Sea Ray 175 Sport Owner's Manual

Sea Ray 175 Sport Owner's Manual

Hide thumbs Also See for 175 Sport:
Table of Contents

Advertisement

Sea Ray
Owner's
Manual
175 Sport
Owner's Manual Part Number: MRP 1805237

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 175 Sport and is the answer not in the manual?

Questions and answers

Ben
May 8, 2025

I have a 2006 Searay 175 boat but lost power to the radio

Subscribe to Our Youtube Channel

Summary of Contents for Sea Ray 175 Sport

  • Page 1 Sea Ray Owner’s Manual 175 Sport Owner’s Manual Part Number: MRP 1805237...
  • Page 2 Owner’s Manual you will be referred to informa- your Sea Ray, gives you important information on all tion provided by manufacturers of specific the features of your Sea Ray, for years of trouble- systems. free boating take the time to carefully review the information in your Owner’s Manual Packet and...
  • Page 3 This Page Was Intentionally Left Blank 175 Sport...
  • Page 4: Ntroduction

    Owner’s Manual Packet. Locate and read the individual warranties; then put them • Canadian Power and Sail Squadrons together for easy future reference. The Sea Ray ® warranty is on the warranty information card in your •...
  • Page 5: Hull Identification Number (Hin)

    Failure to include it creates sell products in the United States. Sea Ray ensures delays. Also of vital importance are the engine serial that all of its products comply with these laws.
  • Page 6: Service, Parts And Repair For Your Boat

    ONTACT HONE UMBERS NTERNET DDRESSES When your boat needs service, parts or repair, take it to an authorized Sea Ray dealer. To find a dealer Sea Ray Boats USA ® in your area call: Phone ........1-800-SRBOATS Fax ........... 1-314-213-7878 Internet ........
  • Page 7: About Your Limited Warranty

    Thank you for your decision to buy a Sea Ray. The Limited Warranty is subject to change at any time at Sea Ray’s discretion. The information contained herein is general information about the Limited Warranty for the owner’s general knowledge, and does not alter or amend the terms of the Limited Warranty.
  • Page 8: Table Of Contents

    19. Key to Symbols on Control & Prints ....1.16 D. Bilge Blower ..........4.2 20. Environmental Considerstions ......1.18 E. Engine and Stern Drive ......... 4.3 A. Fuel & Oil Spillage ........1.18 F. Bilge Layout ........... 4.6 175 Sport...
  • Page 9 ® Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications, materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea Ray is not ®...
  • Page 10: Ection Safety

    Being aware of your passenger’s safety at all Replacement safety labels can be obtained by times; and calling your dealer or Sea Ray at 1-800- SRBOATS for information on how to contact the • Reducing speed when there is limited visibility, manufacturing facility for your boat.
  • Page 11: Legally Mandated Minimum Required Equipment

    Store pyrotechnic signals in a well-marked waterproof container in a dry location. Other: Your Sea Ray is equipped with the required navigation lights, engine exhaust and ventilation systems. 175 Sport...
  • Page 12: Carbon Monoxide

    To minimize the danger of CO accumulation when the engine and/or generator are running, or using burning fuel applications. • Be sure to have sufficient ventilation when using canvas or window-type side curtains when underway, anchored, moored or docked. 175 Sport...
  • Page 13: Lifesaving Equipment

    Boat operators are required to carry one wearable personal flotation device (Type I,II,III or V) for every person on board. Boats must also have at least one throwable device (Type IV). 175 Sport...
  • Page 14: Additional Recommended Equipment For

    • Mooring lines Before purchasing PFDs, ensure • Fenders that there is an attached tag indicating they are approved by the U.S. Coast Guard or by your national boating law enforcement agency. 175 Sport...
  • Page 15: Impaired Operation

    GUARD SAFETY STANDARDS IN EFFECT ON THE DATE OF CERTIFICATION The detrimental effects of alcohol and drugs are SEA RAY BOATS, INC. MANUFACTURER: increased by the wind, waves and sun, quickly KNOXVILLE TN...
  • Page 16: Load Capacity

    Passengers can fall overboard if not seated properly on the seats provided. Your Sea Ray has been equipped with a propeller ® which our tests have shown to be the best suited...
  • Page 17: Stability

