Quadra-Fire SAPPHIRE-MBK Owner's Manual page 2

Sapphire series gas stove direct vent room heater

Hide thumbs Also See for Quadra-Fire SAPPHIRE-MBK:

Owner's manual (52 pages)

Table Of Contents

Table of Contents

Hearth & Home Technologies welcomes you to our tradition

of excellence! In choosing a Quadra-Fire appliance, you

have our assurance of commitment to quality, durability, and

performance.

This commitment begins with our research of the market,

including 'Voice of the Customer' contacts, ensuring we

make products that will satisfy your needs. Our Research

and Development facility then employs the world's most

advanced technology to achieve the optimum operation of

LOCATION: HANGING ON A CHAIN UNDER APPLIANCE

Report No. / Rapport Numéro

3198461

APPROVED FOR CANADA AND USA TO: ANSI Z21.88b-2009 / CSA 2.33b-2009 Vented Gas Fireplace Heaters, and applicable sections

of UL307b Gas Burning Heating Appliances for Manufactured Homes and Recreational Vehicles, CAN/CGA 2.17-M91 "Gas Fired Appliances

for use at High Altitudes." This appliance is manufactured for operation with Natural Gas. For conversion to propane Manufacturer's instructions

must be used. This appliance may be installed in a bedroom or bedsitting room; in Canada remote thermostat installation is required.

FAN TYPE VENTED CIRCULATOR :Optional Blower Kit #GFK-160A. 120 Vac, 60 Hz., 12 Amperes or less.

Route power cord away from unit. Do not route power cord under or over stove.

Thermal Efficiency with blower on* 80.92% NG / 82.44% LP (* With Maximum horizontal length)

CAN/CSA P.4.1-02 Canada Minimum pipe Top Vent: 58.90% NG / 60.09% LP. Rear Vent: 65.04% NG / 66.49% LP

Top Vent:

Input Rate on "HI" (BTU/Hr)

Input Rate on "LO" (BTU/Hr)

Maximum Output (BTU/Hr)**

Main Burner Orifice

Rear Vent:

Input Rate on "HI" (BTU/Hr)

Input Rate on "LO" (BTU/Hr)

Main Burner Orifice

Both:

Minimum Inlet Pressure (Inches W.C.)

Maximum Inlet Pressure (Inches W.C.)

Manifold Pressure on "HI" (Inches W.C.)

AFUE

**Max Venting, Blower On

This appliance equipped for altitudes 0-2000' (0-610m) in USA; and in Canada for altitudes of 0-4500' (0-1370m). In USA for Altitudes above 2000', the vent configuration, orifice or combination of both may need to be

changed. See Owner's Manual for information on making these changes. This appliance must be installed in accordance with local codes, if any (and Commonwealth of Massachusetts approved); if none, follow ANSI

Z223.1/NFPA 54 in USA, or CSA B149.1 in Canada. Install and use only in accordance with manufacturer's installation and operating instructions. NOTE: Have the gas supply line installed in accordance with local building

codes by a qualified installer approved and/or licensed as required by the locality. (In the Commonwealth of Massachusetts, installation must be performed by a licensed plumber or gas fitter.) / Cet appareil est équipé pour les altitudes

conformément aux instructions du fabricant.

WARNING: Operation of this appliance when not connected to a properly installed and maintained venting system can result in carbon monoxide (CO) poisoning and possible death. AVERTISSEMENT:

L'opération de cet appareil lorsqu'il n'est pas connecté à un système de ventilation correctement installé et maintenu peut résulter à un empoisonnement d'oxyde de carbone ou même de mort possible.

This appliance is only for use with the type of gas indicated on the rating plate and may be installed in an aftermarket, permanently located, manufactured (mobile) home where not prohibited by local codes.

See owner's manual for details. This appliance is not convertible for use with other gases, unless a certiﬁed kit is used. / Cet appareil doit être utilisé seulement avec le gaz indiqué sur l'étiquette enregistré et

peut être installé dans une maison mobile en place permanente dans les endroits permis par les codes locaux. Voyez le manuel du propriétaire pour des détails supplémentaires. Cet appareil ne doit pas être

converti avec des autres gaz sans l'utilisation d'un ensemble de conversion certiﬁé.

MINIMUM CLEARANCES TO COMBUSTIBLES /ESPACE MINIMUM AUX COMBUSTIBLES

Minimum clearances required from combustible construction for all appliance surfaces.

Espaces minimum exigés de la construction combustible aux surfaces de l'appareil.

