Nexgrill 720-0718N Assembly & Operating Instructions
Nexgrill 720-0718N Assembly & Operating Instructions

Nexgrill 720-0718N Assembly & Operating Instructions

Charcoal - gas combo grill

Advertisement

ASSEMBLY & OPERATING INSTRUCTIONS
Charcoal - Gas Combo Grill
300
400
500
200
600
100
700
800
Version No.19000293A1
!
WARNING:
Read this Owner's manual carefully and be
sure your gas grill is properly assembled,
installed and maintained. Failure to follow these
instructions could result in serious injury and/or
property damage. This gas grill is intended for
outdoor use only and is not intended to be
installed in or on recreational vehicles or boats.
Note to Installer
Leave this Owner's Manual with the customer
after delivery and/or installation.
300
400
500
600
200
100
700
800
Nexgrill Industries, INC.
5270 Edison Ave. Chino, CA 91710
Note to Consumer
Leave this Owner's Manual in a convenient
place for future reference.
Customer Service Helpline:
For parts ordering, call:
1-800-913-8999
MFG No.: 720-0718N
Please make sure the cylinder valve
connection device shall properly and safely
mate with the connection device attached to
the inlet of the pressure regulator.
• Parts
• Assembly
• Safety Rules
• Use and Care
• Troubleshooting

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 720-0718N and is the answer not in the manual?

Questions and answers

Summary of Contents for Nexgrill 720-0718N

  • Page 1 For parts ordering, call: outdoor use only and is not intended to be 1-800-913-8999 installed in or on recreational vehicles or boats. MFG No.: 720-0718N Note to Installer Leave this Owner’s Manual with the customer Please make sure the cylinder valve after delivery and/or installation.
  • Page 2: Table Of Contents

    Nexgrill Grill Warranty Do not store or use gasoline or other flammable liquids or One-Year Full Warranty on Nexgrill Grill If this grill fails due to a defecting material or vapors in the vicinity of this or workmanship within one year from the date of any other appliance.
  • Page 3 Precautions • Have your LP gas tank filled by a reputable A tank of approximately 12 inches in diameter by 18- propane gas dealer and visually inspected and re- 1/2 inches high is the maximum size LP gas tank to qualified at each filling.
  • Page 4 Burner Flame Check WARNING A strong gas smell, or the hissing sound of gas indicates a serious problem with your gas grill or the LP gas tank. Failure to immediately follow the steps listed below could result in a fire or explosion that could cause serious bodily injury, death, or property damage.
  • Page 5: Packaging Content List

    PACKAGE CONTENTS LIST A. Firebox --------1pc. B. Cart Leg, Front Left------1pc. C. Cart Leg, Back Left----1pc. D. Cart Brace, Left------1pc. E. Cart Leg, Front Right-----1pc. F. Cart Leg, Back Right----1pc. G. Cart Brace, Right ------1pc. H. Swivel Caster with Brake---1pc I.
  • Page 6 S. Charcoal Bin Right Side Panel-- T. Charcoal Bin back panel--1pc. U. Charcoal Bin Front panel-1pc. V. Charcoal Bin Handle---1pc. W. Front Trim Panel--------1pc. X. Cart Beam, Front-----1pc. Y. Charcoal Bin Slide---2pcs. Z. Cart Beam, Back-----1pc. ZA. Gas Tank Barrier Bar --1pc. ZB.
  • Page 7: Hardware Pack