    There can be people in the water, property. You are responsible for damage partially submerged debris, and other navigational caused by your wake. hazards such as rocks, sand bars, dangerous currents, to name a few. 175 Sport...
  • Page 18: General Considerations

    Boat use is limited to small lakes, rivers and boat’s limitations. Modify speed in keeping with canals. weather, sea and traffic conditions. Your 175 Sport is Design Category C. • Instruct passengers on location and use of The wind speed and wave height specified as the safety equipment and procedures.
  • Page 19: Chart Your Course

    Give the float plan to a friend or relative, so they can give the information to a national boat agency, like the U.S. Coast Guard, in the event you fail to return. 1.10 175 Sport...
  • Page 20: Water Sports

    Slow down and look for swimmers or skiers when cruising in an area where there might be persons in the water. TURN LEFT STOP TURN RIGHT TURN GO FASTER SLOW DOWN OK AFTER FALL SKIER IN WATER CUT MOTOR BACK TO DOCK 1.11 175 Sport...
  • Page 21: Diving

    At least two people on board your courteous to others sharing the water: boat should be CPR certified, and should have taken a first aid course. Equip your boat with a first aid kit. 1.12 175 Sport...
  • Page 22: Water Rescue

    • If the boat is floating stay with the boat. Hang water to assist the victim. on, or climb on the boat and signal for help. • Handle the victim with care. Spinal injuries may have occurred. 1.13 175 Sport...
  • Page 23: Collisions And Leaking

    Determine whether or not you can repair the problem yourself. See the proper manuals for assistance in troubleshooting the engine, steering and engine controls. • If you are not sure you can fix the problem, or if conditions are adverse, signal for help. 1.14 175 Sport...
  • Page 24: Safety Hotlines

    Community. Helm – steering console. Further information concerning these requirements Hull – the basic part of a boat that provides may be obtained from Sea Ray Customer Service: ® buoyancy to float the weight of the craft and its load.
  • Page 25 ENGINE START STOP CONTROL START SWITCH ROTATIONAL (TWIN ENGINE ONLY) SPEED ENGINE ENGINE OIL FUEL ENGINE (COOLANT) FUEL, DIESEL PRESSURE LEVEL COOLANT FUEL WATER JACKET GENERAL TEMPERATURE UNLEADED LEADED FUEL BILGE BILGE BLOWER FUEL FUEL FILTER PUMP 1.16 175 Sport...
  • Page 26 OPERATION (THROTTLE & SHIFT) ING DIRECTION BOW DOWN ROTARY CONTROL (QUANTITY INCREASES WARNING FIRE NO OPEN FLAME WITH WIDTH OF PROPELLER BATTERY ELECTRICAL RISK NO SMOKING SYMBOL) HAZARD LIFT POINT OR PROPER LIFT LOCATION OF POINT SLING 1.17 175 Sport...
  • Page 27: Fuel & Oil Spillage

    FOR BOATS WITH VACUFLUSH ® HEADS ONLY Fill tank(s) less than rated capacity. Allow for fuel expansion. Do not place facial tissues, paper towels or sanitary napkins in head. Such material can damage the waste disposal system and the environment. 1.18 175 Sport...
  • Page 28: Excessive Noise

    Each power boat operator is responsible for injury or damage caused by the boat’s wake. Be especially careful in confined areas such as channels or marinas. Observe “no wake” warnings. CAUTION Reduce speed in congested waterway. Be alert for No Wake markers. 1.19 175 Sport...
  • Page 29 1 • S ECTION AFETY This page intentionally left blank. 1.20 175 Sport...
  • Page 30: Warning Label Locations

    21. 175 Spor 21. 175 Spor 21. 175 Sport t t t t W W W W W ar ar ar ar arning La ning La ning La bel Loca bel Loca tions tions 21. 175 Spor 21. 175 Spor...
  • Page 31 175 Spor 175 Spor 175 Sport t t t t W W W W W ar ar ar ar arning La ning La ning La bel Loca bel Loca tions (Contin tions (Contin ued) ued) 175 Spor 175 Spor ning La...
  • Page 32 La ning La bel Loca bel Loca tions (Contin tions (Contin ued) ued) 175 Spor 175 Spor 175 Sport Dash t Dash ning La ning Label Loca bel Loca bel Locations (Contin tions (Contin tions (Continued) ued) ued) ARNING...
  • Page 33 W W W W W L L L L L I I I I I B B B B B A A A A A GE NTENTION NTENTION NTENTION NTENTION NTENTIONALL ALLY Y Y Y Y LANK LANK LANK LANK LANK 1.24 175 Sport...
  • Page 34: Ection Eneral Oat Rrangement

