Royal RG1000 Owner's Manual page 24

Fire Goes Out
Set cook control switch to the off position and allow grill to cool.
No fuel in hopper
Fill hopper with good, dry fuel.
No fuel in fi repot
Verify the control is properly connected to auger. Clear auger if jammed. Replace auger and/or auger motor if defective.
Unburned fuel in fi repot
Adjust smoke control switch (decrease the "P" setting) to increase auger idle fuel feed rate.
No draft air fl ow
Verify the control is properly connected to draft fan and operating normally. Replace draft fan if defective.
Control is defective
Contact Royall Grills technical support.
Grill Temperature at the 180 Degree Cook Setting is too High
Auger idle fuel feed rate is too high. Adjust smoke control switch (increase the "P" setting) to decrease idle fuel
feed rate.
Probe is defective
Replace probe
Control is defective
Contact Royall Grills technical support.
Grill Temperature at the High Cook Setting is too Low
At the high temperature setting, the auger runs continually until the grill temperature reaches 450 degrees.
Grill lid is open
Close grill lid. Grill is designed to operate with grill lid closed.
Insuffi cient amount of fuel in fi re pot
Clear auger if jammed. Tighten auger connection to auger motor shaft if slipping. Replace auger and/or auger motor
if defective.
Damp fuel source
Replace damp fuel with good dry fuel.
Adverse operating conditions
Shield grill from cold wind and/or rain. Grill may not be able to attain 450 degrees in an extremely cold operating
environment.