GENERATOR SET 6.5 HP - RECOIL START - 2600W/2800W RATED Model 92456 OPERATING INSTRUCTIONS ® 3491 Mission Oaks Blvd., Camarillo, CA 93011 Visit our Web site at http://www.harborfreight.com TO PREVENT SERIOUS INjURy OR DEATH, READ AND UNDERSTAND ALL WARNINGS AND INSTRUCTIONS bEFORE USE.
Write the invoice number on the inside of the front cover. Keep this manual and invoice in a safe and dry place for future reference. REV 11/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 2...
Do not change the plug in any way. Double insulation eliminates the need for the three wire grounded power cord and grounded power supply system. For technical questions, please call 1-800-444-3353. SKU 92456 Page 3...
Do not use the generator if the Power Switch does not turn it on or off. Any generator that cannot be controlled with the Power Switch is dangerous and must be replaced. For technical questions, please call 1-800-444-3353. SKU 92456 Page 4...
Page 5
“Inspection, Maintenance, And Cleaning” section of this manual. Use of unauthorized parts or failure to follow maintenance instructions may create a risk of electric shock or injury. For technical questions, please call 1-800-444-3353. SKU 92456 Page 5...
Generator. If the floor/ground surface is not level, strong cross members should be placed under the full length of the Generator Frame at its low side. For technical questions, please call 1-800-444-3353. SKU 92456 Page 6...
Page 7
If this occurs, open exhaust sys- tem drain plugs, if equipped, and allow the gases to dissipate before attempting to restart the Generator. Use only engine manufacturer recommended fuel and oil. For technical questions, please call 1-800-444-3353. SKU 92456 Page 7...
Do not induce vomiting if fuel is swallowed. For skin contact, immediately wash with soap and water. For eye contact, immediately flush eyes with clean water. For technical questions, please call 1-800-444-3353. SKU 92456 Page 8...
Connect the generator only to a load or electrical system (115 volt) that is com- patible with the electrical characteristics and rated capacities of the Generator. Before servicing equipment powered by the Generator, disconnect the equipment from its power input. For technical questions, please call 1-800-444-3353. SKU 92456 Page 9...
Install the Generator on a concrete slab or other area where rain drainage or flood waters can not reach it. Generator placement should allow four feet of access to all sides for mainte- nance. For technical questions, please call 1-800-444-3353. SKU 92456 Page 10...
Engine Crankcase. Fill the Engine’s Crankcase until the oil level is level with the upper marked line on the Dipstick. Then, screw the Dip- stick back into the Oil Fill Hole. (See Figure C, next page.) For technical questions, please call 1-800-444-3353. SKU 92456 Page 11...
Page 12
SWITCH GROUND CONNECTOR #6 AWG GROUNDING WIRE (NOT INCLUDED) GROUNDING ROD (NOT INCLUDED) FIGURE b FUEL GAUGE (34) FUEL TANK CAP (33) FUEL TANK (30b) OIL DIPSTICK (65A) FIGURE C For technical questions, please call 1-800-444-3353. SKU 92456 Page 12...
Page 13
CHOKE LEVER (21A) FUEL VALVE (40b) FIGURE E Turn on the Fuel Valve (40B). (See Figure E.) Close the Choke Lever (21A) to about 1/8” clearance. (See Figure E.) REV 03/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 13...
Page 14
If necessary pull the rope several times until the Engine starts. (See Figure G.) Allow the Engine to run for several seconds. Then, open the Choke Lever (21A) all the way. (See Figure E.) For technical questions, please call 1-800-444-3353. SKU 92456 Page 14...
Page 15
If using only a 12 volt DC tool or equipment, turn the 120 volt AC Circuit Breaker (5) to its “OFF” position. (See Figure D.) Start and run the Engine as previously discussed in this manual. For technical questions, please call 1-800-444-3353. SKU 92456 Page 15...
If abnormal noise or vibration occurs, have the problem corrected before further use. Do not use damaged equipment. For technical questions, please call 1-800-444-3353. SKU 92456 Page 16...
Storage: Before storing, drain all fuel out of the generator’s gas tank. If this is not followed, old fuel in the generator’s fuel tank may clog the generator and prevent it from starting until cleaned out. REV 10/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 17...
BUYER ASSUMES ALL RISK AND LIABILITY ARISING OUT OF HIS OR HER REPAIRS TO THE ORIGINAL PRODUCT OR REPLACEMENT PARTS THERETO, OR ARISING OUT OF HIS OR HER INSTALLATION OF REPLACEMENT PARTS THERETO. REV 06/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 18...
Page 20
Start Rope Piston Pin Start Handle Piston Pin C-clip NOTE: Some parts are listed and shown for illustration purposes only, and are not avail- able individually as replacement parts. REV 06/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 20...
Page 21
78A 79A 80A 23A 24A 12A 13A 15A 16A 17A NOTE: Some parts are listed and shown for illustration purposes only, and are not avail- able individually as replacement parts. REV 06/06 For technical questions, please call 1-800-444-3353. SKU 92456 Page 21...
Harbor Freight If any emission-related part on your engine is defective, the Tools Customer Service Department at 1-800-444-3353. part will be repaired or replaced by HFT. Harbor Freight Tools Emission Control For technical questions, please call 1-800-444-3353. SKU 92456 Page 23...
(c) failure to follow recommendations on fuel use contained in the Owner’s Manual (d) improper or inadequate maintenance of any war- ranted parts (e) repairs performed outside of the authorized war- ranty service dealers For technical questions, please call 1-800-444-3353. SKU 92456 Page 24...