A. Side of stove top to side wall

B. Back of stove to back wall (air shield)

C. Corner of stove top to side wall

D. Minimum Alcove Height

E. Maximum Alcove Depth

F. Minimum Alcove Width

A, B & C measurements are from stove top, not side / "A, B & C" mesure est du sommet de poêle, pas le côté

HEARTH: A non-combustible hearth pad is not required. However, the ﬂoor beneath the appliance must be stable, level, and strong enough to support the

appliance without a tipping hazard. / CHEMINÉE: Un coussinet non-combustible de cheminée n'est pas exigé. Cependant, le plancher en dessous du

poêle doit être droit, à niveau et assez fort pour supporter le poêle sans le hasard de basculer.

Right and left sides of appliance are determined when facing the front of appliance. / Les côté gauches et droits de l'appareil sont déterninés

lorsque vous êtes en face de l'appareil.

2010

2011

2012

Made in U.S.A. of US and imported parts. / Fabriqué aux États-Unis-d'Amérique par des pièces d'origine américaine et pièces importées.

and Welcome to the Quadra-Fire Family

SAMPLE OF SERIAL NUMBER / SAFETY LABEL

MODEL / MODÈLE:

SAPPHIRE-D GAS STOVE

VENTED GAS FIREPLACE HEATER

NOT FOR USE WITH SOLID FUEL

FOURNAISE AU GAZ AVEC VENTILATION

NE PAS UTILISER AVEC LE COMBUSTIBLE SOLIDE

For use with Natural Gas

For use with Propane

Usage Au Gaz Naturel

Usage Au Gaz Propane

0-2000 FT

0-2000FT

30,000

28,500

21,000

19,700

24,276

23,495

.106 (#36 DMS)

.063 (#52 DMS)

26,000

18,000

19,000

.098 (#40DMS)

.059 (#53DMS)

10"

11"

13"

3.5"

10"

79.15%

80.62%

ELECTRICAL SUPPLY / FOURNITURE ÉLECTRIQUE: 120 Volts, 60 Hz

6 in. (152mm)

3 in. (76mm)

54 in. (1372mm)

36 in. (914mm)

34 in. (864mm)

Date of Manufacture / Date du Manufacturier

Jan

Feb

Mar

Apr

May

Quadra-Fire • Sapphire • 7055-116 Rev. G • 10/12

our stoves, inserts and ﬁ replaces. And yet we are old-fash-

ioned when it comes to craftsmanship. Each appliance is

meticulously fabricated and surfaces are hand-ﬁ nished for

lasting beauty and enjoyment. Our pledge to quality is com-

pleted as each model undergoes a quality control inspec-

tion.

We wish you and your family many years of enjoyment in

the warmth and comfort of your hearth appliance. Thank

you for choosing Quadra-Fire.

Serial No / Numéro du

007020

APPROUVÉ POUR LE CANADA ET LES ÉTATS-UNIS: ANSI Z21.88b-2009 / CSA 2.33b-2009 Fournaises au Gaz avec Ventilation, et les sections

applicable de UL 307b Appareils de Chauffage Au Gaz pour les Maisons Mobiles et les Véhicules Motorisés, CAN/CGA 2.17-M91 "Gas Fired Appliances

for use at High Altitudes". Cet appareil est manufacturé pour l'opération avec le Gaz Naturel. Pour une conversion au gaz propane Manufacturier

instructions doivent être utilisées. Cet appareil peut être utilisé dans une chambre à coucher ou salle de séjour; au Canada, l'installation d'un thermostat

à distance est exigée.

VENTILATEUR CIRCULATOIRE: Le Souiﬂeur Optionel Kit #GFK-160A. 120 Vac, 60 Hz., 12 Amperes ou moins.

Éloignez le ﬁl électrique de l'appareil. Ne pas faire passer le ﬁl électrique au dessous de l'appareil.

Efficacité thermique* avec ventilateur allumé 80.92% NG / 82.44% LP (* avec longueur horizontale maximum)

CAN/CSA P.4.1-02 Le canada tuyau minimum Top Vent: 58.90% NG / 60.09% LP, Rear Vent: 65.04% NG / 66.49% LP

Puissance Évaluée à "HI" (BTU/Hr) - Évent Supérieur

Puissance Évaluée à "LO" (BTU/Hr)

Puissance Maximum (BTU/Hr**

Orifice du Brûleur Principal

Puissance Évaluée à "HI" (BTU/Hr) -- Évents Arrière

Puissance Évaluée à "LO" (BTU/Hr)

Orifice du Brûleur Principal