INSTALLATEUR: Laissez cette notice avec l'appareil.
CONSOMMATEUR: Conservez cette notice pour consul-
tation ultérieure.
OTL Report No. 116-S-08-5
CARE AND OPERATION INSTRUCTIONS
Direct-Vent
SEREFINA™ SERIES
MODELS
CI1500DVF
AVERTISSEMENT
UNE SURFACE VITRÉE CHAUDE PEUT
NE PERMETTEZ JAMAIS À UN ENFANT
DE TOUCHER LA SURFACE VITRÉE.
AVERTISSEMENT: Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire
au minimum le risque d'incindie ou d'explosion ou
pour éviter tout dommage matériel, toute blessure
ou la mort.
- Ne pas entreposer ni utilizer d'essence ni d'autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
des téléphones se trouvant dans le bâtiment où vous
trouvez.
• Appelez immédiatement votre fournisseur de gaz
depuis un voisin. Suivez les instructions du fournis-
seur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par
le fournisseur de gaz.
CI2500DVF
CAUSER DES BRÛLURES.
LAISSER REFROIDIR LA SURFACE
VITRÉE AVANT D'Y TOUCHER.
Advertisement
Table of Contents
Related Manuals for Lennox Hearth Products CI1500DVF
Summary of Contents for Lennox Hearth Products CI1500DVF
- Page 1 CARE AND OPERATION INSTRUCTIONS Direct-Vent SEREFINA™ SERIES P/N 775,148M REV. D 03/2010 MODELS Portland OTL Report No. 116-S-08-5 CI1500DVF CI2500DVF Ce manuel d’installation est disponible en francais, simplement en faire la demande. Numéro de la pièce 775,148CF. WARNING AVERTISSEMENT HOT GLASS WILL UNE SURFACE VITRÉE CHAUDE PEUT...
-
Page 2: Table Of Contents
PRODUCT IS SUBJECT TO CHANGE WITHOUT NOTICE achieve the maximum benefit and enjoyment available from your new gas stove. Thank you for selecting a Lennox Hearth Products gas stove as INTRODUCTION the answer to your home heating needs. The stove models covered in this manual are Direct-Vent sealed combustion Sincerely, vented gas stove heaters designed for residential application. -
Page 3: Safety And Warning Information
IMPORTANT SAFETY AND WARNING AVERTISSEMENT INFORMATION On ne devrait pas placer de vêtements ni d’autres matières inflammables sur l’appareil ni à prox- imité. WARNING Young children should be carefully supervised when WARNING they are in the same room as the appliance. Tod- dlers, young children and others may be susceptible Any safety screen or guard removed for servicing to accidental contact burns. - Page 4 F OR YOUR SAFETY do not install or operate this appliance without T hese fireplaces are vented gas appliances. Do not burn wood first reading and understanding this manual. Any installation or or other material in these appliances. operation of the appliance deviating from that which is stated T his appliance is only for use with the type of gas indicated on in this manual WILL void the warranty and may be hazardous.
-
Page 5: Variable Flame Adjustment
(See Small Area Paint Touch-Up, Page 14). Paint is available at your Lighting Millivolt Appliances local authorized Lennox Hearth Products dealer. Never attempt to paint a hot stove. To light millivolt appliances refer to the detailed lighting instructions found on Page 18 (English) and Page 19 (French). -
Page 6: Attaching Safety In Operation Warnings
3. Si no puede encontrar las etiquetas, sírvase llamar Lennox Hearth Products or your nearest Lennox ment parlée dans la résidence du propriétaire. a Lennox Hearth Products o al distribuidor de Hearth Products dealer to receive additional 3. Si vous ne trouvez pas les étiquettes, veuillez Lennox Hearth Products más cercano para recibir... -
Page 7: Maintenance
MAINTENANCE WARNING Do not attempt to touch the front enclosure glass with your hands while the stove is in use. WARNING Turn off gas and electrical power to the fireplace Models with Porcelain Enamel Finish and allow it to cool before cleaning or servicing the appliance. -
Page 8: Operation/Care Of Your Appliance
OPERATION AND CARE OF YOUR APPLIANCE HI / LO Knob Inlet Appliance operation may be controlled through a remotely located optional Variable Flame Height Adjustment Pressure wall thermostat or remote control. Port Manifold Pressure Port In lieu of remote or remote wall thermostat operation, the appliance must be operated directly through the on/off rocker switch located on the upper right side of the rear shield. -
Page 9: Front Glass Enclosure Panel, Removal And Installation
These are direct-vent appliances. They are designed to operate only with FRONT GLASS ENCLOSURE PANEL, REMOVAL AND INSTAL- the front glass enclosure panel properly installed. Generally, the glass LATION enclosure panel should not be removed except to gain access to the components within the firebox, and the appliance may only be operated without the front glass enclosure panel in place for very brief periods of WARNING... -
Page 10: Burner Adjustments
der the bottom front of the front glass enclosure and pull 3. Reach un To install the front glass enclosure panel, proceed as follows: it forward as shown in Figure 5. 1. Retrieve the glass door frame. Visually inspect the gasket on the backside of the panel. -
Page 11: Adjustment Rod
Main Burner Factory Air Shutter Opening Setting - Inches (millimeter) Air shutter adjustment should only be performed by a qualified professional service technician. Model Natural Gas Propane Gas CI1500DVF 5/16" (7.93 mm) 5/8" (15.9 mm) WARNING CI2500DVF 1/2" (12.7 mm) 5/8" (15.9 mm) -
Page 12: Log And Ember Placement
LOG AND EMBER PLACEMENT Rear Log Stoppers Carefully install this seven-piece log set into the firebox as shown in these instructions. All logs should fit onto corresponding pins and/or log stoppers. This will ensure a proper flame and safe combustion. Ember Strip WARNING... - Page 13 7. Install the center top twig onto the corresponding pin on the rear 4. Place the center log over the corresponding pins next to the front left log as shown in Figure 12. log and align it with the indentation on front left log as shown in Figure 15.
