Table of Contents
Advertisement
Quick Links
OWNERS MANUAL
IMPORTANT: RETAIN THIS MANUAL IN A SAFE PLACE
Do not store or use gasoline or other flammable vapors or liquids in
WARNING: Improper installation, adjustment, alteration, maintenance
can cause property damage, injury, or death. Read the installation,
operating and maintenance instructions thoroughly before installing
Broiler area must be kept free of combustible materials, and the flow of combustion and ventilation air
must not be obstructed. Operating personnel must not perform any maintenance or repair functions.
Contact your Nieco Authorized Dealer.
In a prominent location, post instructions to be followed in the event the user smells gas. This informa-
tion shall be obtained by consulting your local gas supplier.
AUTOMATIC
FOOD SERVICE
EQUIPMENT
AUTOMATIC GAS BROILER
MODEL N2500
FOR FUTURE REFERENCE.
FOR YOUR SAFETY:
the vicinity of this or any other appliance.
or servicing this equipment.
Advertisement
Table of Contents
Related Manuals for Nieco N2500
Summary of Contents for Nieco N2500
- Page 1 Broiler area must be kept free of combustible materials, and the flow of combustion and ventilation air must not be obstructed. Operating personnel must not perform any maintenance or repair functions. Contact your Nieco Authorized Dealer. In a prominent location, post instructions to be followed in the event the user smells gas. This informa-...
-
Page 2: Table Of Contents
G. Specifications ..........31 Nieco Corporation - Model N2500... -
Page 3: General Information
The N2500 is flow-through, with a toaster section for toasting and cheesemelting capabilities. This manual provides the safety, installation and operating procedures for the Nieco Automatic Broiler Model N2500. -
Page 4: Service/Technical Assistance
For the name of your local Authorized Nieco Distributor, please call (800) 821-2141. Use only genuine Nieco replacement parts in your broiler. Use of replacement parts other than those sup- plied by Authorized Nieco Distributors and Service Agencies will void the warranty and may significantly alter the performance of your broiler. - Page 5 Distributor for adjustment or repair. • Use only genuine Nieco replacement parts for your broiler. Failure to do so will void the warranty and may significantly alter the performance of your broiler. The following warnings and cautions appear throughout the manual and should be carefully observed: •...
-
Page 6: Machine Installation
SEVERE FIRE HAZARD. Follow local fire and building codes for non-combustible construc- tion. Failure to do so could result in a fire hazard. If unsure of your construction, follow mini- mum clearances for combustible construction. Nieco Corporation - Model N2500... -
Page 7: Flexible Gas Line Installation
"lazy" loop for minimum tension. Note: Gas appliances should be disconnected prior to maximum movement. (Minimal movement is possible to connect hose.) N2500 Equipment Side Gas Connection N2500 Manual Gas Valve Nieco Corporation - Model N2500... -
Page 8: Restraining Device
Note: Disconnect power before servicing. B.9 Pre-Operation Check Be sure that all parts are installed in the proper location: Ventilation is turned on Broiler is plugged in Gas line is connected Nieco Corporation - Model N2500... -
Page 9: Troubleshooting Guide
Check that all parts are installed correctly, and that lower burner holes are facing up Check that broiler is properly cleaned and assembled Check ventilation __ Make sure there isn’t excessive exhaust or an air vent blowing on the broiler Nieco Corporation - Model N2500... - Page 10 Check condition and placement of grease extractors; clean daily and position properly Grease on floor from Check that grease bucket is installed discharge end Nieco Corporation - Model N2500...
-
Page 11: Operation
This light indicates your broiler has gone below 100°F of the set point and may no Gas Pressure longer be properly cooking the Gauge product. (On side of broiler) Nieco Corporation - Model N2500... -
Page 12: Step-By-Step Lighting Procedure
Your Nieco Automatic Broiler is designed to automatically stop gas flow to the broiler in the event of power failure, gas pressure loss or any other related incident. No attempt to operate this appliance should be made in the event of a power failure. -
Page 13: Control Operation
Turn the LOWER BELT SPEED CONTROL knob to set the RIGHT BELT SPEED to the desired setting. AUTOMATIC CALIBRATION The N2500 can be calibrated automatically. Use the following steps to automatically calibrate your broiler: 1. Broiler must be OFF. 2. Push and hold the TEMPERATURE CONTROL KNOB in. -
Page 14: Cleaning And Disassembly
Make sure grease pans are cool before putting in water or it may warp the pans. Take to sink area and spray with degreaser. Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Cleaning Aid Nieco Corporation - Model N2500... - Page 15 Clean: 3:00 p.m.; 7:00 p.m.; 11:00 p.m.; 2:00 a.m. Feed End Tools No-Scratch Pad 3-Compartment Sink Instructions Pull each meat guide out slightly from the bottom, then lift off. Wash, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 16 Wash, rinse, and sanitize in the 3-compartment sink. DO NOT lift the feeder base by the feeder bar or the chains. This will damage the feeder base. REASSEMBLY: Pull the release pin and place feeder base in position. Nieco Corporation - Model N2500...
