Table of Contents
Advertisement
Quick Links
STAINLESS STEEL NATURAL GAS GRILL
MODEL NO.: 730-0339
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe's Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE
DO NOT RETURN TO PLACE OF PURCHASE
ITEM NO: 127141
400
500
300
200
150
250
200
600
100
300
50
¡ ã
C
350
100
F
¡ ã
700
®
Advertisement
Table of Contents
Related Manuals for Jenn-Air 730-0339
Summary of Contents for Jenn-Air 730-0339
- Page 1 STAINLESS STEEL NATURAL GAS GRILL MODEL NO.: 730-0339 ITEM NO: 127141 Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated. ® ¡ ã ¡ ã FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE...
-
Page 2: Table Of Contents
TABLE OF CONTENTS SECTION ONE SECTION FIVE Safety Instructions ………………………………….. Exploded View ………………………………. Placement of the Grill ……………………………..Parts List …………………………………….. 21-22 SECTION TWO SECTION SIX Pie Cart Assembly …………………………………. Grilling Hints ………………………………..Side Burner Hose Quick Connect ……………….. Grill Cooking Chart ………………………..23-25 Battery Assembly …………………………………... -
Page 3: Safety Instructions
SAFETY INSTRUCTIONS RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS WARNING WARNING Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Spiders and insects can nest inside the burners of CAUTION... -
Page 4: Safety Instructions
SAFETY INSTRUCTIONS WARNING WARNING Do not use the grill if the odor of gas is Failure to properly place the burner over the present. Contact customer service at 1-800- orifice could cause a fire to occur behind and 554-5799. beneath the valve panel, thereby damaging the grill and making it unsafe to operate. - Page 5 SAFETY INSTRUCTIONS USING THE SIDE BURNER WARNING Inspect the gas supply hose prior to turning on Do not attempt to light the grill if gas odor is the gas. If there is evidence of cuts, wear or present. Contact customer service at 1-800-554- abrasion, it must be replaced prior to use.
- Page 6 SAFETY INSTRUCTIONS WARNING The grill is not intended to be installed in or on Do not try lighting this appliance without first reading recreational vehicles and/or boats. the “LIGHTING INSTRUCTIONS” section of this manual. Children should not be left alone or unattended in an area where the grill is being used.
-
Page 7: Placement Of The Grill
Do not use briquettes of any kind in the grill. Clean the grill with caution. To avoid steam burns, The 730-0339 natural gas grill is designed for do not use a wet sponge or cloth to clean the grill optimum performance without the use of briquettes. -
Page 8: Pie Cart Assembly
PIE CART ASSEMBLY Estimated Assembly Time: 20 minutes Required Tools: Phillips Screwdriver (not included) Step1: Unscrew the back panel from the pie cart, and then remove the back panel. (Fig.1) Fig. 1 70 0 Step 2: Loosen the side panel top two screws a quarter of the way out. -
Page 9: Pie Cart Assembly
PIE CART ASSEMBLY Step 4: Re-tighten the top screws. Apply the screws and the washers 5 00 20 0 60 0 1 00 8 00 70 0 into the bottom part of the side panel. Fig. 4 (Fig. 4) 3 0 0 4 0 0 5 0 0 2 0 0... -
Page 10: Side Burner Hose Quick Connect
SIDE BURNER HOSE QUICK-CONNECT 1. The side burner hose connects the side burner manifold directly to the main grill manifold. The side burner hose comes from the factory connected to the main grill manifold. 2. To connect the hose to the side burner manifold, push the hose through the hole in the side panel of the main grill cart, through the “pie”... -
Page 11: Battery Assembly
BATTERY ASSEMBLY 1. Remove the ignition button housing by turning counterclockwise. 2. Insert the battery into the housing with the positive (+) terminal facing outward. 3. Replace the ignition button housing after the battery has been installed. -
Page 12: Installation Of Natural Gas Regulator
INSTALLATION OF NATURAL GAS REGULATOR 1. Connect the PVC natural gas hose to the house gas supply line using the quick-connect fitting as shown in figure A. 2. Perform the leak test on page 11 before each use. Do not use the grill until all connections have been checked and do not leak. -
Page 13: Leak Testing
24,000 BTU/Hr. Total 96,000 BTU/Hr. Total gas consumption (per hour) of the 730-0339 Natural gas grill with all burners set on “HI”: The installation of this appliance must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code No. -
Page 14: Installer Final Check
INSTALLER FINAL CHECK 4. The unit has been tested and is free of leaks. 1. Specified clearance maintained 24 inches from 5. The gas supply shut off valve has been located. combustible materials/construction. 6. All burners are factory installed. 2. All internal packaging has been removed. 7. -
Page 15: Operating Instructions
