17.0 hp electric start 42" mower automatic lawn tractor (61 pages)
Summary of Contents for Craftsman EZ3 917.270813
Page 1
For answers to your questions about this product, CaEI: Read and follow all Safety 1-800-659-5917 Rules and Instructions before Sears Craftsman Help Line operating this equipment. 5 am - 5 pro, Mon- Sat Sears, Roebuck and Co., Hoffman Estates, II 60179...
Craftsmanridingequipmentis availableat no chargefor 30 daysfrom the date of purchase.Pleasecontactyour nearestservicecenter.After 30 daysfrom the date of purchase,warrantyserviceis availableby takingyour Craftsman ridingequipmentto your nearestSearsServiceCenter:(In-homewarrantyservicewill still be availableafter 30 daysfrom the date of purchasebut a standardtrip chargewill apply)..
, Slowdown beforeturning. blades and proceed slowly straight • Never leave a runningmachine down the slope., DO NOT: unattended. A lwaysturn off blades,set parkingbrake,stop engine, • Do not turn on slopes unless neces- remove keys before dismounting sary, and then, turn slowly •...
Page 4
, Neverrun a machineinsidea closed . Nevermake adjustmentsor repairs area. with the enginerunning. • Keep nuts and bolts, especiallyblade • Grasscatchercomponentsare subject attachmentbolts, tight and keep to wear, damage,and deterioration, equipmentin good condition° which could exposemoving parts or • Nevertamperwith safetydevices. allow objectsto be thrown.Frequently Check their proper operationregularly°...
CASE SIZE:U 1R REPAIR PARTS section of this manual)° BLADE BOLT 27-35 FT_ LBS TORQUE: CONGRATULATIONS on your purchase of a Craftsman Tractor., It has been designed, engineered and manufactured to give you the best possible depend- ability and performance.. Should...
Page 6
Parts Bag contents shown full size , ,ill i 1,,, = = i,,i, (1) Hex Bolt 3/8-16 (1) Lockwasher Locknut 5/16-18 (1) Hex Bolt (1) Large Fiat Washer 5/16-18 x 1-1/4 (1) Shoulder Bolt 5/16-18 (1) Knob (I) Washer 17/32 x 1-3/16 x 12 Gauge (2) Screws #10 x 5/8 (2) Lock Washers...
Page 7
Parts packed separately in carton Seat Mulcher Steering Plate Wheel Video Cassette Steering Manual Boot Parts Bag Parts Bag contents not shown full size Steering Wheel Insert Assemblies (2) Keys Steering Extension Shaft Steering Wheel Adapter Slope Sheet...
Page 8
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely_ Use the correct tools as necessary to insure...
Page 9
TO DRIVE TRACTOR OFF SKID .._+,;+:::_, ._" ._ 7_ _ . WARNING: Before starting, read, Label understand and follow all instructions the Operation section of this manual. sure tractor is in a well-ventilated area. Be sure the area in front of tractor clear of other people and objects.
Page 10
Hook CHECK FOR PROPER POSITION Points Weld Nut OF ALL BELTS Down From The To See the figures that are shown for Lock replacing motion and mower blade drive Washer Latch belts in the Service and Adjustments Weld Nut Hook section of this manual,.
Page 11
These symbolsmay appearon your tractoror in literaturesuppliedwith the product, Learn and understandtheir meaning, BATTERY CAUTION OR REVERSE FORWARD FAST SLOW WARNING LIGHTS ON OVER TEMP ENGINE ON LIGHT ENGINE OFF OIL PRESSURE PARKtNG BRAKE UNLOCKED MOWER LIFT FUEL CHOKE MOWER HEIGHT LOCKED ATTACHMENT REVERSE...
Page 12
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations various controls and adjustments. Save this manual for future reference_ ht Switch Lever Plunger Choke Contro Throttle Attachment...
