Dux AiroHeat D2FH00000C Owner's Manual

Dux AiroHeat D2FH00000C Owner's Manual

Heat pump water heater

Advertisement

Owner's Manual
Heat Pump Water Heater
Model: D2FH00000C
Installation Details

Commissioning Checklist

Owner's Information (warranty)
For advice, repairs and service, call:
1300 365 115 (Australia)
0800 729 389 (New Zealand)
Specifications and materials may change without notice.
Effective for Airoheat
Part No: H3023
Version: 10155G
Water Heaters manufactured and sold after 1st June 2006.
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the AiroHeat D2FH00000C and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Dux AiroHeat D2FH00000C

  • Page 1: Commissioning Checklist

    Owner’s Manual Heat Pump Water Heater Model: D2FH00000C Installation Details Commissioning Checklist Owner’s Information (warranty) For advice, repairs and service, call: 1300 365 115 (Australia) 0800 729 389 (New Zealand) Specifications and materials may change without notice. Effective for Airoheat Water Heaters manufactured and sold after 1st June 2006.
  • Page 2: Table Of Contents

    Owner’s Manual – Airoheat ® Contents Welcome To Dux Hot Water Owner’s Instructions Installation Details Troubleshooting Plumbing Connections System Maintenance Electrical Connection Safety Information Installation Checklist Service Information Commissioning The System Warranty Operational Diagrams Warranty Card Commissioning Check List Part No: H3023...
  • Page 3: Welcome To Dux Hot Water

    – safely, economically, and for many years to come. To be upfront about it, we want Dux to be your brand of choice. So you can depend on us to provide more than just a hot water system.
  • Page 4: Installation Details

    Owner’s Manual – Airoheat ® Installation Details This water heater must be installed All warranty is voided if the unit is laid on by a licensed tradesperson, and in its side for storage or transport. It must accordance with: be stored and transported in a near vertical position at all times, there are no •...
  • Page 5 Owner’s Manual – Airoheat ® Installation Details Location Preferred Location The water heater should be located as If possible the location selected for the close as possible to the most frequently heat pump should be on the warm side used hot water outlet. Ensure that the of the home.
  • Page 6 Owner’s Manual – Airoheat ® Installation Details Noise Considerations Transportation The selected location must consider Ensure the Airoheat is always stored and noise impact on living areas, especially transported in an upright position. bedrooms, inside the house. Although Note: All warranty is voided if the unit is the running noise level is very low (51 laid on its side for storage or transport.
  • Page 7: Plumbing Connections

    Owner’s Manual – Airoheat ® Plumbing Connections Installation Dimensions Table (mm) – 250 Litre Tank Height (A) 1755 Overall Diameter Height (from base of heater) Hot Water Outlets (B) 1231 Cold Water Inlets Minimum louver clearances Sides All measurements approximate only. Specifications and material are subject to change without notice.
  • Page 8: Hot Water Connection

    Water Quality Pressure & Temperature Relief Your Dux water heater has been Valve manufactured to suit all water conditions The Pressure & Temperature Relief Valve in “All Water Areas” present in Australia.
  • Page 9: Condensation Drain

    Owner’s Manual – Airoheat ® Plumbing Connections Caution: DO NOT braise the copper Condensation Drain All heat pump water heaters will create elbow to a condensate drain line, this condensation from the evaporator will result in damage to the louver coil.
  • Page 10: Electrical Connection

    Owner’s Manual – Airoheat ® Electrical Connection Note: The water heater is fitted with Electrical Connection The unit is designed for connection to an electronic temperature control and an over-temperature energy cut-out. - CONTINUOUS TARIFF, single phase Under no circumstances should the 240 volt AC supply.
  • Page 11 Owner’s Manual – Airoheat ® Electrical Connection Hotlogic Operational Codes Red light (Status) Green light (Power) Power LED Status LED Explanation (Green) (Red) Alternating Power on initialisation (LEDs blink alternately) Power on Fan on (compressor on/off) Flashing Ambient sensor error (possible tank sensor error) Flashing Tank sensor error Flashing...
  • Page 12: Installation Checklist

    Owner’s Manual – Airoheat ® Installation Checklist Always transport the Airoheat in the Ensure there is no obstruction on upright position, if you lay it on its top of the Airoheat that will block side the refrigeration system may be the air outlet.
  • Page 13: Commissioning The System

