Napoleon GSS36N Installation And Operation Instructions Manual
Outdoor gas fireplace
Hide thumbs
Also See for GSS36N:
- Installation and operating instructions manual (48 pages) ,
- Installation and operation instructions manual (28 pages) ,
- Installation and operation instructions manual (12 pages)
Table of Contents
Advertisement
Quick Links
INSTALLER: THESE INSTRUCTIONS MUST BE CONVEYED TO AND REMAIN WITH THE HOMEOWNER.
CERTIFIED UNDER CANADIAN AND AMERICAN NATIONAL STANDARDS, CR97-003, CAN1-2.21-M85, IAS U.S. 4-96.
INSTALLATION AND OPERATION INSTRUCTIONS FOR
WARNING: If the information in these instructions is not followed exactly, a fire or
explosion may result causing property damage, personal injury or death.
Do not store or use gasoline or other flammable vapours and liquids in the vicinity
• Do not try to light any appliance.
• Do not touch any electrical switch.
• Close propane bottle or shut-off gas
supply.
• Do not use any phone in your building
or near the appliance.
Installation and service must be performed by a qualified installer, service agency or
the gas supplier.
THIS FIREPLACE MUST BE INSTALLED OUTSIDE.
Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031
OUTDOOR GAS APPLIANCE
OUTDOOR GAS FIREPLACE
NATURAL GAS MODEL
PROPANE GAS MODEL
CERTIFIED FOR CANADA AND UNITED STATES USING ANSI / CSA METHODS
FOR YOUR SAFETY
of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
www.napoleonfireplaces.com • ask@napoleon.on.ca
GSS36N
GSS36P
• Immediately call your gas supplier from
a neighbour's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier,
call the fire department.
1
W415-0369 / C / 11.21.05
Advertisement
Table of Contents
Related Manuals for Napoleon GSS36N
Summary of Contents for Napoleon GSS36N
- Page 1 Installation and service must be performed by a qualified installer, service agency or the gas supplier. THIS FIREPLACE MUST BE INSTALLED OUTSIDE. Wolf Steel Ltd., 24 Napoleon Rd., Barrie, ON L4M 4Y8 Canada • (705)721-1212 • fax(705)722-6031 www.napoleonfireplaces.com • ask@napoleon.on.ca W415-0369 / C / 11.21.05...
-
Page 2: Table Of Contents
TABLE of CONTENTS PG 3-4 INTRODUCTION OPERATION / MAINTENANCE Warranty Operating Instructions General Instructions Maintenance General Information Venturi Adjustment INSTALLATION REPLACEMENTS Gas Installation Ordering Replacement Parts Combustion and Ventilation Air Provisions Replacement Parts Clearance to Combustibles 11-12 TROUBLE SHOOTING GUIDE Framing Mantle Clearances Nailing Tab Installation... -
Page 3: Warranty
After the first year, NAPOLEON will not be responsible for installation, labour or any other costs or expenses related to the reinstallation of a warranted part, and such expenses are not covered by this warranty. -
Page 4: General Instructions
GENERAL INSTRUCTIONS GENERAL INFORMATION THIS GAS FIREPLACE SHOULD BE INSTALLED AND FOR YOUR SATISFACTION, THIS FIREPLACE HAS BEEN SERVICED BY A QUALIFIED INSTALLER to conform with TEST-FIRED TO ASSURE ITS OPERATION AND QUAL- local codes. Installation practices vary from region to re- ITY! Maximum input is 40,000 BTU/hr for natural gas and gion and it is important to know the specifics that apply to propane. -
Page 5: Installation
It must never be installed inside the stand for a standard 20lb cylinder is available from your warm air envelope of your structure. Napoleon Dealer. It is highly recommended that this fireplace be installed in 1. Move the fireplace into position and secure using the a “sheltered”... -
Page 6: Framing
When roughing in the fireplace, raise the fireplace to ac- FRAMING commodate for the thickness of the finished floor materi- It is best to frame your fireplace after it is positioned. Use als, i.e. tile, carpeting, hard wood, which if not planned for will interfere with the opening of the lower access door 2x4's and frame to local building codes. -
Page 7: Finishing
FINISHING LOG PLACEMENT PHAZER logs are exclusive to Napoleon Fireplaces, provide a unique and realistic glowing effect that is different in every installation. Log colours may vary. During the initial use of the fire- place, the colours will become more uniform as colour pigments burn in during the heat activated curing proc- ess. -
Page 8: Curtain Mesh
HOOD LOGO PLACEMENT Remove FIGURE 12 backing of the logo supplied and place on the HOOD screen cover, as indicated. CURTAIN MESH FIGURE 14 LOUVRE INSTALLATION UPPER LOUVRES: In- The curtain mesh must be kept fully closed during opera- FIGURE 15a-c sert the upper louvres HOOD tion to help prevent accidental burns from occurring. -
Page 9: Control Which Has Been Under Water
AIR SHUTTER OPENINGS on all openings when the gas knob for the burner is turned on. A 5 to 10 second total light-up period is satisfactory. If 7/16" ignition takes longer, consult your Napoleon dealer / dis- tributor. FIGURES 16 FULLY OPEN... - Page 10 Contact your dealer for questions concerning prices and When ordering replacement parts always give the follow- policies on replacement parts. Normally all parts can be ing information: ordered through your Napoleon dealer or distributor. 1. M & S ODEL ERIAL UMBER OF FIREPLACE 2.
- Page 11 TROUBLE SHOOTING GUIDE SYMPTOM PROBLEM TEST SOLUTION Main burner goes Pilot flame is not large - turn up pilot flame. out; pilot stays on. enough or not engulfing the - replace pilot assembly. thermopile Thermopile shorting - clean thermopile connection to the valve. Reconnect. - replace thermopile / valve.
- Page 12 SYMPTOM PROBLEM TEST SOLUTION Pilot goes Gas piping is undersized. - turn on all gas appliances and see if pilot flame flutters, dimin- while standing; ishes or extinguishes, especially when main burner ignites. Monitor Main burner is in appliance supply working pressure. 'OFF' position.