Section 11 − Parts List; Recommended Spare Parts - Hobart Welding Products CHAMPION ELITE Owner's Manual

Trouble
Battery Discharges between uses.
Engine idles but does not come up to
weld speed.
Unstable or sluggish engine speeds.
Engine does not return to idle speed.

11-1. Recommended Spare Parts

Dia.
Mkgs.
. . . . . . . . . F1, F2 . . . 169296
. . . . . . . . . . . F6 . . . . . 215621
. . . . . . . . . . . . . . . . . . . . 215984
. . . . . . . . . . . . . . . . . . . . 230015
. . . . . . . . . . . . . . . . . . . . 230016
. . . . . . . . . . . . . . . . . . . . 066698
. . . . . . . . . . . . . . . . . . . . 215985
. . . . . . . . . . . . . . . . . . . . 067007
. . . . . . . . . . . . . . . . . . . . 230017
. . . . . . . . . . . . . . . . . . . . 237857
. . . . . . . . . . . . . . . . . . . . 199062
. . . . . . . . . . . . . . . . . . . . 198755
. . . . . . . . . . . . . . . . . . . . 198754
. . . . . . . . . . . . . . . . . . . . 241408
. . . . . . . . . . . . . . . . . . . . 198777
.
A complete Parts List is available on-line at www.HobartWelders.com.
OM-240 438 Page 46
Clean battery, terminals, and posts with baking soda and water solution; rinse with clear water.
Periodically recharge battery (approximately every 3 months).
Replace battery.
Check voltage regulator and connections according to engine manual.
Have Factory Authorized Service Agent check hour meter/idle module, and current transformer CT1.
Readjust throttle linkage if necessary. Check throttle solenoid TS1 for smooth operation.
Check oil level. Oil level should not exceed Full mark on dipstick. Fuel pump will operate erratically if
crankcase is overfilled.
Tune-up engine according to engine manual.
Remove weld and generator power loads.
Check throttle linkage for smooth, non-binding operation.
Have Factory Authorized Service Agent check hour meter/idle module, current transformer CT1, Engine
Control switch S2, and throttle solenoid TS1.
SECTION 11 − PARTS LIST
Part
No.
Recommended Spare Parts
. . Fuse, Mintr Gl 25. Amp 125 Volt
. . Fuse, 30 Amp Ato Type (Subaru and Kohler)
. . Filter, Fuel In−line .250 (Kohler)
. . Tune−up & Filter Kit, Kohler (Includes)
. . . . Air Filter Element, Kohler
. . . . Oil Filter, Kohler
. . . . Filter, Fuel w/Clamps & 1/4 in Fuel Line
. . . . Spark Plug
. . . . Air Filter Wrapper
. . Filter, Fuel In−line .250 (Subaru)
. . Tune−up & Filter Kit, Subaru (Includes)
. . . . Element, Air Filter
. . . . Filter, Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . Filter, Fuel w/Clamps
. . . . Spark Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
.
A complete Parts List is available at wwwHobartWelders.com
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Quantity
2
1
1
1
1
1
1
2
1
1
1
1
1
1
1