    Do not place slings where they may lift on underwater fittings. & S LEAT TERN OCATIONS . 2.1.1) CLEAT BOW & STERN EYE BOW EYE CLEAT STERN CLEAT CLEAT STERN CLEAT 175 Sport...
  • Page 35: Propulsion System

    Wear slip resistant footwear secured to your feet and hold on to rails or boat structure. 4. P ROPELLERS Your Sea Ray has been equipped with propellers ® which our tests have shown to be the best suited for general use under normal conditions and load.
  • Page 36 Wear slip resistant footwear secured to your feet and hold on to rails or boat structure. DANGER Rotating propellers can injure or kill you. Shut off engine when persons are in water, near boat, on swim platform or ladder. 175 Sport...
  • Page 37 (C) DRAFT (DN) 34" (86.4cm) STERN DRIVE FULL LOAD WATER LINE (A) 17’ 6” (5.33 cm) (B) BEAM 7’ 0" (2.13 m) 175 SPORT SPECIFICATIONS HEIGHT DIMENSIONS (A) Overall Length ....... 17ft. 6in. 5.33m (D) Height Overall ...... 4ft. 9in. 1.45m (B) Beam (Width) ......
  • Page 38 WITH SWIVEL BASE HELM SEAT WITH SWIVEL BASE SKI/KNEE BOARD FLOOR STORAGE ENGINE COMPARTMENT COVER WITH GAS ASSIST LIFTS JUMP SEAT WITH JUMP SEAT REMOVABLE CUSHION (BATTERY BELOW) FUEL FILL AFT NAVIGATION LIGHT POLE INSERT SWIM PLATFORM LADDER SKI TOW 175 Sport...
  • Page 39: General Deck Layout

    BELOW WALK-THROUGH WINDSHIELD COMPANION SEAT WITH SWIVEL BASE HELM SEAT WITH SWIVEL BASE SKI/KNEE BOARD FLOOR STORAGE BENCH SEAT ENGINE COMPARTMENT COVER WITH GAS ASSIST LIFTS FUEL FILL AFT NAVIGATION LIGHT POLE INSERT SWIM PLATFORM LADDER SKI TOW 175 Sport...
  • Page 40 GASOLINE VAPORS CAN EXPLODE RESULTING IN INJURY OR DEATH BEFORE STARTING ENGINES: • CHECK ENGINE COMPARTMENT BILGE FOR GASLINE OR VAPORS, AND • OPERATEBLOWER FOR FOUR MINUTES, AND •VERIFY BLOWER OPERATION RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEED. 175 Sport...
  • Page 41: Description Of Major Controls

    The “Throttle Only” mechanism (Figure 2.8.2) may differ from one style gear/throttle unit to another. Refer to your Gear Shift & Throttle Manual for proper “THROTTLE ONLY” operation of this feature. BUTTON (PUSH IN AND HOLD WHILE MOVING LANYARD SHIFT LEVER FORWARD) AND CLIP 175 Sport...
  • Page 42: Power Trim Unit And Gauge

    Immediately reduce your engine end of the upward travel. To bring the drive unit down RPM and trim the outdrive DOWN slightly until into boating position, push the power trim switch engine slows down and you regain forward speed. down. 175 Sport...
  • Page 43: Ignition Shutdown Switch (Standard On Side Mount Controls)

    To reset the ignition shutdown switch after it has been activated, simply reinstall the switch clip above the shutoff switch and flip the switch to the UP X1000 position. 0 0 0 0 0 HOURS 175 Sport 2.10...
  • Page 44: Oil Pressure, Water Temperature

