Table of Contents
Advertisement
Quick Links
SC50 SCOOTER
Read this manual carefully. t contains important safety information.
No one under the age of 16 should operate this scooter.
OWNER'S MANUAL
Minimum Recommended Age
Requirement 16
Always wear a helmet; t could save your Life!
Do not remove this operator's manual from this vehicle.
Please obtain, review, and follow provincial / municipal government acts and regulations pertaining to owning and operating this scooter.
Rev. E
Advertisement
Table of Contents
Related Manuals for Baja motorsports SC50
Summary of Contents for Baja motorsports SC50
- Page 1 SC50 SCOOTER Read this manual carefully. t contains important safety information. No one under the age of 16 should operate this scooter. OWNER’S MANUAL Minimum Recommended Age Requirement 16 Rev. E Always wear a helmet; t could save your Life! Do not remove this operator’s manual from this vehicle.
- Page 2 Should you experience a problem or need to return your Baja Motorsports SC50 Scooter for repair, please call the BAJA MOTORSPORTS customer service department TOLL FREE at 1-888- 863-BAJA (2252) between the hours of 7am and 5pm Monday thru Friday PST and Saturday 8am to 4pm PST.
- Page 3 WARNNG This manual should be considered as a permanent part of the vehicle and should remain with the vehicle when resold or otherwise transferred to a new user or operator. The manual contains important safety information and instructions which should be read carefully before operating the vehicle.
-
Page 4: Table Of Contents
Table of Contents MPORTANT ................2 GENERAL PRECAUTONS/WARNNGS ......3 NHTSA SAFETY NOTCE ............ 8 PRE RDE CHECK LST ............9 OPERATON ................13 STARTNG THE ENGNE ..........13 DRVNG SAFELY ............14 SHUTTTNG OFF THE ENGNE ........15 STOPPNG THE VEHCLE ..........15 PARKNG................ -
Page 5: Mportant
Important Please read this manual and follow all instructions carefully. To emphasize the special information, the symbol and the words WARNING or CAUTION have some special meanings. Pay great attention to the messages. WARNNG ndicates a potential hazard that could result in death or injury. -
Page 6: General PrecautOns/WarnNgs
General Precautions WARNING! FAILURE TO FOLLOW THESE INSTRUCTIONS CAN RESULT IN SEVERE INJURY OR DEATH. CAUTION: FAILURE TO FOLLOW THESE INSTRUCTIONS CAN ALSO RESULT IN DAMAGE TO THE VEHICLE AND/OR OTHER PROPERTY. Read and follow all instructions in this Owner's/Operator's manual, any accompanying supplements, and the Engine Owner's Manual before attempting to operate this vehicle. -
Page 12: Pre RDe Check LSt
WARNING! ALWAYS PERFORM THE ENTIRE PRE-RIDE CHECKLIST BEFORE USING THE VEHICLE AS THIS CAN HELP YOU SPOT PROBLEMS THAT COULD INTERFERE WITH SAVE VEHICLE OPERATION. FAILURE TO FOLLOW THIS ENTIRE CHECKLIST BEFORE EVERY RIDE CAN CAUSE DEATH, SERIOUS INJURY, AND/OR PROPERTY DAMAGE TO YOUR- SELF AND/OR OTHERS Front Turn Under seat... -
Page 15: Fuel And Oil
FUEL AND OIL FUEL The proper fuel is very important for the engine. Ensure that there is no dust, dirt, or water which has mixed in the fuel. Please use regular unleaded gasoline ENGINE OIL Your scooter has a four-stroke engine. Please use oil as described in the chart below. -
Page 18: ShutttNg Off The EngNe
Authorized Baja Motorsports service center... -
Page 20: RGht Brake/SwTch Assembly
Operation (Cont’d) Right brake/ switch assembly On/Off Safety stop Switch (1) The On/Off safety stop switch needs to be at “on” position before scooter will start. The safety stop switch is available in case of an emergency. Electric starter switch (2) The electric starter switch is located directly under On/Off safety stop switch. -
Page 21: KCk Starter
Kickstarter... -
Page 22: Nstrument Panel
Clock and Date (6) Seat lock... -
Page 23: Fuel Tank
The gas cap is located under the gas cap cover. To open, lift seat then open gas cap cover by inserting key and turning clockwise. Seat Gas Cap Gas Cap Cover... -
Page 24: MaNtenance
Maintenance Checking and Changing engine oil Checking engine oil Remove engine oil dip stick cap (1). Check oil level on dipstick. Add oil if below 3/4 full. Refer to page 12 for correct engine oil type. Changing engine oil To drain old engine oil, place catch basin under engine and unscrew drain plug(2) located on bottom left side of engine. -
Page 25: Changing Transmission Oil
Maintenance (cont’d) Changing Transmission oil The transmission oil was filled at the factory before shippment, Drain and refill transmission oil every 5000km (3100 miles) Draining transmission oil Drain transmission oil by removing drain screw (1) located on bottom of transmission (2) . Drain oil into a catch basin and dispose of properly at oil relcaim facility Adding Transmission oil... -
Page 26: AR FLter
Maintenance (cont’d) Air Filter Checking Air filter The air filter (1) is located on the left side of the scooter. Remove air filter cover by removing screws (2). If filter is dirty, follow cleaning instructions below. Cleaning Air filter 1. Remove foam element (3) from air filter housing (1). -
