Royal Enfield SIGNALS 350 Owner's Manual
  1. Manuals
  2. Brands
  3. Royal Enfield Manuals
  4. Motorcycle
  5. SIGNALS 350
  6. Owner's manual

Royal Enfield SIGNALS 350 Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

SIGNALS
350
USA/CALIFORNIA - CLASSIC 350/SIGNALS 350

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the SIGNALS 350 and is the answer not in the manual?

Questions and answers

Related Manuals for Royal Enfield SIGNALS 350

Summary of Contents for Royal Enfield SIGNALS 350

  • Page 1 SIGNALS USA/CALIFORNIA - CLASSIC 350/SIGNALS 350...
  • Page 3 FOREWORD Congratulations! Welcome to the Royal Enfield family. And to a world of motorcycling that has an enviable heritage, including being the world’s oldest motorcycle marque in continuous production. Since its introduction in 2008, the Classic 350 has captured the imagination of motorcycling enthusiasts across the world with its vintage inspired build, authentic styling and timeless appeal.
  • Page 4 Technical specifications are subject to change without prior notice at the sole discretion of Royal Enfield. “© Copyright 2021 Royal Enfield (A unit of Eicher Motors Ltd.). All Rights Reserved. No part of this manual shall be copied, distributed or otherwise dealt without the express permission in writing from Royal Enfield”.

  • Page 5: Important

    We would like to emphasize that any repairs to the induction, emission, exhaust and evaporative systems must be performed only by a Royal Enfield Authorized Dealer so that the motorcycle conforms to the United States Environment Protection laws. Federal Motor Vehicle Safety Standards and California Air Resources Board regulation (Applicable only for motorcycles sold within the state of California.)
  • Page 6 National Highway Traffic Safety Administration (NHTSA) in addition to notifying Royal Enfield North America Limited, 226 N Water St., Milwaukee WI 53202 US. If NHTSA receives similar complaints, it may open an investigation and ifit finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.

  • Page 7: Table Of Contents

    Pre-Operational Checks ..........55 Wiring Diagram ............110 Running in Period ............56 Radio Type Approval ........... 111 Starting ............... 57 Service/Maintenance Record ......... 112 Gear Shifting, Riding and Stopping ......62 Notes ................. 113 Royal Enfield All New Classic 350/Signals 350...

  • Page 8: Safety Definitions

    Indicates a potentially hazardous situation. Disregarding this message may result in injury to rider or other persons. CAUTION This message, if disregarded, may result in damage to the motorcycle. NOTE Indicates important and useful messages for better understanding. Royal Enfield All New Classic 350/Signals 350...

  • Page 9: Personal And Motorcycle Information

    Licence No. Valid till : Model Color : Engine No. VIN. No. Tyre make Front : Rear : Tyre Nos. Front : Rear : Battery make Battery No. Sold by Date of Sale Royal Enfield All New Classic 350/Signals 350...

  • Page 10: Safe Riding Tips/Guidelines

    Switch “OFF” mobile phones and other hand « bar controls, tyre pressures, fuel and oil levels, etc. held electronic devices. Use only genuine Royal Enfield spare parts and Do not smoke and please ensure that there are « no open flames or sparks near the motorcycle, approved accessories.
  • Page 11 Royal Enfield cautions you against the use of certain Do not exceed the legal speed imit or ride too  nonstandard parts such as aftermarket and custom fast for existing conditions. Always reduce speed made extended front forks or suspensions, which may when poor riding conditions exist.
  • Page 12 Bright/light colours Rough or uneven road surfaces. « are best for greater visibility in traffic, especially at Slippery road surfaces. night. Avoid loose, flowing garments and scarves. « Royal Enfield All New Classic 350/Signals 350...
  • Page 13 Replace worn out parts. Exhaust gas contains poisonous carbon monoxide  Worn out parts can adversely affect stability and and chemicals, known to cause cancer, birth handling. defects or other reproductive defects. Royal Enfield All New Classic 350/Signals 350...
  • Page 14 Centre regarding any questions or problems that leading to an accident. occur in the operation of your motorcycle. Failure to do so may aggravate an initial problem, cause costly repairs and jeopardize your personal safety. Royal Enfield All New Classic 350/Signals 350...

  • Page 15: Rules Of The Road

    Watch for loose debris, such as leaves, slippery,  turning either right or left, watch for pedestrians, substances or gravel that can hamper the stability animals, as well as other vehicles. of your motorcycle. Royal Enfield All New Classic 350/Signals 350...
  • Page 16 Never jump a traffic light. When  head is locked and then remove the ignition key. a change is imminent from Go to Stop (or vice versa) at intersections, slow down and wait Royal Enfield All New Classic 350/Signals 350...
  • Page 17 However, vehicles and other objects seen in this type of mirror will look smaller and farther away than when seen in a flat mirror. Use care when judging the size or distance of vehicles/ objects seen in these mirrors. Royal Enfield All New Classic 350/Signals 350...

