Install Kickstand Assembly; Fuel Mixture Instructions - AMF SKI-DADDLER Parts And Service Manual

C
c
• Attach the positive
(+)
battery cable (and the
RED wire lead from cigarette lighter SD18E20B
only) to the positive terminal post.
• Position the holddown strap across the battery
and over the holddown rods. Secure the strap and
battery using locknuts and washers. Do not over-
tighten.
• Replace the hood and headlight assembly.
Install Kickstand Assembly - Models SO IBE20B,
SO IBE25B and SO IBP21 A Only
The attaching hardware required for kickstand
installation will be found in the plastic parts bag
shipped with the Ski-Daddler snowmobile. Check
container against the following list to be certain no
parts are missing or damaged.
Part No.
Description Qty
37175
Kickstand assembly - 18 inch
1
32234 Spring
2
37186
Long spacer, 1- 11/32 LG 2
33778 Short spacer, 13/32 LG
2
181575 Hex head bolt, 1/4- 28 THD by
4
1- 1/2 IN.
181578
Hex head bolt, 1/4-28 THD by
2
1-7/8 IN.
9000123
Locknut, 1/4-28 THD
6
33808
Formed washer 6
446188
Flat washer, 17/64 ID 4
• During initial installation, assemble all compo-
nents loosely as shown in figure 3. After completing
,
~.,
~~
~1!!1
::::::i/
!
~'H '
:
LOCKNUT(6)~
~ ~
_ FLAT WASHER (4) @.... SHORT
- <-
SPACER
- , - KICK STAND '-.. (2)
~ .
' - BRACKET
.> ' - ....
-- -- . . . ; r '
, ___ --- SCREW (2)/ _
.>
...
--
--
---
---
"".s::;a
A "- --- ---
;- LONG SPACER
(2)~~ SC REW
(4)
~
SPRING (2)
Figure 3
1002472
5
~IPREDELIVERY
INSTRUCTIONS
1e.~Si3~
the installation, tighten all nuts and bolts securely
but do not overtighten.
• Check the installation by setting the sled on the
kickstand as shown in figure 13.
Fuel Mixture Instructions
WARNING
Never fill the gasoline tank while the
engine is hot. Wipe off any spilled
gasoline before attempting to start
engine.
The correct oil-to-gasoline ratiO is 20: 1 (20parts
regular gasoline to 1 part oil). Too much oil will
cause carbon deposits. Too little oil or a poor mix
will cause insuffiCient lubrication and possible
engine damage.
IMPORTANT: Gasoline and oil should be mixed at
temperatures ' above zero. At temperatures below
zero gas and oil mix with difficulty.
Fuels containing additives are not recommended for
use in Ski-Daddler engines. For mixing with gaso-
line, use AMF-nondetergent oil prepared exclu-
sively for use in air-cooled, 2-cycle engines.
IMPORTANT: Some outboard motor oils contain a
detergent that works well in outboard motors that
operate at much lower temperatures because they
are water cooled. However, the detergents may
cause spark plug fouling in the air-cooled engines
used on Ski-Daddler snowmobiles.
Use a mixture of gasOline and oil as shown in the
Fuel Mixture Chart. Neve' r use gasoline left over
from the summer or previous winter.
FUEL MIXTURE CHART
OIL (Ounces)
o
4 8 12 16 20 24 28 32 36 40
5
/
/~
/
~/
4
V
",
/""
/ ",
""
/
",
~
",'"
/
~
3
2
/
v,..
U.S. Gallons
Imperial Gall ion.
T-
o
GASOLINE
(Gallons) GASOLINE/O IL RATlO - 20 to 1