9. Declaration of Conformity ....................25 Notes ............................26 Warranty registration card ....................27-28 Please refer to the Briggs & Stratton owners manual supplied with the LBP46 for any engine related questions on this machine 2 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
Page 3
Starter rope (LSP42,LSP46 & LBP45 models only) Quick-release clamp Grass collection bag Advance lever (LSP42, LSP46 & Fuel tank LBP46 only) Air box Parts supplied: spark plug socket, wrenches, 2 hose-clamps User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 3...
Introduction Thank you and congratulations on your purchase of a new SANLI mower. We are confident that this equipment, when properly maintained and adjusted, will give you many years of trouble-free operation enabling you to fully appreciate its quality, performance and ease of use.
Wear eye and hand protection when refilling the mower with fuel or oil. Wear protective equipment Wear eye and hearing protection when using the mower. User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 5...
● Start the engine carefully in a clear, unobstructed area following the instructions for use. Keep hands and feet well away from the turning blade. 6 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
To avoid the risk of serious burns, never touch a hot engine or any of its parts unless wearing suitable protective gloves. Observe any local or national regulations relating to the use of engine- powered outdoor equipment. User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 7...
Making any unauthorised modifications to the mower (i.e. modifications that are unauthorised by SANLI UK and/or an appointed SANLI dealer) can make the machine unsafe and may lead to severe injuries during use. SANLI UK can accept no liability for machine failure or personal injury if the machine’s...
If too much oil has been added to the engine, the excess can be drained out by tipping the mower onto its side with the air filter and carburettor uppermost. User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 9...
If a fuel leak is seen or suspected, do not start the engine. Drain the fuel tank using a fuel suction pump and immediately contact an approved SANLI UK service dealer for advice. 10 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
For best results, always adjust the cutting height of your mower to suit the mowing conditions and do not try to remove too much grass in one pass. Adjustment of the cutting height for models LS42, LSP42 and LSP46 is made centrally.
The LSP42, LSP46 & LBP46 mowers are equipped with a gearbox which allows the mower to be self-propelled. When the transmission is activated, it engages the rear wheels of the mower and the mower moves forward under its own power. 12 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
3.23 Stopping the mower To minimise possible risk of accidents, the engine of your SANLI lawnmower is coupled to an operator control. When the operator control lever is released, it returns immediately to its rest position and the engine is automatically turned off.
Remove the spark plug and gently clean off any carbon deposits from the tip with a small copper wire brush, finishing off with petrol. Allow the spark plug to dry. Pull the starter rope several times to expel excess oil 14 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
Never try to straighten a bent blade. Replace a damaged, worn or bent blade as soon as possible. Use only genuine SANLI parts or those approved by SANLI UK. Excessive vibration when mowing is a good indication of a problem with the cutting system.
Page 16
If the spark plug is worn or damaged, replace with a new spark plug of the same or suitable type for the engine. If in doubt, contact a SANLI UK appointed dealer. 16 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
Page 17
SANLI part WARNING: Do not twist the cartridge to clean foam, as you could damage it. The SANLI LSP46 mower is equipped with a dual filtration system comprising of the foam pre-filter and a cartridge filter paper.
Page 18
(fig.20). Check the effectiveness of the transmission and the resistance of the lever. Once proper adjustment has been reached, secure the adjustment device by tightening the lock nuts. 18 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
Therefore, please treat the text and images in this manual as being for illustrative purposes only. They may in no case serve as a basis for any legal claim. User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 19...
Page 20
= 136, b = 101, c = 49, d = a = 136, b = 102, c = 54, d = 88, e = 55 88, e = 56 20 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
Page 21
Acoustic power measured 92.4 dB (A) Acoustic power guarantee 96 dB (A) Vibration AhW 2.73 m/s Dimensions:(cms) a = 155, b = 102, c = 57, d = 105, e = User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46 / 21...
Worn or bent blade bag and/or excess Replace the blade Blockage between deck and grass clippings left on Clear blockage/clean bag collector bag or bag blocked the surface 22 / User’s Manual Sanli LS42 - LSP42 - LSP46-LBP46...
An identification number is located on the name plate affixed to the mower and also to the back of this instruction book. Please quote this number when contacting a SANLI authorised dealer or service agent to request a repair, maintenance or a replacement part.
To qualify for support under the SANLI UK guarantee, the applicant must submit as soon as possible a request or claim to an authorised SANLI UK service dealer or agent. A list of approved service dealers/agents is available on the website www.sanli.co.uk...
9. EC Declaration of Conformity Fujian Jinjiang Sanli Engine Co., Ltd. Declares that the following equipment manufactured by Fujian Jinjiang Sanli Engine Co.,Ltd conforms to the following Directive(s):2006/42/EC,2004/108/EC and 2000/14/EC of the European Parliament and of the council on the approximation of the laws of the Member States relating to the noise emission in the environment by equipment for use outdoors.
9. EC Declaration of Conformity Fujian Jinjiang Sanli Engine Co., Ltd. Declares that the following equipment manufactured by Fujian Jinjiang Sanli Engine Co.,Ltd conforms to the following Directive(s):2006/42/EC,2004/108/EC and 2000/14/EC of the European Parliament and of the council on the approximation of the laws of the Member States relating to the noise emission in the environment by equipment for use outdoors.
WARRANTY REGISTRATION CARD PLEASE REGISTER YOUR MACHINE TO VALIDATE YOUR WARRANTY To validate your warranty, register your equipment with SANLI UK after its purchase by completing and returning the warranty card below or by www.sanli.co.uk/register/. registering on the website Serial Number...