    “Underway” means the boat is not docked or at anchor. Trolling or drifting with engine off is considered “underway” and navigation lights must be used. AVIGATION AND NCHOR IGHT WITCH . 2.11.1) NAVIGATION ANCHOR LIGHT LIGHT 140 180 175 Sport 2.11...
  • Page 45 2 • G ECTION ENERAL RRANGEMENT NTENTIONALLY LANK 175 Sport 2.12...
  • Page 46: Section 3 • Using Your Boat

    A damaged hull can be unsafe; it could cause the boat dangers of Carbon Monoxide (CO) information to sink. in this manual. Use a trailer that can properly support the boat’s weight and shape. Get professional help in picking the right trailer for your boat. 175 Sport...
  • Page 47: Trailer Launching And Loading

    Gasoline vapors can explode from static electricity if fueling is not done properly. • Shut off engine, bilge blower and all other electrical equipment. Read and understand this section • Shut off gas burning appliances (gas stove, etc.). 175 Sport...
  • Page 48: Boarding

    Leave compartment open until no odor is apparent. Close compartment. • If fumes in the engine compartment do not disappear, do not turn on blower or start engine. Get help from trained and experienced persons before using the boat. 175 Sport...
  • Page 49: Personal Flotation Devices (Pfds)

    Verify that prevent falling overboard or getting knocked the bilge pump is operating about in the boat at all times when the boat is PTIONAL QUIPMENT by turning the bilge pump underway. 175 Sport...
  • Page 50 THROTTLE ONLY button TRAINED HELP TO and move shift/throttle FIND AND FIX THE THROTTLE ONLY lever forward to full open PROBLEM. BUTTON throttle, then return to IF OIL PRESSURE GOES ABOVE OR BELOW OPERATING RANGE, SHUT ENGINE DOWN IMMEDIATELY. GET 175 Sport...
  • Page 51: Shifting To Drive The Boat

    INSPECTED AT LEAST TWICE A YEAR BY YOUR Cockpit can fill with water if boat is moving forward, when it is put into reverse. SEA RAY DEALER. See Section 8 of this manual for inspection, service and maintenance Before shifting into reverse, shift to neutral, wait for recommendations.
  • Page 52 OUTING . 3.7.1) . 3.7.2) SHIFT / THROTTLE CONTROL BOX POWER STEERING CYLINDER STEERING CABLE FLUID RETURN LINE FLUID PRESSURE LINE FLUID RETURN LINE CHECK & ADD FLUID HERE HELM STEERING RACK STEERING WHEEL SHIFT THROTTLE CABLE CABLE 175 Sport...
  • Page 53 3 • U ECTION SING This Page Was Intentionally Left Blank 175 Sport...
  • Page 54: Underwater Gear

    After removing your boat from the water, unthread the drain plug to drain the bilge (Figure 4.1.1). BILGE PUMP RAIN FLOAT SWITCH . 4.1.1) ILGE UMP AND ILGE LOWER WITCH . 4.1.3) Fuel GARBOARD TRANSOM HULL DRAIN URETHANE CAULK BILGE BILGE DRAIN PLUG BLOWER PUMP 175 Sport...
  • Page 55: Bilge Blower

    DO NOT use the boat until the problem is corrected. The bilge pump is protected by two fuses, one in the fuse block located behind the control station and the other in a fuse holder adjacent to the battery (See Fig. 6.4.2). 175 Sport...
  • Page 56: Engine And Stern Drive

    If this doesn’t clear the entanglement, and you can’t anchor or moor the boat in shallow water to get to the stern drive in the water, the boat will have to be taken out of the water. 175 Sport...
  • Page 57 Have the propeller for a particular application. Available propellers removed by an authorized dealer or trained are listed in the Mercury Precision Parts / mechanic. Quicksilver Accessories Guide. 175 Sport...
  • Page 58 (Figure 4.5.4). COAT WITH ANTI-SEIZE LUBRICANT (F . 4.5.4) SECURING TABS Install the thrust washer, propeller, continuity washer, thrust hub, propeller nut retainer and the propeller nut onto the shaft (Figure 4.5.1). 175 Sport...
  • Page 59: Bilge Layout

    AYOUT ILGE AYOUT . 4.6.1) A Float Switch F Power Trim Pump B Bilge Pump G Bilge Blower C Battery & Battery Tray H Fuel Tank D Bilge Pump Fuse 7.5 amp E Stereo Memory Fuse 15 amp 175 Sport...
  • Page 60: Section 5 • Fuel System