Page 13
The operationof anytractorcan resultin foreignobjectsthrowninto the eyes,which can resultin severeeye damage. Alwayswear' s afety glassesor eye shieldswhile operatingyour tractoror performingany adjustmentsor repairs° We recommenda wide visionsafety maskover' spectaclesor standardsafetyglasses. HOW TO USE YOUR TRACTOR • Never use choke to stop engine° IMPORTANT: Leaving the ignition...
Page 14
• Turn knobclockwise( TO OPERATE MOWER f"-,I ) to raise cutting height.. Your tractor is equipped with an operator , Turn knob counterclockwise ()_'_) presence sensing switch Any attempt lower cutting height. the operator to leave the seat with the The cutting height range is approxi-...
, Do not pushor tow tractorat more than gas can damage the fuel system of an five (5) MPH engine while in storage. To avoid engine NOTE: To protect hood from damage problems, the fuel system should emptied before storage of 30 days or when transporting your tractor...
Page 16
COLD WEATHER STARTING (50 ° F and • When operating attachments, select a ground speed that will suit the terrain below) and give best performance of the . When engine starts, slowly push attachment being used. choke control in until the engine begins to run smoothly, Continue...
Choc. _roke Operation .CheckTl'eP'essu'e :V" o.oo. o0oro,o. oooooo I I I 1 Ii Interlock Systems Check for LoOSe Fasteners ' V' _S._;p_;_R_ple_e _Mow_ Bi"_e_ ................Lubrication Chart ..Che_, Ba!ter','_L e'or ....CIean Battery and Terminals Check Transaxle Cooling Adjust Blade Belt(s)
Page 18
TRACTOR • Install new or resharpened blade with trailing edge up towards deck as Always observe safety rules when shown.. performing any maintenance.. IMPORTANT: To ensure proper assem- BRAKE OPERATION bly, center hole in blade must align with if tractor requires more than six (6) feet star on mandrel...
NOTE: Although multi-viscosity oils BATTERY (5W30, IOW30 etc.) improve starting 'four tractor has a battery charging cold weather, these multi-viscosity oils system which is sufficient for normal use, will result in increased oil consumption However, periodic charging of the battery when used above 32°R Check your with an automotive...
ENGINE COOLING FINS , Clean cartridge by tapping gently flat surface.. If very dirty or damaged, Remove any dust, dirt or oil from engine replace cartridge.. cooling fins to prevent engine damage , Reinstall cartridge plate, cover plate, from overheating_ Air guide covers must knob and precleaner..
Page 21
IN-LINE FUEL FILTER CLEANING The fuel filter should be replaced once • Clean engine, battery, seat, finish, etc_ each season. If fuel filter becomes of all foreign matter_ clogged, obstructing fuel flow to carbure- . Keep finished surfaces and wheels tor, replacement is required..
Page 22
TO INSTALL MOWER Check adjustment on right side of tractor. Measure distance "D" directly in front , Raise attachment lift lever to its and behind the mandrel at bottom edge highest position. of mower housing as shown. • Slide mower under tractor with •...
Mandrel TO REPLACE MOTION DRIVE BELT Idler Pulley Park the tractor on level surface,. Engage Pulleys parking brake° For assistance, there is a Mandrel belt installation guide decal on bottom dley side of left footrest. ° Remove mower (See "TO REMOVE MOWER"...
Page 24
Neutral Lock Gate TO START ENGINE WITH A WEAK Gearshift Level BATTERY CAUTION: Lead-acid batteries generate explosive gases. Keep sparks, flame and smoking materials away from batteriesr Always wear eye protection when around batteries. If your battery is too weak to start the engine, it should be recharged...
Page 25
• Lift hoodto raised position. • Removeterminalguard, • DisconnectBLACKbattery cable then RED baiter.,/cableand carefully removebatteryfromtractor,, • Installnew batterywith terminalsin Headlight Wire samepositionas old battery° Connector • Reinstallterminal guard • FirstconnectREDbatterycable to positive(+) batteryterminalwith hex bolt and keps nut as shown Tighten securely.
