Introduction; Predelivery Instructions; Install Ski Assembly - AMF SKI-DADDLER Parts And Service Manual

c
c
c
INTRODUCTION
This manual has been prepared to provide all
authorized AMF Ski- Daddler Dealers, Distributors
and technicians with the instructions necessary to
service and maintain the 1970/1971 AMF MARKIV
and MARK V series Ski- Daddler snowmobiles.
The series classification for each snowmobile is
clearly shown on the left-hand side of the console
control panel. The Model Number and Serial Number
are permanently stamped on the nameplate attached
to the rear right-hand side of the main frame as-
sembly. When ordering accessories or replacement
parts, always indicate the correct Model Number
and Serial Number as shown on the nameplate.
The following list identifies the Ski-Daddler series
claSSification, corresponding model numbers and
engine designation covered in this manual.
,:---series
"l\i
Classification Model Number
Engine
IMARK IV-300
SD15PI0B JLO 295
MARK V-400
SD18P27A Hirth 399
MARK V-400E
SD18E27A Hirth 399
MARK V-400DE SD18E25B Kohler 399
MARK V-500DE SD18E20B Hirth 493
MARK
V-640 SD18P21A
Hirth 634
SD15P10B
111
I
Manufacturer's engine code number
P
=
Prepared
f~r electri~
starter;
E
=
Equipped WIth electriC starter
Traction belt width in inches
Ski-Daddler
This manual is presented in two sections. The first
section, Maintenance, provides the instructions
necessary for maintenance and service while the
second section, the Illustrated Parts List is pro-
vided to facilitate the ordering of spare and replace-
ment parts.
The Parts List section also contains a numerical
listing of all items shown in the Illustrated Parts
List. Thus, if the part number is known but not its
application, refer to the numerical list.
If
the part
number is not known, locate the item on the illus-
tration to obtain the index number keyed to the
applicable parts list.
1002472
3
~I
INTRODUCTION
IMPORTANT To keep the AMFWarrantyinforce,
be certain to use only AMF -Approved replacement
parts. The AMF-Warranty does not apply to parts
covered by the original manufacturer's warranty
such as engine or engine parts, starters, belts,
carburetor battery or other components or acces-
sories not
~anufactured
by AMF. Should any claim
arise concerning these items, follow the manufac-
turer's instructions.
If
the information in this manual is not applicable to
all models, the exceptions will be noted and the cor-
rect information for the particular model will be
given.
PREDEL/VERY INSTRUCTIONS
The 1971 Ski-Daddlers are shipped completely as-
sembled except for the windshield assembly, the
ski assembly and the kickstand assembly. On the
electric-start models, the battery is installed but
not activated.
These assemblies, plus the attaching hardware will
be found in the shipping container. Carefully open
the carton and immediately inspect the eqUipment
for any damage or missing items.
IMPORTANT: The owner must retain the Ski-
Daddler Inspection Record, FormNo. 4477QA. This
form must be shown to the dealer should any claim
arise under the AMF Warranty.
Install Ski Assembly
• Place the spindle pads (figure 1) in the spring
mounting bracket with the thicker section and the
directional arrow on the pad pointing forward.
NO" TE: The spindle pads and attaching hardware,
locknuts and 3-1/4-inch length screws, will be
found in the plastiC bag shipped with the sled.
Figure 1
LOCKNUT
SP IND LE PAD
(THICK SECTION
FORWJ>.RDJ