    The 175 Sport standard gasoline fuel system consists of a 21 gallon (79.5 liters) fuel tank, fuel CAUTION...
  • Page 61: Fueling Precautions

    Spills – wipe; dispose of rags ashore. B. B & D – EFORE URING UELING HECKLIST • Fire extinguisher – close at hand. • Mooring – boat tied securely to fueling pier. • Crew – at least one knowledgeable person present. 175 Sport...
  • Page 62 5 • F ECTION YSTEM OCATION . 5.3.1) FUEL TANK VENT FUEL FILL OPENING FUEL FILL CAP DANGER NOTICE JUMP SEAT FLOOR PLAN SUN PAD FLOOR PLAN (STANDARD) (OPTION) FUEL FILL PLATE FUEL FILL PLATE 175 Sport...
  • Page 63 5 • F ECTION YSTEM This Page Was Intentionally Left Blank 175 Sport...
  • Page 64: Section 6 • Electrical System

    If your boat will not be used for several weeks remove the batteries from the boat and connect To prevent arcing or damage to the alternator, them to a charger. always disconnect battery cables before doing any work on the engine’s electrical system. 175 Sport...
  • Page 65 TO ENGINE NEGATIVE TERMINAL POSITIVE CABLES NEGATIVE CABLES ATTERY ABLE OUTING CE O NTERNATIONAL PTION ATTERY WITCH . 6.2.2) STBD BATTERY SWITCH PORT (WITH INTERNATIONAL CE OPTION) BATTERY TO ENGINE STARTER TERMINAL TO ENGINE NEGATIVE TERMINAL POSITIVE CABLES NEGATIVE CABLES 175 Sport...
  • Page 66: Battery Switch

    Do not use automotive parts for these components or any jumper cables because they are not ignition- protected and could cause a fire or explosion. ATTERY WITCH OCATION . 6.3.2) PORT STBD BATTERY SWITCH LOCATED IN AFT STARBOARD COCKPIT 175 Sport...
  • Page 67: Fuses

    8. 12V RECEPTACLE ATO FUSE 9. ACCESSORY *BLANK (AUTO TYPE) 10. ACCESSORY *BLANK *FOR DEALER OR CUSTOMER INSTALLED EQUIPMENT CCESSORY OLDERS OCATED DJACENT TO ATTERY . 6.4.3) FUSE NAME FUSE AMPERAGE 12VDC BILGE PUMP STEREO MEMORY ATO FUSE (AUTO TYPE) 175 Sport...
  • Page 68: Lighting

    ML906 Zinc anodes require replacement about every six months if the boat is operated in salt water for extended periods of time. In fresh water, the zinc anodes can be replaced about once a year. 175 Sport...
  • Page 69 If the anodes are deteriorating rapidly, or not at all, contact your dealer. NODE . 6.6.1) ZINC ANODE 175 Sport...
  • Page 70: Wire Harnesses

    6 • E ECTION LECTRICAL YSTEM 6. W ARNESSES ARNESS . 6.7.1) 175 Sport...
  • Page 71 6 • E ECTION LECTRICAL YSTEM 7. 175 S PORT EATS LECTRICAL CHEMATICS DC W IRING IAGRAM . 6.8.1) DRAWING NO. 09-601 (1 OF 2) REVISION 05 / 175 SPORT WITH JUMP SEATS ONLY 175 Sport...
  • Page 72: Electrical Schematics

    6 • E ECTION LECTRICAL YSTEM 175 S PORT EATS LECTRICAL CHEMATICS ONTINUED DC W IRING IAGRAM . 6.9.1) DRAWING NO. 09-601 (2 OF 2) REVISION 08 / 175 SPORT WITH JUMP SEATS ONLY 175 Sport...
  • Page 73 6 • E ECTION LECTRICAL YSTEM 175 S PORT LECTRICAL CHEMATICS DC W IRING IAGRAM . 6.10.1) DRAWING NO. 09-603 (1 OF 2) REVISION 0 / 175 SPORT WITH SUN PAD ONLY 6.10 175 Sport...
  • Page 74 6 • E ECTION LECTRICAL YSTEM 175 S PORT LECTRICAL CHEMATICS ONTINUED DC W IRING IAGRAM . 6.11.1) DRAWING NO. 09-603 (2 OF 2) REVISION 02 / 175 SPORT WITH SUN PAD ONLY 6.11 175 Sport...
  • Page 75 6 • E ECTION LECTRICAL YSTEM This Page Was Intentionally Left Blank 6.12 175 Sport...
  • Page 76: Section 7 • Options & Accessories