OPERATING INSTRUCTIONS GENERAL USE OF THE GRILL AND ROTISSERIE Each main burner is rated at 13,000 BTU/Hr. The local codes, with the National Electrical Code, main grill burners encompass the entire cooking ANSI/NFPA 70. area and are side ported to minimize blockage from After its first use, the stainless steel adjacent to the falling grease and debris. -
Page 16: Lighting Instructions
CAUTION When using the rotisserie burner, remove the Adjust the counter balance weight to balance the warming rack. High heat from the burner may cause heavier side of the meat and avoid lopsided rotation the warming rack to bend. of the rotisserie motor. LIGHTING INSTRUCTIONS BEFORE LIGHTING…... -
Page 18: Lighting Illustrations
LIGHTING ILLUSTRATIONS MAIN & SIDE BURNER LIGHTING ROTISSERIE BURNER, SEAR BURNER OR SIDE BURNER LIGHTING 1. Push and turn rear burner knob slowly to “IGNITE / ON” setting, hold in until the burner is 1. Open the top cover or lid. lit up, continue to press and hold for 15 seconds. -
Page 19: To Match Light The Grill
TO MATCH LIGHT THE GRILL If the burner will not light after several attempts using the control knobs, the burner may be lit with a match. 1. If you have already attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. -
Page 20: Using The Side Burner
USING THE SIDE BURNER Inspect the gas supply hose prior to turning on the 4. If the smell of gas is detected and the igniter is gas. If there is evidence of cuts, wear or abrasion, it not functioning, immediately turn the control must be replaced prior to use. -
Page 21: Care And Maintenance Of The Grill
CARE & MAINTENANCE OF THE GRILL Extreme care should be taken when moving a STAINLESS STEEL burner. It must be correctly centered on the orifice Grease specks can gather and bake onto the before any attempt is made to relight the grill. surfaces of the stainless steel, giving the Frequency of cleaning will depend on how often you appearance of rust. -
Page 23: Troubleshooting
TROUBLESHOOTING WHEN TO LOOK FOR SPIDERS You should inspect the burners at least twice a WARNING year or immediately after any of the following Spiders and insects can nest inside the burners conditions occur: of the grill and disrupt gas flow. This very dangerous condition could cause a fire behind 1. -
Page 24: Exploded View
EXPLODED VIEW MODEL 730-0339 39( A) 39( C ) 39( B) 87( A) 87( B) 106( A) 106( B) -
Page 25: Parts List
PARTS LIST Model No. 730-0339 REF# DESCRIPTION REF# DESCRIPTION Ice Box Handle Sear Burner Ice box Lid Sear Igniter Wire Ice Box Main Igniter Wire (A. B. C.) Condiment Container Lid Rotisserie Burner Condiment Container Rotisserie burner Igniter Wire Condiment Frame, Top... - Page 26 REF# DESCRIPTION REF# DESCRIPTION Rotisserie Burner Thermocouple Side Burner Cart Front Door Rotisserie Burner Thermocouple Side Burner Cart Door Handle Bracket Main Burner Bowl Assembly NG Brass Connector Rotisserie Burner Flex Gas Regulator, NG Main Manifold NG Hose W/Quick Connector Rotisserie Burner Gas Valve NG Regulator Clamp Side...
-
Page 27: Grilling Hints
GRILLING HINTS This Jenn-Air grill has an infrared side burner – commonly referred to as a “searing” burner. This Use a spatula instead of tongs or a fork to turn the type of burner produces extreme heat that can be meat. - Page 28 French fries Medium 15 to 30 minutes Place in aluminum foil pan. Grill, stirring occasionally. FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS MEATS BEEF Hamburgers 1/2 to 3/4 inch Medium 10 to 18 minutes Grill, turning once when juices rise to the surface.
- Page 29 POULTRY Broiler/fryer 2 to 3 pounds Low or 1 to 1-1/2 hours Place skin side up. Grill, turning and brushing frequently with melted butter, margarine, oil or marinade. FOOD WEIGHT FLAME APPROXIMATE SPECIAL OR THICKNESS SIZE TIME INSTRUCTIONS AND TIPS Breasts Medium 30 to 45 minutes Marinate with Italian dressing...
-
Page 30: Grill Recipes
GRILL RECIPES BBQ SALMON eafood. Toss to coat. Cover, tender. Let stand 5 minutes befor 2 large salmon steaks frigerate 2 hours. serving. 2 tbs. oil Salt & pepper ARBECUED LONDON BROIL 2 oz. thin bacon slices to 6 servings 2 tbs. - Page 31 Lemon 1 medium tomato, chopped salt and hook into the rack. Turn rotisserie pepper burner on high. Bake using the Pound flank steak to ¼ inch thickness o rotisserie for 50 minutes or until done. flatten chicken breasts. Mix oil, limejuice Roast eggplant on gas grill over and seasonings in a zip lock bag.
-
Page 32: Limited Warranty
Our telephone number is 1-800-554-5799, fax number 1-800-598-8829. Please direct all correspondence to: Nexgrill Industries, Inc. 280 Machlin Court, City of Industry, California, 91789, ATTN: Warranty Service Center. *Jenn-Air is a trademark of the Maytag Corporation and is used under license to Lowe’s Company Inc. Printed In China...