-
Page 14: Millivolt Appliance Checkout
With proper care and maintenance, your appliance will provide many years of enjoyment. If you should experience any problem, first refer to the troubleshooting guide in this manual. If problem persists, contact your Lennox Hearth Products Dealer. Figure 17 SMALL AREA PAINT TOUCH-UP... -
Page 15: Wiring Diagrams
OPTIONAL ROOM AIR BLOWER WIRING DIAGRAMS IMPORTANT: Ground supply wire must be connected to the green Wiring diagrams are provided here for reference purposes only. This wire attached to the green ground screw. Failure to do so will information is also provided on schematics attached directly to the appli- result in a potential safety hazard. -
Page 16: Accessory Components
Wall Thermostat ACCESSORY COMPONENTS The wall thermostat kit provides temperature control for optimum Standard Remote Control System comfort. The Model RCL (Standard) Remote Control System, features a simple On/Off control function for the stove. This model includes a hand-held transmitter, a remote receiver with wall-mount coverplate and all hardware required to install the unit. - Page 17 Cat. No. Model Description with the use of these touch-up paint kits. H0773 BLK-CI15 Brick Liner Kit CI1500DVF Series H0774 BLK-CI25 Brick Liner Kit CI2500DVF Series (ref. form # 775151M) Touch-Up Kit - Painted Models Cat. No.
-
Page 18: Lighting Instructions - Millivolt
LIGHTING INSTRUCTIONS – SIT MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A. This appliance has a pilot which must be lighted with a •... - Page 19 INSTRUCTIONS D’ALLUMAGE - VANNE GAZ MILLIVOLT SIT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MATÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. •...
-
Page 20: Maintenance Schedule
MAINTENANCE SCHEDULE Anually (Before the onset of the Burning Season) Maintenance Task Accomplishing Person Procedure Inspecting/Cleaning Burner, Logs Qualified Service Technician Inspect valve and ensure it is properly operating. Check piping and Controls for leaks. Vacuum the control compartment, fireplace logs and burner area. -
Page 21: Troubleshooting Guide - Millivolt
TROUBLESHOOTING THE Millivolt GAS CONTROL SYSTEM Note: Before troubleshooting the gas control system, be sure external gas shut off valve (located at gas supply inlet) is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION... -
Page 22: Replacement Parts List
REPLACEMENT PARTS LIST Cast Body Components Item Cat. No. Description Where Used Contact an Authorized Lennox Hearth Products dealer to obtain any of these parts. Never use substitute materials. Use of non-approved parts H3703 Glass Panel Enclosure Assem- CI1500DVF Series bly, Complete can result in poor performance and safety hazards. - Page 23 Trivet, Enamel Mid. Blue, 1 ea. CI2502DVF 1 ea. 55M98 Trivet, Painted Black, 1 ea. CI1500DVF 66M08 Leg Casting, Painted Black, CI1500DVF & CI2500DVF 66M19 Trivet, Painted Black, 1 ea. CI2500DVF 1 ea. Room Air Blower System (Optional Kit) H1007 Side Casting, Left - Enamel CI1506DVF Hunter Green, 1 ea.
- Page 24 REPLACEMENT PARTS Front View Log Set Does Not Include Ember Strip (purchased separately) Front View NOTE: DIAGRAMS AND ILLUSTRATIONS ARE NOT TO SCALE.
-
Page 25: Optional Warming Shelves
4. Place the insets (4 ea. for the CI1500 series or 6 ea. for the CI2500 OPTIONAL WARMING SHELVES KIT series) into the recessed areas on both warming shelves as shown in Figures 24 and 25. Note: Common ceramic tiles (4-1/4” square) can Kit Contents: be used in place of insets on the warming shelves (available at most 2 ea. -
Page 26: Product Reference Information
Fuel Type (Check one) c Natural Gas c Propane Gas (LP) Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information.