HearthStone STERLING “G” B-VENT 8521 Owner's Manual
HearthStone STERLING “G” B-VENT 8521 Owner's Manual

HearthStone STERLING “G” B-VENT 8521 Owner's Manual

Gas fired b-vent room heater
Hide thumbs Also See for STERLING “G” B-VENT 8521:

Advertisement

WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property
damage, personal injury or loss of life.
v Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
v WHAT TO DO IF YOU SMELL
GAS:
Do not try to light any appliance.
Do not touch electrical switches; do not use
the phone in your building.
Immediately call your gas supplier from a
neighbors phone. Follow your gas suppliers
instructions.
If you cannot reach your gas supplier, call
the fire department.
v Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.
317 Stafford Avenue
Morrisville, Vermont 05661
E-Mail:
inquiry@hearthstonestoves.com.
STERLING "G" B-VENT
Gas Fired B-Vent Room Heater
Owner's Manual
AVERTISSEMENT: Assurez-vous de bien suivre
les instructions donné dans cette notice pour
réduire au minimum le risque d'incendie ou pour
éviter tout dommage matéeriel, toute blessure ou
la mort.
v Ne pas entresposer ni utiliser d'essence
ni'autrevaperurs ou liquides inflammables
dans le voisinage de cet apprareil ou de
tout autre appareil.
v QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareil.
Ne touchez à aucun interrupteur. Ne pas vous
servir des téléphones se trouvant dans le
batiment où vous vous trouvez.
Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
Si vous ne pouvez rejoindre le fournisseur
de gaz, appelez le service dos incendies.
v
L'installation et service doit être exécuté par un
qualifié installer, agence de service ou le
fournisseur de gaz.
6400-40427
05-22-03
(8521)

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the STERLING “G” B-VENT 8521 and is the answer not in the manual?

Questions and answers

Summary of Contents for HearthStone STERLING “G” B-VENT 8521

  • Page 1 STERLING “G” B-VENT (8521) Gas Fired B-Vent Room Heater Owner’s Manual AVERTISSEMENT: Assurez-vous de bien suivre WARNING: If the information in these les instructions donné dans cette notice pour instructions is not followed exactly, a fire or réduire au minimum le risque d’incendie ou pour explosion may result causing property éviter tout dommage matéeriel, toute blessure ou damage, personal injury or loss of life.
  • Page 2: Table Of Contents

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent TABLE OF CONTENTS TABLE OF CONTENTS ........................... 1 Introduction ..............................2 Owner Information Record..........................3 Warnings - Cautions - Safety Information ..................... 4 Unpacking And Inspection..........................5 Installation And Connections ..........................6 Hearth Requirements ............................
  • Page 3: Introduction

    Sterling a pleasing look which can be maintained with minimum care. To own a HearthStone is to make a statement - a statement of your appreciation and understanding of exceptional quality. Your Sterling is manufactured using imported cast iron and stone which combine to enhance the decor of any home.
  • Page 4: Owner Information Record

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Owner Information Record Record here all relevant information concerning the purchase and installation of your Sterling gas-fired heater. This information will facilitate servicing, purchase of replacement parts and warranty claims, if necessary.
  • Page 5: Warnings - Cautions - Safety Information

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Warnings - Cautions - Safety Information surface temperatures and warned that they should stay away to avoid burns to skin or clothing ignition. This gas appliance must be installed and Children should be carefully supervised when in the Failure maintained by qualified service personnel.
  • Page 6: Unpacking And Inspection

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent supplied decorative ceramic fiber logs with unapproved ceramic logs, real wood logs or any other ARNING material. Do not operate this appliance with the glass removed, cracked or broken. Do not substitute materials.
  • Page 7: Installation And Connections

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Prior to removing the shipping carton, inspect the carton for visible signs of damage. Carefully remove the shipping carton. Carefully remove and set aside the three top stones. Inspect the Sterling for visible or concealed damage. The unit should appear square and true. The sheet metal parts should be smooth and free of bends or dents.
  • Page 8: Clearances To Combustibles

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Clearances To Combustibles Due to high surface and radiant Sterling BV Minimum Clearance to Combustibles temperatures, the Sterling should be located out of traffic and away from A=6" (152mm) Single Wall Stove Pipe B=2"...
  • Page 9: Electrical Connections

