Page 1
Owner’s Manual 190 Sport Manual Part Number: MRP 2064033...
Page 3
Owner’s options please visit www.searay.com. There you Manual. will be able to view all Sea Ray manuals and any items that are not included in this manual. The Owner’s Information Packet contains the...
Page 4
Information in this publication is based upon the latest product specifications available at printing. Sea Ray ® Boats, Inc. reserves the right to make changes at any time, without notice, in the colors, equipment, specifications, materials and prices of all models, or to discontinue models. Should changes in production models be made, Sea ®...
This publication does not contain component or accessory manuals. 1. Passenger Locations/Stability ........1 Please visit www.searay.com for a complete library of all Sea Ray 2. Load Capacity ............2 Owner’s and Accessory Manuals 3. Design Category ............2 4.
NOTICE is used within their boundaries. Information which is important to proper operation or Contact state boating authorities or any marine maintenance, but is not hazard related. dealer for registration requirements. Sea Ray Boats...
U.S. Coast Guard Auxiliary are included with your Owner’s Manual Packet. • U.S. Power Squadron The Sea Ray® Express Limited Warranty is on the warranty information sheet and in this manual. • Canadian Power and Sail Squadrons Please locate and read the individual warranties.
Sea Ray product be done by ® You will find information regarding the Sea Ray ® an authorized dealer at the authorized dealer’s warranty following the introduction. A warranty location. information card is also included in the owner information packet.
Page 10
The new owner can submit this request, free of charge, via the searay.com website or through a local authorized Sea Ray Dealer where processing fees may be applied. Sea Ray reserves the right to reject any warranty transfer request for a boat that has been damaged, neglected, or otherwise previously excluded from warranty..
The manufacturer’s load rating is the maximum allowed under calm conditions. WARNING Reduce boat loading if weather, water or other Rear facing transom seats MUST NOT be used while conditions are adverse. engine is running or boat is moving. 190 Sport ®...
GET TO SHORE BEFORE for boats under 26' (7.9 meters). THE WEATHER TURNS BAD B. Canada – Transport Canada only provides All Sea Ray Sport Boats are Design Category C. ® specific numbers for passenger capacity or The wind speed and wave height specified as the...
Wners anual 5. K eY To YMbols on onTrols rinTs These symbols may be found on your controls and gauges and/or used in this owner’s manual. This page is to help you understand what the symbols mean. 190 Sport ®...
6. b asic iMensions anD learances ImensIons and learances . 5.1) WATERLINE KEEL 190 Sport SpecificationS HeigHt DimenSionS ® (A) Overall Length (D) Keel to Top of Windshield ....4ft. 8¾in. 1.44 m With Std. Swim Platform ..19ft. 8in. 5.99 m (E) Waterline to Top of Windshield ..3ft.
Even a small amount of water in the engine can cause rust and is to be avoided. Never hoist the boat with an appreciable amount of water in the bilge. Fuel and water tanks should preferably be empty, especially if of large capacity. 190 Sport ®...
12. b 13. e ilge aYouT ngines The engines are the heart of your Sea Ray Sport Boat. Proper attention to and maintenance Ilge ayouT of your engines will assure you of many hours . 12.1) of pleasurable, safe boating and will prevent unnecessary engine problems.
YsTeM additives WILL NOT be covered under warranty. Sea Ray Sport Boats are equipped with a carbon canister. This canister filters all the hydrocarbons Thanol lenDeD uels that pass through the canister. If the carbon canister...
Page 24
Periodically inspect for the presence of water in the fuel tank. If any is found, all water must be removed and the tank completely dried before refilling the tank with any fuel containing ethanol. 190 Sport ®...
Page 25
190 s ® porT Wners anual ysTem . 15.1) fueL tank fiLL fueL tank vent engine feed carbon canister fueL tank 190 Sport ®...
MP3 device port and is satellite radio ready. 17. c anvas The following canvas pieces are available individually as options: Sunbrella® Bimini Top w/ Boot Cockpit and Tonneau Covers w/ storage Bag Travel/Storage Cover 190 Sport ®...
The batteries installed in your boat have been selected for their ability to furnish starting power based on engine starting requirements, as well as their ability to power the DC accessories attached to the electrical system. 190 Sport ®...
Page 30
Use charger only when battery the ventilation is sufficient, and temperatures do not is disconnected from the boat’s electrical circuit. drop below freezing (0°C/32°F). Disconnecting the Follow the charger instructions. battery is not necessary if boat is equipped with an 190 Sport ®...
50 percent, do not put a battery into service that has less than 30 percent SOH. A battery load tester is a general indicator of a battery's ability to provide a cranking current, but it is not as accurate as actual SOC and SOH readings. 190 Sport ®...
Switching between batteries should also be avoided the alternator. while the engine is running unless the switch has been specially designed for this purpose aTTery elecTor WITcH . 22.2) ypIcal aTTery WITcH . 22.1) 190 Sport ®...
Some of the various types of fuses and breakers used on your boat are as follows: Fig. 23.1 is an automotive- . 23.1) type blade ATO/ATC fuse shown being used in an in-line FUSE fuse holder. 190 Sport ®...
Refer to the owner's manual package for instructions we recommend that you take your boat to your and warranty information. authorized Sea Ray dealer for service. Sea Ray ® ® reserves the right to change or update the electrical system on any model at any time without notice to the consumer and is NOT obligated to make any updates to units built prior to changes.
Page 35
190 s ® porT lecTrIcal ysTem dc W IrIng Iagram draWIng no. 2039020 (1 of 1) . 25.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. 190 Sport ®...
Page 36
190 s ® porT lecTrIcal ysTem dc W IrIng Iagram draWIng no. 09-601 (1 of 2) . 26.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. 190 Sport ®...
Page 37
190 s ® porT lecTrIcal ysTem remIer Tereo IrIng cHemaTIc draWIng no. 09-608 . 27.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. 190 Sport ®...
Page 38
09-874 . 28.2) Warning: Warning: DO NOT attempt to DO NOT attempt to work on the electrical system work on the electrical system of this boat without professional of this boat without professional assistance. assistance. 190 Sport ®...
Page 39
Helm, gauges, and Switches Layout ......7 Hull Identification Number (HIN) ......... vi This publication does not contain component or accessory manuals. Please visit www.searay.com for a complete library of all Sea Ray Through-Hull Cutouts ........... 6 Owner’s and Accessory Manuals Index i...
Need help?
Do you have a question about the 190 Sport and is the answer not in the manual?
Questions and answers