  • Page 18: Accessories And Luggage

    Fitment of accessories which are not motorcycle and as low as possible; this minimizes tested and approved by Royal Enfield may affect the sudden shift in the motorcycle’s center of gravity. performance or life of the components for which Royal Enfield cannot be held responsible and Royal Enfield  Distribute weight evenly on both sides of the...
  • Page 19 ACCESSORIES AND LUGGAGE Large surfaces such as fairings, windshields, Royal Enfield cautions you against use of non-   backrests and luggage racks can adversely affect standard parts such as aftermarket and custom handling of the motorcycle. Use Royal Enfield...
  • Page 20 Do not exceed the maximum permissible overall  weight or the axle loads. If your motorcycle is equipped with saddlebags, a  windshield or a passenger backrest, be prepared to reduce operating speed to maintain stability. Royal Enfield All New Classic 350/Signals 350...

  • Page 21: Technical Specifications

    20.21 PS @ 6100 rpm (with ECU map number) Max torque ......27 Nm @ 4000 rpm Spark plug gap ..... 0.7 to 0.8 mm Idle RPM ......1050 ± 100 rpm Spark plug ......YR7MES/Bosch Royal Enfield All New Classic 350/Signals 350...
  • Page 22 Clutch ........Conventional wet clutch Secondary sprocket ratio ..2.800:1 Primary drive ....... Gear Drive chain links ....104 links Primary ratio......2.313 Gear box ......Constant mesh Gear ratio 2.615 1.706 1.300 1.040 0.875 Royal Enfield All New Classic 350/Signals 350...
  • Page 23 F TT Brakes Size : 120/80-18 M/C 62P Front disc ....300 mm disc with twin piston floating caliper Rear disc ....270 mm disc, single piston floating caliper ABS ......Dual channel Royal Enfield All New Classic 350/Signals 350...
  • Page 24 Fuel dead stock ....1.5 +/- 0.5 l Rear ......36 psi * The above values are approximate and the actual fuel Steering lock ......Integrated with filling capacity will vary from the values mentioned. ignition lock Royal Enfield All New Classic 350/Signals 350...
  • Page 25 Modifications on the motorcycle which are not approved Hi-beam indicator ....12 V - LED by Royal Enfield may not only disqualify for warranty, but Neutral lamp tell tale ... 12 V - LED also affects performance of the motorcycle.
  • Page 26 Do not use the vehicle beyond the allowed gross Saddle height ...... 805 mm  weight. The suspensions and tyres are designed to perform only to the maximum gross vehicle weight. Royal Enfield All New Classic 350/Signals 350...

  • Page 27: Recommended Lubricants

    * Do not mix Dot 4 & other brake fluids together. Dry fill : 2.2 l (Approx.) CAUTION Use of wrong grade/mixed grade oil will reduce the life of the moving parts and seriously affect performance. NOTE Recommendation subject to change without notice. Royal Enfield All New Classic 350/Signals 350...

  • Page 28: Motorcycle Identification Numbers

    Net brake horse power of the engine in hp Check digit Model year Plant location C - Chennai,K - Kanchipuram, V - Vallam Vadagal Engine capacity 3 - indicating 349.3cc Running serial number Royal Enfield All New Classic 350/Signals 350...
  • Page 29 It is illegal to tamper with the VIN information label as it is the It is illegal to tamper with the VIN information label as it is the only means of identifications of the motorcycle. only means of identifications of the motorcycle. Royal Enfield All New Classic 350/Signals 350...
  • Page 30 It is illegal to tamper with the VIN information label as it is the It is illegal to tamper with the VIN information label as it is the only means of identifications of the motorcycle. only means of identifications of the motorcycle. Royal Enfield All New Classic 350/Signals 350...

  • Page 31: Engine Number Details

    Engine Capacity Type of Cooling Type of Transmission Type of Fuel system Production Month (A-Jan., H- Aug., K- Sep., N-Dec.) Year of Manufacturing (2020:L, 2021:M, 2022:N) Manufacturing Plant (1-Oragadam, 2-Vallam Vadagal) Production Serial Nos Royal Enfield All New Classic 350/Signals 350...
  • Page 32 MOTORCYCLE IDENTIFICATION LABELS AND LOCATION Scan the QR code to view the labels and its location on your motorcycle. Royal Enfield All New Classic 350/Signals 350...

  • Page 33: Location Of Keyparts

    6. Handle bar Instrument cluster 8. Ignition switch 9. Day flash switch 10. High beam/low beam switch 11. Info button 12. Clutch lever 13. Turn signal switch 14. Charger port 15. Horn button Royal Enfield All New Classic 350/Signals 350...
  • Page 34 LOCATION OF KEYPARTS Right trafficator rear 2. Rear wheel 3. Right side panel 4. Starter motor 5. Brake pedal 6. Horn Front wheel 8. Right trafficator front 9. Brake lever front 10. Spark plug Royal Enfield All New Classic 350/Signals 350...
  • Page 35 LOCATION OF KEYPARTS Left trafficator front 2. Gear change pedal 3. Side stand 4. Center stand 5. Left trafficator rear 6. Seat Left side panel 8. Fuel tank Royal Enfield All New Classic 350/Signals 350...

