Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Drive Medical SPGT-3C-BL SPGT-3C-R, SPGT-3C-G
Summary of Contents for Drive Medical SPGT-3C-BL SPGT-3C-R, SPGT-3C-G
- Page 1 SUNFIRE PLUS GT SPGT-3C-BL, SPGT-3C-R, SPGT-3C-G OWNER’S MANUAL...
-
Page 2: Table Of Contents
TA BLE OF CONTENTS PREFACE AND INTRODUCTION ……..………………………………… SAFETY NOTICE………..……………………....……… ………. Before driving While driving Labeling EMI……………………………………………..……………………………….. PARTS INTRODUCTION……………………………………………..………. OPERATION…………………………………………………………………..Control panel How to operate your power chair How to set to freewheel mode BATTERY CHARGING AND CARE………………………………………..Charging the battery Battery Replacing the batteries / charger INSPECTION AND MAINTENANCE……………………………………..…. -
Page 3: Preface And Introduction
P R E F A C E A N D I N T R O D U C T I O N Please carefully read this owner’s manual before using the power chair. Improper use of the power chair could result in, injury. This owner’s manual includes operating instructions for every aspect of the power chair, including assembly instructions and how to deal with possible accidents. -
Page 4: Safety Notice
S A F E T Y N O T I C E 2.1 BEFORE DRIVING The user should become familiar with the usage and operation of this power chair before driving. Therefore, please always keep the following safety notices in mind. For your safety, please follow these rules. - Page 5 S A F E T Y N O T I C E Do not use your power chair under any of the conditions below. On roads with heavy traffic or roads that are unpaved, snow-covered, or icy. Do not drive at night. Do not drive in rain or show. Do not drive your power chair in an “S”...
- Page 6 S A F E T Y N O T I C E 8. Engage the 4.5mph switch if you are driving on the pavement. Warning ! Do not set in the freewheel mode when driving on a gradient. Always re-engage the anti-freewheel device before use. Fail to do so may result in injury. To protect your safety, the power will automatically cut off and electromagnetic brake system will activate while driving down a steep gradient.
- Page 7 S A F E T Y N O T I C E Attention: 1.When climbing an incline, do not zigzag or drive at an angle up the face of the of the incline. 2. Always drive your power chair straight up the incline. This greatly reduces the possibility of a tip or a fall.
-
Page 8: Labeling
Labeling Carefully read all the labeling on the power chair before driving it. Do not remove these labels. NEVER LIFT POWER CHAIR BY THE FRONT OR REAR SHROUD WARNING: Radio waves may affect power chair control. Radio wave sources, such as radio stations, amateur radio (HAM) transmitters, two-way radios and cellular phones can affect powered motorized power chair. - Page 9 S A F E T Y N O T I C E This section provides the user with basic information that describes the problems with electromagnetic interference (EMI), known sources of EMI, protective measure to either lessen the possibility or exposure or to minimize the degree of exposure, and suggested action should unexpected or erratic movement occur.
-
Page 10: Emi
E M I Attention: Other types of hand-held devices, such as cordless phones, laptop computers, AM/FM radios, TV sets, CD players, cassette and small appliances such as electric shavers and hair dryers are not likely to cause EMI problems to your powered power chair . POWERED POWER CHAIR ELECTROMAGNETIC INTERFERENCE (EMI) Because EM energy rapidly becomes more intense as one moves closer to the transmitting antenna (source), the EM fields from hand-held radio wave sources (transceivers) are of special concern. -
Page 11: Parts Introduction
PA R T S I N T R O D U C T I O N PARTS DESCRIPTION Controller Armrest Headrest Seatback Seat Drive Wheel Caster Wheel Footrest 9 Knob To Adjust The Armrest... -
Page 12: Operation
O P E R AT I O N JOYSTICK AND CONTROLLER Your Sunfire Plus GT is operated by a joystick and controller. The Sunfire Plus GT is currently available with one of two controller options: PG VR 2. VR2 Series CONTROL FUNCTIONS 1.ON/OFF Button 2. - Page 13 O P E R AT I O N Attention: We recommend that the first few times you operate your Sunfire Plus GT Plus you should turn the speed and respond adjustment knob to the slowest setting until you become familiar with you new power chair.
- Page 14 O P E R AT I O N JOYSTICK DEPTH ADJUSTMENT Your power chair is equipped with an adjustable joystick. This function enables you to move the joystick from the armrest to the desired position. Suggestion 1. You should recharge the batteries after each time the power chair is used to ensure maximum range.