- Page 17 Make sure grease pan is cool before putting in water or it may warp the pans. Take to sink area and spray with degreaser. Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 18 Wring out a sanitized towel and wipe feed end crumb tray. Awning Clean: Daily Discharge End Tools No-Scratch Pad 3-Compartment Sink Heat Resistant Gloves Instructions Tilt and lift pins off hooks; pull out. Wash, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 19 Tools Scrub Pad Degreaser 3-Compartment Sink Instructions Lift patty catch pan insert up and off. Take to sink area and spray with degreaser. Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 20 Tools Scrub Pad Degreaser 3-Compartment Sink Instructions Slide patty catch pan insert out and off. Take to sink area and spray with degreaser. Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 21 Discharge End Tools Soapy Towel Sanitized Towel Instructions Slide discharge end crumb tray out. Wring out a soapy towel and wash discharge end crumb tray. Wring out a sanitized towel and wipe discharge end crumb tray. Nieco Corporation - Model N2500...
- Page 22 If used with a garbage bag liner, remove liner and throw in trash. If no liner, dump bucket into trash can. Take to sink area and spray with degreaser. Wash with a scrub pad, rinse and sanitize in the 3- compartment sink. Nieco Corporation - Model N2500...
- Page 23 Side Crumb Tray Clean:Daily Side Tools Soapy Towel Sanitized Towel Instructions Slide side crumb tray out. Wring out a soapy towel and wash side crumb tray. Wring out a sanitized towel and wipe side crumb tray. Nieco Corporation - Model N2500...
- Page 24 If necessary, use the small orifice brush to clean any clogged burner holes. Repeat steps for all burners. DO NOT use water or get the burners wet. REASSEMBLY: Be sure the holes on the burner are facing up. No water Nieco Corporation - Model N2500...
- Page 25 Element Covers Clean: Monthly Side Tools Scrub Pad Heat Resistant Gloves 3-Compartment Sink Instructions Open element cover access doors. Lift and remove element covers. Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 26 Shrouds Clean: Monthly Tools No-Scratch Pad Heat Resistant Gloves Degreaser 3-Compartment Sink Instructions Lift shrouds from top of broiler. Take to sink area and spray with degreaser. Wash, rinse, and sanitize in the 3-compartment sink. Nieco Corporation - Model N2500...
- Page 27 Upper Burners Clean: Monthly Tools Heat Resistant Gloves Soft Bristle Brush Instructions Lift each burner up and out of broiler. Use a soft bristle brush to brush burner. DO NOT use water on burners. No water Nieco Corporation - Model N2500...
- Page 28 Wash with a scrub pad, rinse, and sanitize in the 3-compartment sink. Flame Sensor Clean: Monthly Inside Tools Towel Flame Sensor Instructions Wipe the flame sensor with a dry towel. Do NOT use water on the flame sensor. No spray No water Nieco Corporation - Model N2500...
- Page 29 Tools Large Orifice Brush Lizard Safety Utility Knife Instructions Clean the slots on the pilot burners with a lizard knife. Be careful not to cut yourself! Clean the pilot orifices using the large orifice brush. Nieco Corporation - Model N2500...
-
Page 30: Broil Chain Tension & Link Removal
Unhook the master link. CAUTION To ensure proper broiler operation be sure to reassemble the chain with the knuckle opening facing away from the direction of travel. Nieco Corporation - Model N2500... -
Page 31: Specifications
65.04 1652 Width 43.34 1100 * The N2500 comes with a stand included. E N E R G Y - G A S M O D E L S Gas connection1” N.P.T. Electrical connection (specify exact voltage) Domestic 115V IØ 50/60Hz 5A Natural Gas 3”... - Page 32 Nieco Corporation • 7950 Cameron Drive • Windsor, CA 95492 • (707) 284-7100 Office • (707) 284-7430 Fax 3/04 www.nieco.com • e-mail:service@nieco.com Printed in the USA © 2004 Nieco Corporation All Rights Reserved Reorder P/N 9999-99186...
Need help?
Do you have a question about the N2500 and is the answer not in the manual?
Questions and answers