Page 26
. With engine not running, move choke • Continue to hold throttle lever against control (located on dash panel) to full idle speed screw and adjust idle choke position speed screw to obtain t200 RPM, if • Loosen knob and remove cover the governed idle spring...
Page 27
Immediately prepare your tractor for filter, fuel hose, or tank during storage, storage at the end of the season or if the Also, experience indicates that alcohol blended fuels 9called gasohot or using tractor will not be used for 30 days or more..
TROUBLESHOOTING CHART [..CORRECTION CAUSE PROBLEM • Fill fuel tank. • Out of fuel. Will not start • See "TO START ENGINE" • Engine not "CHOKED" in Operation section. properly. - Wait several minutes • Engine flooded, before attempting to start, •...
Page 29
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Engine clicks but witl - Loose or damaged • Check all wiring, not start (Cont'd) wiring • Faulty solenoid . Check/replace solenoid starter,, starter, Loss of power • Cutting too much Set in "Higher Cut" position/ grass/too fast.
Page 30
TROUBLESHOOTING CHART PROBLEM CAUSE CORRECTION Mower blades will not . Obstruction in clutch Remove obstruction° rotate mechanism,, • Worn/damaged mower Replace mower drive belt., drive bell , Frozen idler pulley, Replace idler puIley. • Frozen blade mandre!. Replace blade mandrel. Poor grass discharge o Engine speed too slow.
Page 31
TRACTOR -- MODEL N UMBER 9I 7.270813 SCHEMATIC BATTERY FUSE STARTER AMMETER (OPTIONAL) ..{ ..BLACK L __-= CLUTCH ! BRAKE (PEDAL UP) ----( WHITE IGNITION SWITCH I - - - OCCUPIED) BLACK BLACK ATT'MENT CLUTCH " BLACK (CLUTCH OFF) GROUNDING CONNECTOR "_...
Page 32
TRACTOR -- MODEL NUMBER 917.270813 ELECTRICAL...
TRACTOR -- MODEL NUMBER 9t7.270813 GROUND DRIVE PART KEY PART DESCRIPTION DESCRIPTION Transaxie (See Breakdown) 140312 Keeper Bett Chassis Span Ctr ..Peerless 206-545C 17060612 Screw 3/8-16 x 75 146682 Cover Pedal BIk Round Spring Return Brake 8883R 123666X Pulley Transaxle 140186 Engine Pulley LT/YT 12000028...
Page 38
T RACTOI_ "" MODEL NUMBER 917.270B13 STEERING + ..,_ ..,r29...
Page 39
TRACTOR -- MODEL NUMBER 917,270813 STEERING KEY PART NO, NO, DESCRIPTION 139768 Wheel Steering 154427 Axle Asm Fr LT Wlgzks 38142 t56483 SpindleAsm LH t57473 SpindleAsm RH 6266H WasherThrust .75 x 1,230 121748X Washer 25f32 X 1-5t8 X 16 Ga I9272016 Washer 27132 X 1-t!4 X !6 Ga 12000029...
Page 44
TRACTOR-- MODEL NUMBER 917.270813 LIST ASSEMBLY 25 24...
Page 45
TRACTOR --MODEL NUMBER 917.270813 LIST ASSEMBLY KEY PART DESCRIPTION t59460 WireAsm lnnertSprg WfplungerLT 159471 Handleasm Lift LH I05767X Pin Groove 12000002 ERing#5133-62 19211621 Washer PLTD 21f32 X 4X 21ga 120183X Searing Nylon Slk 629 ld 12563tX GripHandle 122365X Button P_ungerRed 11 139865 Link Lift LH 139866...
Page 46
TRACTOR -- MODEL NUMBER 917.270813 MOWER DECK t06_ 103 105 t 02/_...
