Cleaning The Vehicle - Club Car DS Golf Car 2001 Owner's Manual

Receptacle Fuse Link
As an additional feature to protect the batteries and charging circuit from an overload, the electric vehicle is
equipped with a receptacle fuse link (Figure 17, Page 31 for V-Glide 36-Volt vehicles, or Figure 18, Page
31 for PowerDrive System 48 vehicles). If the charger does not come on when the vehicle is placed on
charge, visually inspect the fuse link. See following WARNING.
WARNING
• IF THE RECEPTACLE FUSE LINK IS BLOWN, DETERMINE THE SOURCE OF THE ELECTRICAL
PROBLEM AND CORRECT IT BEFORE REPLACING THE FUSE. CONTACT YOUR NEAREST
CLUB CAR DISTRIBUTOR/DEALER.
Figure 17 Receptacle Fuse Link for 36-Volt Vehicle

CLEANING THE VEHICLE

Club Car DS vehicles are equipped with ArmorFlex
automotive cleaners with a sponge or soft cloth for normal cleaning. A garden hose at normal residential
water pressure is adequate.
Club Car does not recommend any type of pressure washing or steam cleaning. Such a process (especially
if the vehicle has an ArmorFlex rear body that is removed) will expose electrical components to moisture.
Moisture entering electrical components can result in water damage and subsequent component failure.
Use non-abrasive wax products. Battery acid, fertilizers, tars, asphalt, creosote, paint, or chewing gum
should be removed immediately to prevent possible stains.
The seats of the vehicle will last longer with proper cleaning. Use a solution of 10% liquid soap and warm
water applied with a soft cloth. For imbedded dirt, a soft bristle brush may be used. For heavy soiling, diffi-
cult stains or scratches, blemishes, or other body damage, see Section 4 of the appropriate maintenance
and service manual.
NOTE
• DISPOSE OF WASTE WATER PROPERLY.
36-VOLT
FUSE LINK
Figure 18 Receptacle Fuse Link for 48-Volt Vehicle
®
front and rear bodies. Use only commercially available
2001 DS Golf Car Electric Vehicle Owner's Manual
Cleaning the Vehicle
48-VOLT
FUSE LINK
SENSE LEAD
FUSE
31