Page 27: Brakes
Maintenance (cont’d) Brakes FRONT HYDRAULIC DISK BRAKE 1. Inspect front disk brake caliper (1) for leakage. If brake fluid leaks, the safety of riding could be affected. 2. Inspect the brake hose (2) for cracks, and the joint for leakage. 3. -
Page 28: Dle Speed Adjustment/Fuel Hose Nsp
Idle speed adjustment To adjust the idle speed properly, you need a tachometer. If you do not have one, ask your authorized service center to perform this adjustment. Engine Idle adjustment Screw To adjust the idle speed: 1. Start the engine and warm it up. 2. -
Page 29: TRes
Maintenance (cont’d) Tires 3.0 mm (0.12 in) The scooter is equipped with tires of the size and type listed below: Front Rear Size 3.50 x 10 3.50 x 10 Tire Tread Condition WARNING Operating this scooter with improper tires, or even improper tire air pressure could be hazardous. -
Page 31: TransportNg
Transporting It is best to transport the scooter in the normal position. Before transporting the scooter drain the fuel from the carburetor as follows: 1. Drain fuel from carburetor into an empty container by loosening the carburetor drain screw (1). The carburetor drain screw is located at the bottom of the engine . -
Page 32: Storage Procedure
Storage Procedure If you do not use your scooter for a long time, it will need special service requiring appropriate materials, equipment and skill. For this reason, we recommend that you trust this maintenance work to your authorized service center. If you wish to service the machine for storage yourself, follow the general guidelines below: VEHICLE Place the vehicle on level ground and wash the entire vehicle. -
Page 33: Maintenance Chart
Maintenance Chart t is very important to inspect and maintain your scooter regularly. Follow the guidelines in the chart. The intervals between periodic services in miles are shown. At the end of each interval be sure to perform the maintenance listed. -
Page 34: Troubleshooting
Improper repairs or adjustments may damage the vehicle. Such damage may not be covered under warranty. If you are not sure about the proper action, consult your authorized service center or Baja Motorsports about the problem. Fuel Supplying Check 1. Make sure there is adequate fuel in the fuel tank. -
Page 35: Ignition System Check
Trouble shooting (Cont’d) Ignition System Check 1. Remove the spark plug and reattach it to the spark plug lead. 2. Turn ignition key to the “RUN” position. Slide the engine stop switch to the “Run” position. Push the electric button “START “(grey button). If the ignition system is operating properly, a blue spark should jump across the spark plug gap. -
Page 36: Specifications
Specifications Description Data Description Data Engine Type 4 Stroke/Air cooled Horse Power (HP) 1.8 HP Overall length 1676mm Displacement 49.5cc (66”) Overall width 660mm Starter Electric with suppliment (26”) kick start Overall height 1067mm Brake Front: Disc Hydraulic; (42”) Rear: Drum Dead weight 87kg Rear wheel... -
Page 37: SerAl Number LocatOn
You need to know the frame and engine serial numbers to get warranty work, theft recovery and consumer safety information. You also need these numbers to help your authorized service center or Baja Motorsports order parts. The Frame number is stamped on front of scooter just above the front floor base. - Page 38 BAJA INC. – EMISSION CONTROL SYSTEM WARRANTY YOUR WARRANTY RIGHTS AND OBLIGATIONS The emission control system warranty period for this vehicle begins on the date the vehicle is de- livered to the first purchaser other than an authorized dealer, or the date it is first used as a dem- onstrator, lease, or company vehicle, whichever comes first and continues for 60 months after that date, or 12,000km, whichever comes first, provided there has been no abuse, neglect or improper maintenance of your vehicle.
- Page 39 Your emission control system warranty covers components whose failure would increase an en- gine’s emission, including electronic controls, fuel injection system, carburetor, the ignition sys- tem, catalytic converter, or any other system utilized in this vehicle to control emission if it is origi- nally equipped.
- Page 40 • Physical damage, corrosion, or defects caused by fire, explosions or similar causes beyond the control of the Distributor. • Failures not caused by a defect in material or workmanship. Use of the vehicle in any type of competitive racing or related events immediately and completely voids this and all other warranties.
- Page 41 LIMITED LIABILITY The liability of the Distributor under this Emission Control System Warranty is limited solely to the remedying of defects in material workmanship by an authorized dealer at its place of business during customary business hours. This warranty does not cover inconvenience or loss of use of the vehicle or transportation of the vehicle to/from the authorized dealer.
- Page 42 Baja Inc. P.O. Box 61150 Phoenix, Az. 85082 Tel: 602-443-9180 Toll Free: 888-863-2252...