Introduction; Read This Manual Thoroughly - Generac Power Systems 005789-0 Owner's Manual

INTRODUCTION

Thank you for purchasing this model by Generac Power Systems,
Inc. This model is a compact, high performance, air-cooled,
engine driven generator designed to supply electrical power to
operate electrical loads on job sites, or remote locations where
no utility power is available or in place of utility due to a power
outage.

READ THIS MANUAL THOROUGHLY

If any portion of this manual is not understood, contact the
nearest Authorized Dealer for starting, operating and servicing
procedures.
Throughout this publication, and on tags and decals affixed to the
generator, DANGER, WARNING, CAUTION and NOTICE blocks are
used to alert personnel to special instructions about a particular
operation that may be hazardous if performed incorrectly or
carelessly. Observe them carefully. Their definitions are as
follows:
After this heading, read instructions that, if
not strictly complied with, will result in serious
personal injury, including death and/or property
damage.
After this heading, read instructions that, if not
strictly complied with, may result in serious
personal injury and/or property damage.
After this heading, read instructions that, if not
strictly complied with, could result in damage to
equipment and/or property, and minor injury.
After this heading, read explanatory statements that require
special emphasis and relate to property damage.
These safety warnings cannot eliminate the hazards that they
indicate. Common sense and strict compliance with the special
instructions while performing the service are essential to preventing
accidents.
Four commonly used safety symbols accompany the DANGER,
WARNING and CAUTION blocks. The type of information
each indicates is as follows:

This symbol points out important safety
information that, if not followed, could endanger
personal safety and/or property of others.
 This symbol points out potential explosion
hazard.

This symbol points out potential fire hazard.

This symbol points out potential electrical shock
hazard.
DANGER
NOTICE:
The operator is responsible for proper and safe use
of the equipment. We strongly recommend that the
operator read this manual and thoroughly understand
all instructions before using the equipment.
We also strongly recommend instructing other users
to properly start and operate the unit. This prepares
them if they need to operate the equipment in an
emergency.

Using a generator indoors WILL KILL YOU IN
MINUTES. Exhaust contains carbon monoxide, a
poison gas you cannot see or smell.

NEVER use in the home, or in partly enclosed
areas such as garages. ONLY use outdoors and
far from open windows, doors, vents, and in an
area that will not accumulate deadly exhaust
gas.
Using a generator indoors WILL KILL YOU IN MINUTES. Exhaust contains
carbon monoxide, a poison gas you cannot see or smell.
NEVER use in the home or in partly enclosed areas such as garages.
ONLY use outdoors and far from open windows, doors and vents.
 Always disconnect the spark plug wire and
place the wire where they cannot contact the
spark plug to prevent accidental starting when
setting up, transporting, adjusting or making
repairs to the generator.
• The generator produces dangerously high voltage that can
cause extremely hazardous electrical shock. Avoid contact with
bare wires, terminals, etc. Never permit any unqualified person
to operate or service the generator.
• Never handle any kind of electrical cord or device while
standing in water, while barefoot or while hands or feet are wet.
Dangerous electrical shock will result.
• The National Electric Code requires the frame and external
electrically conductive parts of the generator be properly
connected to an approved earth ground. Local electrical codes
may also require proper grounding of the generator. Consult
with a local electrician for grounding requirements in the area.
• Do not use worn, bare, frayed or otherwise damaged electrical
cord sets with the generator.
• Operate generator only on level surfaces and where it will not be
exposed to excessive moisture, dirt, dust or corrosive vapors.
FLAMMABLE and its vapors are
• Gasoline is highly
EXPLOSIVE. Do not permit smoking, open flames, sparks
or heat in the vicinity while handling gasoline. Avoid spilling
gasoline on a hot engine. Comply with all laws regulating
storage and handling of gasoline.
 Never add fuel while unit is running. Allow
generator and engine to cool entirely before
adding fuel.
DANGER
DANGER
1