Table of Contents
Advertisement
MODELS:
NATURAL GAS
CFL-18NG-C
CFL-24NG-C
CFL-30NG-C
ST-CFL-24NG-B
CFL-24NG-IPI
• Important operating
a n d m a i n t e n a n c e
instructions included.
WARNING: If the information in these
instructions is not followed exactly, a fi re
or explosion may result causing property
damage, personal injury, or death.
• Do not store or use gasoline or other fl am-
mable vapors and liquids in the vicinity of
this or any other appliance.
• What to do if you smell gas
- Do not try to light any appliance.
- Do not touch any electrical switch. Do not
use any phone in your building.
- Immediately call your gas supplier from a
neighbor's phone. Follow the gas suppli-
er's instructions.
- If you cannot reach your gas supplier, call
the fi re department.
• Installation and service must be performed
by a qualifi ed installer, service agency, or the
gas supplier.
In the Commonwealth of Massachusetts:
• Installation must be performed by a licensed plumber
or gas fi tter.
• The chimney fl ue damper, when used with gas logs,
will be welded open or completely removed.
• A CO detector shall be installed in the room where the
appliance is installed.
PROPANE
CFL-18LP-C
CFL-24LP-C
CFL-30LP-C
ST-CFL-24LP-B
CFL-24LP-IPI
CAUTION
DO NOT DISCARD THIS MANUAL
• Read, understand and follow
these instructions for safe
installation and operation.
Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08
Owner's Manual
Installation and Operation
• Leave this manual with
party responsible for use
and operation.
WARNING
HOT SURFACES!
Glass and other surfaces are hot during
operation AND cool down.
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
fi replace.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other fl ammable
materials.
• Keep clothing, furniture, draperies and other fl ammable
materials away.
This appliance has been supplied with an integral barrier
to prevent direct contact with the fi xed glass panel. DO
NOT operate the appliance with the barrier removed.
Contact your dealer or Hearth & Home Technologies if the
barrier is not present or help is needed to properly install one.
Installation and service of this appliance should be
performed by qualifi ed personnel. Hearth & Home
Technologies suggests NFI certifi ed
or factory trained professionals, or
technicians supervised by an NFI
certifi ed professional.
1
Advertisement
Table of Contents
Related Manuals for Heat & Glo CFL-18LP-C
Summary of Contents for Heat & Glo CFL-18LP-C
- Page 1 MODELS: NATURAL GAS PROPANE CFL-18NG-C CFL-18LP-C CFL-24NG-C CFL-24LP-C CFL-30NG-C CFL-30LP-C ST-CFL-24NG-B ST-CFL-24LP-B CFL-24NG-IPI CFL-24LP-IPI • Important operating a n d m a i n t e n a n c e instructions included. WARNING: If the information in these instructions is not followed exactly, a fi re or explosion may result causing property damage, personal injury, or death.
-
Page 2: Homeowner Reference Information
Read this manual before installing or operating this appliance. Please retain this owner’s manual for future reference. Congratulations on selecting a Heat & Glo gas appliance —an elegant and clean alternative to wood burning appliances. The Heat & Glo gas appliance you have selected is designed to provide the utmost in safety, reliability, and effi... -
Page 3: Table Of Contents
Table of Contents 1 Introduction A. Appliance Certifi cation ......4 B. High Altitude Installation ......4 2 Getting Started A. -
Page 4: Introduction
Introduction A. Appliance Certifi cation The information in this manual pertains to Models CFL-18 NG/LP-C, CFL-24 NG/LP-C, CFL-30 NG/LP-C. CFL-24 NG/LP-IPI and ST-CFL-24NG/LP-B. These gas log sets have been tested and listed in the U.S. in accordance with ANSI Z21.60b-2004. They have been listed by Underwriters Laboratories Inc. - Page 5 TOP VIEW TOP VIEW TOP VIEW TOP VIEW Figure 1. Minimum Fireplace Sizes for CFL-18/24/30-C and ST-CFL-24-B Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08 MINIMUM FIREPLACE SIZE FRONT WIDTH : 23 REAR WIDTH : 19 DEPTH HEIGHT MODEL CFL-18-C...
-
Page 6: Getting Started
Getting Started CAUTION When installing this log set in a factory built fi replace, be certain to consult the fi replace installation manual. ALL knockouts in the fi replace through which the gas supply line is run MUST be resealed with insulation after the gas line is in place. - Page 7 7. Test fi re the unit after referring to the SAFETY INFOR- MATION and LIGHTING INSTRUCTIONS found in Section 3 in this manual, or on the label plate assembly found on the gas-burner. 8. After the gas line installation is complete, all connections must be tightened and checked for leaks with a com- mercially-available, non-corrosive leak check solution.
- Page 8 • If a remote control is used, the receiver cannot be placed under the burner. If possible, place the receiver outside the combustion chamber. • If the receiver must be placed in the combustion chamber, the protective heat shield MUST be used. See Figure 5.
