Assembly; Loose Parts - RIDGID R4090 Operator's Manual

ASSEMBLY

UNPACKING
See Figure 5.
This product requires assembly.
 Carefully lift the saw from the carton and place on a level
work surface.
WARNING:
Do not use this product if any parts on the Loose
Parts List are already assembled to your product
when you unpack it. Parts on this list are not as-
sembled to the product by the manufacturer and
require customer installation. Use of a product that
may have been improperly assembled could result
in serious personal injury.
 Inspect the tool carefully to make sure no breakage or
damage occurred during shipping.
 Do not discard the packing material until you have care-
fully inspected and satisfactorily operated the tool.
 The saw is factory set for accurate cutting. After
assembling it, check for accuracy. If shipping has influ-
enced the settings, refer to specific procedures explained
in this manual.
 If any parts are damaged or missing, please call
1-866-539-1710 for assistance.
WARNING:
If any parts are damaged or missing do not oper-
ate this tool until the parts are replaced. Use of
this product with damaged or missing parts could
result in serious personal injury.
WARNING:
Do not attempt to modify this tool or create acces-
sories not recommended for use with this tool. Any
such alteration or modification is misuse and could
result in a hazardous condition leading to possible
serious personal injury.
WARNING:
Do not connect to power supply until assembly is
complete. Failure to comply could result in ac-
cidental starting and possible serious personal
injury.
ATTACHING HANDLES TO THE READY RACK™
TILE CARRIER AND WATER TANK
See Figure 6.
The long handle should be attached to the Ready Rack™ Tile
Carrier while the shorter handle is used on the water tank.
On both sides of the Ready Rack ™ tile carrier and the water
tank are slots to be used for handle installation.
 Place the handle below the slot then pull up on the handle
until it slides into the slot.
 Repeat with the water tank.
lonG
handle
short
handle
12 — English
readY racK™
tile carrier
slot
water
tanK
Fig. 6