    Hardware Pack Contents Pack Description Required for assembly (pcs) 5/32-in. x 10-mm Round Head Screw 5/32-in. Lock Washer 1/4-in. x 15-mm Round Head Screw 1/4-in. Lock Washer Allen Key 1/4-in. Nut 1/4-in. Flat Washer 1/4-in. x 61-mm Round Head Screw 1/4-in.
  • Page 8 Assembly Instructions Fig. 1 Screws and washers UNPACKING shown here are 5. With the aid of an assistant, lift the Firebox from the behind of D bottom of the shipping box and place on protected flat surface. Be careful not to damage hose and regulator. 6.
  • Page 9 Fig. 5 3. Bottom Panel Assembly a) Use 4 HH Round Head Screws, 4 DD Lock Washers and 4 II Flat Washers to attach and securely tighten Bottom Panel (J) to Left Cart Legs (E & F). See Fig. 5. b) Repeat step 3a to attach and securely tighten Bottom Panel (J) to Right Cart Legs (B &...
  • Page 10 Fig. 10 6. Charcoal Bin Assembly Back view a). Attach Charcoal Bin Left (R) and Right (S) Side panels to Charcoal Bin Back Panel (T) by securely hooking Back panel tabs into Side panel slots. See Fig. 9. b). Place Charcoal Bin Back Panel (T) on a flat level surface.
  • Page 11 Fig. 13 7. Front Trim Panel Assembly a). Place Front Trim Panel (W) against right side of Charcoal Bin Front Panel. Fit Trim Panel hinge pin into hole onto bottom of Bin Front Panel. Tab at top of Trim Panel goes against back surface of Bin Front Panel.
  • Page 12 Fig. 16 10. Cart Beam, Back Assembly Use 4 AA Round Head Screws and 4 BB Lock Washers to attach Cart Beam, Back (Z) to Left Back Cart Leg (C) and Right Back Cart Leg (F). See Fig. 16. NOTE: Flat side of Cart Beam, Back (Z) must face cart exterior.
  • Page 13 Fig. 19 12. Charcoal Bin Cover Assembly Use 4 JJ Flat Head Screws to connect hinges of Charcoal Bin Cover (ZC) to Cart Beam, Front (X). See Fig. 19. 13. Firebox Assembly NOTE: Obtain the aid of an assistant to lift the Firebox. Be sure that the hose and regulator hang inside the cart when placing Firebox.
  • Page 14 15. Electronic Ignition Battery Installation Unscrew the electronic ignition button and place the Battery (ZE) into the housing with the positive terminal Fig. 23 (+) facing outward. Replace the ignition button after the battery has been installed as shown in Fig. 23. 16.
  • Page 15 CAUTION: When the appliance is not in use, gas Congratulations must be turned off at the supply tank. Your Nexgrill gas grill is now ready for use. Before the first use and at the beginning of each season (and whenever the LP gas tank has been changed): 1.
  • Page 16: Lighting Instructions

    Checking for LP gas leaks Be sure all gas connections are securely tightened. Never test for leaks with a flame. Prior to first use, at Open the Gas Grill Lid. the beginning of each season, or every time your LP Push and turn any main burner knob to gas tank is changed, you must check for gas leaks.
  • Page 17 If Grill Still Fails To Light WARNING 1. Check gas supply and connections for leaks. Check Never lean over the grill cooking area while that all wire connections are secure. lighting your gas grill. Keep your face and body a safe distance (at least 18 inches) from the 2.
  • Page 18: Cleaning And Maintenance

    Cleaning and Maintenance Cleaning Exterior Stainless Steel Surfaces To ensure a proper working unit the following proper care and maintenance is suggested. Weathering and extreme heat can cause exterior stainless steel surfaces to turn tan in color. Machine Cleaning Cooking Grids oils used in manufacturing process of stainless steel We suggest you wash your cooking grids in a mild soap can also cause this tanning color.
  • Page 19: Troubleshooting

    3. Inspect each burner for damage (cracks or holes) Regardless of which burner cleaning procedure you and if such damage is found, order and install a new use, we recommend you also complete the following burner. After installation check to ensure that gas steps to help prolong burner life.
  • Page 20: Charcoal Grill Information

    • Dispose of cold ashes by wrapping them in a Charcoal Grill Information heavy-duty aluminum foil and placing in a noncombustible container. Make sure that there WARNING are no other combustible materials in or near • Do not burn more than 5lbs of charcoal in this unit the container.
  • Page 21: Charcoal Grill Lighting Instructions

    Cooking Temperatures Charcoal Lighting Instructions High setting: Only use this setting for fast 1. Open grill lid, as well as damper vents on side of grill. warm-up,searing steaks or chops and for burning 2. Raise the hinged section of Charcoal Grid to add food residue off the grill after cooking is complete.
  • Page 22: Cooking Chart

    Cooking Chart FOOD Weight or thickness Temperature Time Special instructions and tips Slice or chop vegetables and dot with butter or Vegetables Medium 8 to 20 minutes margarine. Wrap tightly in heavy duty foil. Grill turning occassionally. Wrap individually in heavy duty foil. Cook Potatoes Whole Medium...
  • Page 23: Parts Diagram

    Model 720-0718N Parts diagram 40 0 30 0 50 0 60 0 10 0 30 0 40 0 5 00 20 0 6 00 10 0 7 00 80 0...
  • Page 24: Parts List

    4. Part Description To make sure you obtain the correct replacement 5. Quantity of parts needed parts for your Nexgrill gas grill, please refer to the part numbers on this page. Important: Keep this Use & Care Guide for convenient...

This manual is also suitable for:

Gas combo grill

Table of Contents