-
Page 9: Operating Guidelines And Maintenance Instructions
Operating Guidelines and Maintenance Instructions A. Before Lighting Appliance Before lighting this appliance determine if it has a Standing Pilot or Intellifi re ignition system by viewing the wiring system and gas valve. If this appliance has a red or black ignitor button (see Figure 3 and Figure 4) this appliance has a Standing Pilot ignition system. -
Page 10: For Your Safety Read Before Lighting
Lighting Instructions (IPI) The IPI system must be operated with two D-cell batteries. FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fi re or explosion may result causing property damage, personal injury or loss of life. A. -
Page 11: What To Do If You Smell Gas
Lighting Instructions (Standing Pilot) FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fi re or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. -
Page 12: Troubleshooting
Troubleshooting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualifi ed service technician in the diagnosis of a problem and the corrective action to be taken. This troubleshooting guide can only be used by a qualifi ed service technician. Contact your dealer to arrange a service call by a qualifi... - Page 13 Troubleshooting (continued) Symptom 3. (Continued) c. Valve. d. Plugged burner orifi ce. e. Wall switch or wires. 4. Frequent pilot outage a. Pilot fl ame may be too high or too low, or blow- problem. ing out (high pressure), causing pilot safety to drop out.
-
Page 14: Intellifi Re Ignition System
B. Intellifi re Ignition System Symptom Possible Cause 1. Pilot won’t light. a. Incorrect wiring. The ignitor/module makes noise, but no b. Loose connections or electrical spark. shorts in the wiring. c. Ignitor gap is too large. d. Module. 2. Pilot won’t light, a. - Page 15 Intellifi re Ignition System - (continued) Symptom a. A shorted or loose connection in fl ame 4. Pilot lights but contin- sensing rod. ues to spark, and main burner will not ignite. (If the pilot continues to spark after the b.
-
Page 16: Reference Materials
Reference Materials A. Service Parts Service Parts Diagram Part number list on following page. Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08 Log Set Assembly CFL-18NG-C, CFL-18LP-C Beginning Manufacturing Date: Nov. 2007 Ending Manufacturing Date: ______... -
Page 17: Service Parts List
Orifi ce NG (1.55) Orifi ce LP (2.30 mm) Piezo Ignitor Remote Heat Shield Vermiculite Wire Assembly 24 in Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08 CFL-18NG-C, CFL-18LP-C COMMENTS PART NUMBER SRV481-766 SRV481-755 SRV481-701 SRV481-705... - Page 18 CFL-24NG-IPI, CFL-24LP-IPI Service Parts Service Parts Diagram Beginning Manufacturing Date: June 2008 Ending Manufacturing Date: ______ Log Set Assembly Part number list on following page. Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08...
- Page 19 Service Parts List IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEM DESCRIPTION Log 1 Log 2 Log 3 Log 4...
- Page 20 CFL-24NG-C, CFL-24LP-C Service Parts Service Parts Diagram Beginning Manufacturing Date: Nov. 2007 Ending Manufacturing Date: ______ Log Set Assembly Part number list on following page. Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08...
- Page 21 Service Parts List IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEM DESCRIPTION Log 1 Log 2 Log 3 Log 4...
- Page 22 CFL-30NG-C, CFL-30LP-C Service Parts Service Parts Diagram Beginning Manufacturing Date: Nov. 2007 Ending Manufacturing Date: ______ Log Set Assembly Part number list on following page. Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08...
- Page 23 Service Parts List IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEM DESCRIPTION Log 1 Log 2 Log 3 Log 4...
- Page 24 Service Parts Service Parts Diagram Part number list on following page. Heat & Glo • CFL-18/24/30-C, CFL-24-IPI, ST-CFL-24-B • 526-910 Rev. E • 10/08 ST-CFL-24NG-B, ST-CFL-24LP-B Beginning Manufacturing Date: Nov. 2007 Ending Manufacturing Date: ______ Log Set Assembly...
- Page 25 Service Parts List IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEM DESCRIPTION Log 1 Log 2 Log 3 Log 4...
-
Page 26: Limited Lifetime Warranty
B. Limited Lifetime Warranty Hearth & Home Technologies LIMITED WARRANTY Hearth & Home Technologies (“HHT”) and its respective brands extends the following warranty for HHT gas, wood, pellet and electric appliances purchased from an authorized HHT dealer and installed in the United States of America or Canada. Warranty starts with date of purchase by the original owner (End User) except as noted for replacement parts. - Page 27 B. Limited Lifetime Warranty (continued) • This limited warranty does not extend to or include surface fi nish on the appliance or terminations, door gasketing, glass gasketing, glass discoloration, fi rebrick, pellet logs, kaowool or other ceramic insulating materials. Rust and/or corrosion on any of the metal surfaces, cast iron components, baffl...
-
Page 28: Contact Information
C. Contact Information Please contact your Heat & Glo dealer with any questions or concerns. ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ • Important operating a n d m a i n t e n a n c e instructions included.
Need help?
Do you have a question about the CFL-18LP-C and is the answer not in the manual?
Questions and answers