    WARNING tag for limiting speeds when Bimini Top canvas is installed. The rear (aft) curtain also has a WARNING tag stating “The Aft The following canvas options are available: • Bimini Top and Boot • Cockpit/Tonneau Cover • Tonneau Cover 175 Sport...
  • Page 77: Installation Tips

    Damage will occur to canvas and to the metal rods (bows) or boat if attached to boat while trailering. C. C ANVAS ARE AND AINTENANCE TONNEAU COVER See Section 9, for instructions on the care and maintenance of your canvas. 175 Sport...
  • Page 78: Ervice And

    Owner’s Manual • Canvas Clean Owner’s Manual As Needed Controls Steering Check for proper operation To be done by Sea Ray dealer every six months Power steering oil level Engine Manual • Throttle Lubricate. Include all shift Engine Manual • •...
  • Page 79: Summary Guide For Inspection, Service And Maintenance

    Check for loose, damaged Owner’s Manual • or missing parts Transmission Oil Strainer Screen Clean To be done by Sea Ray dealer annually Zincs (Also see **Mercathode System) Stern drive Check and replace Owner’s Manual Every 25 hours of operation needed...
  • Page 80: Inspection, Service And Maintenance Protocol

    • Check all wiring for proper support. 2. E NGINE • Check all wiring insulation for signs of fraying Engine failure or malfunction, when away from or chafing. shore, can be dangerous. Make certain you do the 175 Sport...
  • Page 81: Topside And Supplies

    D. F an expiration date. YSTEMS • Check the signaling equipment and emergency ASOLINE flares. Make sure all items are within their • Fill fuel tank with gasoline and the expiration dates. 175 Sport...
  • Page 82: Fuel System

    • Check power steering fluid level in the power • Test the navigation lights. steering pump reservoir. • Check all wiring for loose connections. • Inspect all hydraulic hoses for leaks. Keep 175 Sport...
  • Page 83 FLUID HERE qualified dealers authorized by manufacturer of the steering system of your boat. HELM DETAILED OPERATING INSTRUCTIONS AND STEERING RACK WARRANTY INFORMATION ARE PROVIDED BY THE EQUIPMENT MANUFACTURER AND CAN BE FOUND IN THE OWNER’S PACKET. STEERING WHEEL 175 Sport...
  • Page 84: Section 9 • Care & Refinishing

    The water. Gelcoat chalk, however does not wash off. gelcoat is the outer surface, often colored, that presents the shiny smooth appearance associated 175 Sport...
  • Page 85: Stains & Scratches

    • Never use nail polish remover (acetone) or any ketone solvents. The bottom paint should be inspected annually. If it needs repainting consult your Sea Ray ® • Use diluted household detergents to remove dealer.
  • Page 86: Bilge/Engine Compartment

    Inspect the wiring on the Use of protective chemicals is not required. engine and clean and tighten the terminals. Inspect the belts and tighten them if needed. Clean and lubricate the battery terminals; fill the battery cells with distilled water as needed. 175 Sport...
  • Page 87: Canvas And Clear Vinyl

    The fabric should be cleaned regularly before substances such as dirt, pollen, etc. are allowed to accumulate on and become embedded in the fabric. The fabric can be cleaned without being removed from the installation. Simply brush off any loose dirt, 175 Sport...
  • Page 88: Interior Upholstery Fabric

    Packet. NOTICE Always clean spots, stains, etc., immediately. Test an unseen area of fabric before cleaning stain, to insure that cleaning material will not cause damage. REFER TO THE OWNER'S MANUAL PACKET FOR INSTRUCTIONS AND OTHER CLEANING INFORMATION. 175 Sport...
  • Page 89 9 • C & R ECTION EFINISHING This Page Was Intentionally Left Blank 175 Sport...

Table of Contents

Save PDF