Page 47
TRACTOR -- MODEL NUMBER 917.270813 MOWER DECK PART PART DESCRIPTION DESCRIPTION 164961 MowerHousing 122052X Spacer Retainer Pm Mower STD533107 Bolt Rdhd Sqnk 5t16-18unc X3f4 140086 Spring Torsion Brakes 42" 138017 Guard TUV Idler Bracket Asm Fr Sway Bar 38/42 141043 138440 Knob Oval Bracket Asm Deck 42"...
Page 48
TRACTOR -- MODEL NUMBER 917.270813 PEERLESS TRANSAXLE--MODEL NUMBER 206-545C MODEL and SERIAL NUMBERS HERE...
Page 49
TRACTOR -- MODEL NUMBER 917.270813 PEERLESS TRANSAXLE--MODEL NUMBER 206-545C REF PART REF PART NO, NO. DESCRIPTION NO, NO. DESCRIPTION 772147 Transaxle Cover 41A 790079 Brake Lever 780086A Needle Bearing 5/8" 792073A Screw 1/4 * 20 x I-I/4" 770128 Transaxle Case 42A 792085A Screw I/4 - 20 x 2 tt4"...
Page 50
TRACTOR -- MODEL N UMBER 917.270813 BRIGGS & STRATTON ENGINE-MODEL NUMBER 350777, TYPE NUMBER 1034-A1 (_)7_ 5S2A_81 " REQUIRESSPECIALTOOLS'TO iNSTALL (SEE REPAIRINSTRUCTIONMANUAL)
TRACTOR -- MODEL NUMBER 917.270813 BRIGGS & STRATTON ENGINE-MODEL NUMBER 350777, TYPE NUMBER 1034-A1 109t ,_ 127A 788_>t _ _0_,_ 3S'_A _S27 _240...
Page 52
TRACTOR -- MODEL NUMBER 917.270813 BRIGGS & STRATTON ENGINE-MODEL NUMBER 350777, TYPE NUMBER 1034-A 1...
Page 53
TRACTOR-- MODEL NUMBER 917.270813 BRIGGS & STRATTON ENGINE-MODEL NUMBER 350777, TYPE NUMBER 1034-A1 °,,, ¢...
Page 54
TRACTOR-- MODEL NUMBER 917,270813 BRIGGS & STRATTON ENGINE-MODEL NUMBER 350777, TYPE NUMBER 1034-At PART PART DESCRIPTION DESCRIPTION 805562 Valve, Choke 807787 Cylinder Assembly 805058 O-Ring, Oil Pump 805107 Bearing, Cylinder 116A805198 O-Ring, Crankcase Cover 805101 Seal, Oil t168 224531 Washer, Bowl B0782t Head, Cylinder,...
Page 55
TRACTOR -- MODEL NUMBER 917.270813 BRIGGS & STRATTO N ENGINE.MODEL NUMBER 350777, TYPE NUMBER 1034-A1 KEY PART PART DESCRIPTION DESCRIPTION 494439 Screen, Rotating 805057 Screw, Sems 806028 Nut, Hex 805317 Screw, Mounting 492341 Armature, Magneto 270920 O-Ring 806104 Screw, Mounting 473880 Terminal, lgnilion Cable...
Page 59
SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION ONLY RIDE UP AND DOWN HILL, NOT ACROSS HILL SIGHTING GUIDE SIGHT AND HOLD THIS LEVEL WITH SKY LINE OR TREE. 15 ° MAX. greater than 15°), never across the face. Make turns gradu- ally to prevent tipping or loss of control.
Page 60
For in-home major brand repair service: Call 24 hours a day, 7 days a week 1-800-44ViY-HOME _M (I-800-469-4663) Para pedir servicio de reparaci6n a domicilio 1-800-676-5811 In Canada for all your service and parts needs call Au Canada pour tout le service ou les pi_ces t -800-665-4455 For the repair or replacement parts you need:...