Page 1
STAINLESS STEEL NATURAL GAS GRILL MODEL NO.: 730-0512 ITEM NO: 27043 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. ® 4 0 0 3 0 0 5 0 0 2 0 0...
TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions…………………………………. Exploded View……………………………..Placement of the Grill……………………………… Parts List………………………………………… 28-29 SECTION TWO SECTION SIX Side Shelf Assembly……………………………… Grilling Hints…………………………………….. Side Burner Assembly…………………………….. Grill Cooking Chart……………………………… 30-32 Side Burner Hose Quick Disconnect Assembly… Grill Recipe Suggestions……………………….
SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION...
Page 4
SAFETY INSTRUCTIONS WARNING WARNING Do not use the grill if the odor of gas is Failure to properly place the burner over the present. Contact customer service at 1-800- orifice could cause a fire to occur behind and 554-5799. beneath the valve panel, thereby damaging the grill and making it unsafe to operate.
Page 5
SAFETY INSTRUCTIONS USING THE SIDE BURNER WARNING Inspect the gas supply hose prior to turning on Do not attempt to light the grill if gas odor is the gas. If there is evidence of cuts, wear or present. Contact customer service at 1-800-554- abrasion, it must be replaced prior to use.
Page 6
SAFETY INSTRUCTIONS The grill is not intended to be installed in or on WARNING recreational vehicles and/or boats. Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this Children should not be left alone or unattended in an manual.
Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 730-0512 natural gas grill is designed for do not use a wet sponge or cloth to clean the grill optimum performance without the use of briquettes.
SIDE SHELF ASSEMBLY Estimated Assembly Time: Approximately 10 minutes Required Tools: Phillips Screwdriver (not included) 1. Open the grill lid and remove the side shelf from the fire box. 2. The screws used to attach the side shelf are already screwed into the side of the grill cart. Remove the screws from the side panel.
SIDE BURNER ASSEMBLY 1. Open the grill lid. 2. The screws used to attach the side burner are already screwed into the right side of the grill cart. Remove the screws from the side panel. 3. Align the holes on the right side burner with the holes in the grill cart. Insert the screws and tighten. 4.
SIDE BURNER HOSE QUICK DISCONNECT ASSEMBLY Estimated Assembly Time: Approximately 5 minutes No Tools Required 1. Insert the side burner hose with female sleeve through side panel of cart (A). 2. Push the sleeve of the female socket back and insert the male end of the connector. Release the sleeve.
QUICK DISCONNECT ASSEMBLY 1. Install the quick disconnect by pulling the spring ring downward on the female connector; insert the female connector and release the spring ring (A). 2. After spring ring is released, male and female quick disconnect will be locked together. Double check by slightly pulling the hose connector upward, if not properly connected, hose will be detached.
SIDE SHELF HANDLE ASSEMBLY Estimated Assembly Time: Approximately 5-7 minutes Required Tools: Phillips Screwdriver (not included) 1. Remove the four side shelf handle screws from the side of the shelf. 2. Align the holes in the side shelf handle with the holes in the shelf. 3.
BRAKING SYSTEM OPERATION 1. Push to the right to lock. 2. Push to the left to unlock. 50 0 6 00 80 0 INSTALLATION OF NATURAL GAS REGULATOR 1. Connect the PVC natural gas hose to the house gas supply line using the quick-connect fitting as shown in figure A.
SPICE TRAY INSTALLATION Insert the tabs on the spice tray into the holes on the left door of the grill. 3 00 40 0 60 0 10 0 7 00 COOKING GRIDDLE INSTALLATION Remove one of the cooking grids from the firebox and insert the cooking griddle.
Total 77,000 BTU/Hr. Total gas consumption (per hour) of the 730-0512 The installation of this appliance must conform with Natural Gas Grill with all burners set on “HI”: local codes or, in the absence of local codes, with the National Fuel Gas Code ANSI Z223.1 and the...
INSTALLER FINAL CHECK The gas supply shut off valve has been located. Specified clearance maintained of 24 inches from combustible materials/constructions. All burners are factory installed. All internal packaging has been removed. Keep the instruction manual with the grill for future reference.
OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 13,000 BTU/Hr. The After its first use, the stainless steel adjacent to the main grill burners encompass the entire cooking rotisserie burner will most likely turn dark blue. This area and are side ported to minimize blockage from is a normal property of the non-rusting type falling grease and debris.
NOTE Adjust the counterbalance weight to balance the It is normal for the skewer to flex when larger cuts heavier side of the meat and avoid lopsided rotation of meat are being cooked. of the rotisserie motor. If the meat scrapes on the cooking grids during any CAUTION part of the rotation, the cooking grids must be When using the rotisserie burner, remove the...