    Owner’s Manual – Airoheat ® Commissioning The System When both the plumbing and electrical Then allow the water in the tank to connections have been completed the reheat. system is ready to run. Once the reheat cycle is complete, Before applying power to the system measure the water temperature at ensure that the system is full of water PTR outlet again.
  • Page 14: Operational Diagrams

    Owner’s Manual – Airoheat ® Operational Diagrams Refrigeration View Cut-through View Main Component View Part No: H3023 Version: 10155G...
  • Page 15: Commissioning Check List

    Owner’s Manual – Airoheat ® Commissioning Check List The Airoheat produces water Ensure there is no obstruction on condensation, so make sure the top of the Airoheat that will block unit is installed on a flat surface, the air outlet. and ensure you install a condensate When the system is turned on, drain from the condensate drain...
  • Page 16: Owner's Instructions

    Owner’s Manual – Airoheat ® Owner’s Instructions The appliance is not intended for The superheated gas is pumped, from use by young children or infirm the compressor, to a water immersed persons without supervision. Young condenser coil where it gives up its children should be supervised to heat energy to the water.
  • Page 17 The amount of condensation will vary with the humidity of the location so the Operating through Dux’s patented amount of condensate that flows from Hotlogic controller, the system the module will vary (see the section on instinctively determines when conditions condensation on page 18).
  • Page 18 Owner’s Manual – Airoheat ® Owner’s Instructions on for several minutes at a sink, basin Does The Heat Pump Need Sun- or bath but not a dishwasher, clothes light To Operate? Unlike solar water heaters heat pump washer, or other appliance. During this water heaters extract their energy procedure there must be no smoking, from the surrounding air and not from...
  • Page 19: Troubleshooting

    • Do you have the correct size water during the heating cycle. The amount heater for your requirements? Sizing of discharge will depend on hot water details are available from your Dux usage. supplier. Continuous Trickle (PTR) • Is one outlet (such as the shower)
  • Page 20 Owner’s Manual – Airoheat ® Troubleshooting 450 litres of water it is possible that Condensation Is Dripping From there will be certain times of the Inside The Airoheat day where there is insufficient hot Check that the discharge location of the water.
  • Page 21: System Maintenance

    Owner’s Manual – Airoheat ® System Maintenance The heat pump water heater is designed Every 5 years you should contact the to eliminate system maintenance other local service agent to replace all safety than that detailed in this Owner’s valves and anodes to ensure continued system life and operational safety.
  • Page 22: Safety Information

    Owner’s Manual – Airoheat ® Safety Information For safe performance this water heater The Pressure & Temperature Relief is fitted with: Valve should be checked for adequate performance or replaced at intervals • an over-temperature energy cut-out not exceeding 5 years, or less in areas thermostat.
  • Page 23: Service Information

    (vi) To flush the heater, carry out steps where it is recommended that this (i) to (iv) above. Disconnect the hot service be carried out by your local Dux water inlet union and attach a water agent. supply hose to the heater. Turn on The service should include the following: the water supply.
  • Page 24: Warranty

    Airoheat and covers the repair after the end of the 1 year warranty and/or replacement of any failed period, Dux will provide a free component in the Airoheat. Under replacement Airoheat at the this warranty Dux will repair or...
  • Page 25 Where an Airoheat or a component water supply, excessive water in the Airoheat is replaced by Dux, pressure, over temperature the balance of any original warranty or neglect of any kind to the or replacement guarantee period will Airoheat or components.
  • Page 26 Airoheat or the replacement of the Airoheat. components. To the extent the repair of the Airoheat. permitted by law, Dux will not be the payment of the cost of liable for any loss or damage to replacing the Airoheat or of...
  • Page 27: Warranty Card

    Privacy Act Amendment (2000): If and whenever warranty service is required, your personal details will only be given to an Authorised Dux Service Agent for the express purpose of carrying out the arranged warranty service work agreed by you the client and Dux Manufacturing Limited.
  • Page 28 Owner’s Manual – Airoheat ® Heat Pump Water Heater For advice, repairs and service, call: 1300 365 115 (Australia) 0800 729 389 (New Zealand) Part No: H3023 Version: 10155G...

Table of Contents

Save PDF