- Page 15 O P E R AT I O N HOW TO ADJUST THE SEAT To adjust the seatback angle Pull up the seatback release lever. Move the seatback down or up to the desired position . Release the seatback release lever. To adjust the armrest width Seatback Release Lever Loosen the knobs...
- Page 16 O P E R AT I O N To adjust the height of armrests Loosen knob. Pull bolt on handle. Move armrest to required position. Armrest knob To adjust headrest To raise headrest, lift it to desired position. To lower headrest, push releaser and lower headrest to desired position. Releaser To remove the seat Turn the power OFF.
-
Page 17: How To Set To Freewheel Mode
O P E R AT I O N To change the seat height Remove seat (See “To remove the Seat”) Remove the shroud. Disengage and remove the seat height adjustment pin from the seat post. Remove the height adjustment pin from each of the three posts. Raise or lower each post to the desired position. - Page 18 O P E R AT I O N To disengage the drive and place power chair in freewheel “ ” left and right) Warning Do not use your Sunfire Plus GT Power Chair while the drive motors are disengaged unless you are in the presence of an attendant! Do not disengage the drive motors when on an incline as the power chair may roll down causing injury! Suggestion...
- Page 19 O P E R AT I O N HOW TO ADJUST THE SEAT Above: Seat shown in the four possible “ENGAED” positions Below: Seat shown in the four possible “REMOVABLE” positions...
-
Page 20: Battery Charging And Care
6 . B AT T E R Y C H A R G I N G A N D C A R E BATTERIES The Sunfire Plus GT Power Chair uses two long- lasting, 12 volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. - Page 21 6 . B AT T E R Y C H A R G I N G A N D C A R E To charge the batteries using the on-board charger Position the power chair next to a standard wall outlet Be certain the controller power is turned off .
- Page 22 6 . B AT T E R Y C H A R G I N G A N D C A R E Suggestion – How to maximize your battery’s efficiency and service life 1. Fully charge any new battery before its initial use. 2.
-
Page 23: Inspection And Maintenance
7 . I N S P E C T I O N A N D M A I N T E N A N C E INSPECTION Initial adjustments should be made to suit personal body structure and preference. Be sure to, follow these checks and maintenance procedures. -
Page 24: Regular Checking Record
7 . I N S P E C T I O N A N D M A I N T E N A N C E REGULAR CHECKING RECORD To make sure your power chair is correctly serviced, take it to your dealer for regular maintenance checks. - Page 25 7 . I N S P E C T I O N A N D M A I N T E N A N C E Attention When tread depth is below 0.5mm it can easily lead to power chair slippage, making braking distances longer.
-
Page 26: Trouble Shooting And Specification
8 . T R O U B L E S H O O T I N G A N D S P E C I F I C AT I O N TROUBLE SHOOTING Symptom Probable cause Solution Limited driving distance Batteries not fully charged. Charge batteries overnight or ensure 10 hours of charge between uses. - Page 27 Poor battery terminal connection. Clean terminals. Wheelchair does not respond to commands. Power indicator off Electrical malfunction. Contact dealer even after recharging. 8 . T R O U B L E S H O O T I N G A N D S P E C I F I C AT I O N SPECIFICTIONS MODEL Sunfire Plus GT...
- Page 28 8 . T R O U B L E S H O O T I N G A N D S P E C I F I C AT I O N Self-Help Guide If a system trip occurs, you can find out what has happened by counting the Number of bars on the battery gauge that are flashing.
-
Page 29: Warranty
9 . W A R R A N T Y Your Drive brand product is warranted to be free of defects in materials and workmanship as follows: Chair/Scooter frame: Lifetime Electronic Controller and drive train components: 1 year Batteries: 6 months from time of installation This device was built to exacting standards and carefully inspected prior to shipment. - Page 30 Wa r r anty Re gistr ation Please type or print. Serial # _______________________________________ Date Purchased ____/____/____ Owner Name ____________________________________________________________ Address _________________________________________________________________ City ____________________________________ State ________ ________ Additional Required Owner Information Please indicate your understanding of your scooter by completing the following information. ________ I have read and fully understand _______...
- Page 31 9 . W A R R A N T Y VIN (POWERCHAIR INDIFICATION NUMBER) To ensure the correct after sales, service and warranty service support, please write down the power chair identification number found on the rear right-hand side of the frame. Model Sunfire Plus GT Identification Number...
- Page 32 99 Seaview Boulevard Port Washington, NY 11050 516-998-4600 877-224-0946 www.drivemedical.com...