LIGHTING ILLUSTRATIONS MAIN BURNER LIGHTING ROTISSERIE BURNER & SEARING SIDE BURNER LIGHTING 1. Open the top cover or lid. 1. Push and turn rear burner slowly to “INGITE / ON” setting; you should hear a “clicking sound if the electronic ignition system is working properly.
TO MATCH LIGHT THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. Main Burner 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate.
Page 21
Sear Burner 1. If you have already attempted to light the searing side burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting rod. Ignite the match and insert through the cooking grid to the burner.
Page 22
Rotisserie Burner Note: Remove the warming rack when using a match to light the rotisserie burner. 1. If you have already attempted to light the rotisserie burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. 2. Insert a match into the lighting rod. Ignite the match and place near the rotisserie burner. 3.
GRILL LIGHTS Light Operation Instruction 1. Make sure light’s power switch on the control panel is in the “OFF” position. 2. Connect power plug to properly grounded outlet. 3. Turn the light’s power switch to “ON”. WARNING Keep any electrical supply cord away from any heated surface.
Page 24
5. Use a screwdriver to loosen the two screws locking the bulb. Pull out the light bulb and replace with a new bulb. 6. Reverse the instruction from steps 5-1 for installation. Cleaning Method Follow steps 1-4 above for glass cover removal. Use a damp towel to clean the surface of glass cover.
USING THE SIDE BURNER Inspect the gas supply hose prior to turning on the 4. If the smell of gas is detected and the igniter is gas. If there is evidence of cuts, wear or abrasion, it not functioning, immediately turn the control must be replaced prior to use.
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING STAINLESS STEEL Clean the exterior of the burner with a wire brush. There are many stainless steel cleaners Clear any clogged burner ports with a straightened available. Always use the mildest cleaning paper clip.
CARE & MAINTENANCE OF THE GRILL STAINLESS STEEL GRILL BURNERS Grease specks can gather and bake onto the Extreme care should be taken when moving a surfaces of the stainless steel, giving the burner. It must be correctly centered on the orifice appearance of rust.
TROUBLESHOOTING WHEN TO LOOK FOR SPIDERS You should inspect the burners at least twice a WARNING year or immediately after any of the following Spiders and insects can nest inside the burners conditions occur: of the grill and disrupt gas flow. This very dangerous condition could cause a fire behind 1.
PARTS LIST Model No. 730-0512 REF# DESCRIPTION REF# DESCRIPTION Main lid Screw Cover Front Trim Panel, Left Main lid screw Door Handle Tube Main Lid Front Door, Left Temperature Gauge Door Handle Seat Logo Front Door, Right Main Lid Handle Heat Insulating...
PARTS LIST Model No. 730-0512 REF# DESCRIPTION REF# DESCRIPTION NG regulator clamp Main Burner NG Regulator Hose Flame Tamer Regulator, NG Cooking Grid With Hole NG brass connector Cooking griddle NG Hose W/ quick connector Warming Rack Lamps Main Lid Handle Tube...
GRILLING HINTS This Jenn-Air grill has an infrared side burner – It is recommended that meat be defrosted overnight commonly referred to as a “searing” burner. This in the refrigerator as opposed to a microwave. This type of burner produces extreme heat that can be generally yields a juicier cut of meat.
Page 33
French fries Medium 15 to 30 minutes Place in aluminum foil pan. Grill, stirring occasionally. FOOD WEIGHT FLAME APPROXIMATE SPECIAL INSTRUCTIONS OR THICKNESS SIZE TIME AND TIPS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface.
Page 34
POULTRY 1 to 1-1/2 hours Place skin side up. Grill. Turn and Broiler/fryer 2 to 3 pounds brush frequently with melted butter, margarine, oil, or marinade. FOOD WEIGHT FLAME APPROXIMATE SPECIAL INSTRUCTIONS OR THICKNESS SIZE TIME AND TIPS Breasts Medium 30 to 45 minutes Marinate with Italian dressing well-done FISH AND...
GRILL RECIPES BBQ SALMON Half-hour before cooking, turn the 1tsp. Worcestershire sauce 2 large salmon steaks burner to the grill on high. Drain 1tsp. Dry mustard 2 tbs. oil seafood-reserving marinade. On each 1/4 tsp. Thyme, crushed Salt & pepper of twelve 10 in.
Page 36
heat tortillas on grill. Slice meat across CHICKEN TANDOORI STYLE 2 oz. lemon juice grain in thin slices. Place on hot platter. 8 large chicken thighs or drumsticks 10 lbs. pork roast Squeeze lemon juice over. Wrap meat and 1 c. plain nonfat yogurt any of the following toppings in tortillas: 1/2 c.
Our telephone number is 1-800-554-5799, fax number 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc., 280 Machlin Court, City of Industry, California, 91789, ATTN: Warranty Service Center. *Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Inc. Printed in China...