Air Filter - Baja motorsports RT150 Owner's Manual

Maintenance (continued)

AIR FILTER

Air filter (3) is located on the left rear side of the scooter.
To remove filter:
1. Remove air filter cover (1) by removing screws. To access top of cover
bolts, remove side fender cowling (2)
2. Remove filter (3) , check to see if filter is dirty or torn, if damaged, replace.
3. Clean air filter by gently tapping on a hard surface, you can also clean by
using pressurized air. Note: Too much air pressure could damage air filter.
4. Clean outer foam element with solvent then allow to dry.
5. Apply oil to the entire surface of the foam element then ring out excess
oil. Foam element should be damp with oil but not soaked. Re attach foam
element to air filter.
6. Re-install air filter into scooter.
Note: Drain the oil accumulated in the clear tube after every 1,000 miles
CAUTION
The air filter elements must be intact or the engine will suck in dust and
dirt resulting in a shorter service life of the engine.
Water should be prevented from entering into the filter when washing
the vehicle.
The air filter elements shall be cleaned gently to prevent from cracking
or tearing. Replace filter elements with a new ones if broken or
cracked.
2
28
3
1