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Electrical Connections Thermostat The Sterling may use a wall-mounted thermostat for operation. The thermostat controls the unit by "calling for heat" and turning the unit on when the room is cold, and turning the unit off once the room has warmed sufficiently to satisfy the thermostat.
  • Page 10: Draft Hood/Down Draft Sensor/Spill Switch

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Sterling so long as adequate (6" or 152 mm) clearance is maintained from the single wall pipe to combustible surfaces. The single wall vent pipe must connect to double -wall type B-1 vent at the first wall or ceiling penetration, and continue with type B-1 vent from thereon.
  • Page 11: Gas Supply

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Gas Supply ACTORY EADY FOR PERATION All Sterlings are shipped from the manufacturer fully assembled and ready for natural gas or LP (liquid propane) gas operation with minor adjustment. However, if the Sterling needs to be converted from natural gas to LP or from LP to natural gas, conversion of the unit must be performed by qualified service personnel using the manufacturer- supplied optional conversion kit.
  • Page 12: Gas Pressure Adjustment

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Gas Pressure Adjustment Once connected to the gas supply, the supply line and manifold gas pressures must be tested. The supply line pressure is tested, to ensure it meets the minimum gas supply pressure as listed in the Specifications for...
  • Page 13: Lighting The Unit For The First Time

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Lighting the Unit for the First Time Once the Sterling has been set in place and connected as described above, the unit is ready to be lit for the first time. Each Sterling is tested prior to shipment by the manufacturer, so ignition should take place without failure.
  • Page 14: Lighting Instructions

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Lighting Instructions 1. STOP! Read the safety information above. 2. Set the thermostat to "OFF" position. 3. Unplug the fan accessory, if so equipped. 4. Push in and turn gas control knob clockwise to "OFF"...
  • Page 15: Initial Adjustments

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent burners are controlled by the thermostat but that the pilot light remains lit regardless of the thermostat setting. To turn the pilot light off, turn the gas control valve fully clockwise to the OFF position.
  • Page 16: Pilot Adjustments

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent Pilot Adjustments The pilot light is preset by the manufacturer and should not need adjustment. The pilot light flame should be large enough to engulf the thermopile and thermocouple located just next to the pilot light, but not so large as to create excessive noise or consume excessive gas.
  • Page 17: Optional Blower Fan

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent other debris. To clean the firebox, set the thermostat to the OFF position, and turn off the gas at the gas control valve. When the unit is cool, unfasten the front door and carefully remove the decorative ceramic fiber log set taking care not to damage the logs or chip the enamel cast iron.
  • Page 18: Trouble Shooting

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent The supply line should be ½" diameter pipe or tubing. We recommend a flexible line to avoid undue mechanical load on the valve and to ease thread alignment. Check local codes.
  • Page 19: Parts List

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent ARTS 1546-462 Top Stone 1546-462A Side Stone 1546-463 Front Side Stone 1546-464 Front Bottom Stone 2510-219RS Door 2510-303 Bottom Leg 2510-401 2510-403F Front Grill 2510-411 RF Door Frame 2510-413 Side Leg...
  • Page 20: Safety Label

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent AFETY ABEL...
  • Page 21: Electrical Schematics

    HearthStone Quality Home Heating Products MODEL Sterling “G” B-Vent LECTRICAL CHEMATICS Wiring Color KEY: 50 60 70 80 90 HearthStone 50 70 90 Optional Blower...
  • Page 22: Limited Warranties

    Purchaser (referred to as the “Stove” for simplicity) against any of the occurrences listed in this document that result from defects in material or workmanship. All obligations of HearthStone under this document commence on the date the Original Purchaser purchases the Stove (the “Purchase Date”).
  • Page 23 A defect in any part of the Stove if the Original Purchaser fails to comply with HearthStone’s or a Dealer’s request to ship the part or the Stove to HearthStone or a Dealer, as the case may be. THE WARRANTIES CONTAINED IN THIS DOCUMENT ARE EXCLUSIVE AND ARE GIVEN BY...
  • Page 24 Dealer, as the case may be, will instruct the Original Purchaser to either return the defective part, or the entire Stove (if needed), with shipping prepaid, to HearthStone or a Dealer or allow a Dealer to make a service call at the place where the Stove is located.

This manual is also suitable for:

Sterling “g” b-vent

Table of Contents