  • Page 36: Operation Of Controls

     STEERING LOCK position. Turn the handle bar to extreme  left position. Push the key inside  in “OFF” position, press and further turn to anticlockwise direction to lock the steering system. Royal Enfield All New Classic 350/Signals 350...
  • Page 37 Fuel tank mouth Gasoline vapour is highly explosive. Please ensure Splash arrestor there are no open flames or sparks nearby while Maximum fuel level refuelling and fill fuel only in a well ventilated area. Royal Enfield All New Classic 350/Signals 350...
  • Page 38 Wipe immediately incase fuel spills over as otherwise it will leave a permanent stain on the painted surfaces. CAUTION In case of prolonged stoppage of vehicle, please  turn off ignition key to avoid discharge of battery. Royal Enfield All New Classic 350/Signals 350...
  • Page 39 5. Display features 6. Odometer Trip A and Trip B 8. Trip F TRIP 9. Fuel bar graph AMPM kmiles 10. Gear indication 11. ECO mode 5A 5C 12. Service reminder 13. Clock Royal Enfield All New Classic 350/Signals 350...
  • Page 40 Trip F : ECO Mode   Distance driven after low fuel tell tale is “ON” Indicated when driven under optimum Cannot be re-set conditions. Will be visible only when low fuel condition Royal Enfield All New Classic 350/Signals 350...
  • Page 41 OPERATION OF CONTROLS INFO BOTTON MANAGEMENT DETAILS If Trip F not enabled. LCD SEQUENCE (Info switch press <1 s):- If Trip F enabled. NOTE For trip re-set press info button for T>3 s.  Royal Enfield All New Classic 350/Signals 350...
  • Page 42 After fuel filling above reserve level Trip F  surfaces. will continue to show for few mins which is a normal behaviour, this is to avoid wrong indication. Trip F reset may occur when riding in mid  Royal Enfield All New Classic 350/Signals 350...
  • Page 43 Enter into minutes mode (minutes to blink) Setting info 0.2<t<1 Minutes to increment info t>3 Enter into unit mode (AM/PM) to blink info 0.2<t<1 Toggle between AM or PM info t>3 Save data and exit clock setting mode Royal Enfield All New Classic 350/Signals 350...
  • Page 44 RE Mobileapp. Tripper is being provided to have turn by turn Navigation on motorcycle to help riders to have a hassle free riding without handling the smartphones, This device works Royal Enfield All New Classic 350/Signals 350...
  • Page 45 Tripper unit display may look dull during sun overhead Mobile phone low battery indication.  conditions this is normal and due to impact of direct sunlight on the unit customers to refer during other riding conditions. Royal Enfield All New Classic 350/Signals 350...
  • Page 46 100 m, if there is no turn the display will be blank in this region. Distance to destination or ETA: Shows the total  distance to destination or estimated time of arrival (based on used selection from RE Mobile app). Royal Enfield All New Classic 350/Signals 350...
  • Page 47 Tripper will show clock Clock a) If no connec�on is established b) If connec�on is established but no naviga�on input is observed c) Once des�na�on is reached Royal Enfield All New Classic 350/Signals 350...
  • Page 48 Tripper as it may result in permanent damage to For first time pairing user needs to enter the  the same. secured pin shown on tripper through RE Mobile Royal Enfield All New Classic 350/Signals 350...
  • Page 49 Calibrate mobile phones frequently for more GPS Disable battery optimisation settings/low battery   accuracy & location accuracy is dependent on. cut-off setting of smartphone for navigation to work in low battery mode. Royal Enfield All New Classic 350/Signals 350...
  • Page 50 Recommended not to use in rainy conditions to   avoid damages to smart phones and charger, RE inside USB charging port which may lead to short circuit. shall not be liable for any damage to smart phones. Royal Enfield All New Classic 350/Signals 350...
  • Page 51 USB charger will function only when engine is in  smart phone battery capacity, SOC and smart running condition. phone charging circuits. Use standard approved and high quality USB  cables for proper functioning. Royal Enfield All New Classic 350/Signals 350...

  • Page 52: Warning Indications And Safety Systems

    ABS modulator to momentarily and continuously reduce the hydraulic pressure and Failure to do so can result in a serious injuries and loss thereby prevent the brakes from locking the wheels of life. Royal Enfield All New Classic 350/Signals 350...
  • Page 53 Please anticipate the stopping distance required for the speed of travel and apply brakes well in advance so as to bring the motorcycle to a safe stop. Royal Enfield All New Classic 350/Signals 350...
  • Page 54 CAUTION (ABS) Visually inspect for  Always use the approved front /rear tyres and  damaged teeth on sprockets by Royal Enfield to ensure correct ABS the front and rear operation. ABS tone rings. Inspect for damages  Do not make any changes to the suspension ...
  • Page 55 Apply both the brakes simultaneously for better efficiency.  braking. In the event of the ABS indicator remaining continuously  “ON”, please take the motorcycle to a nearest authorised Royal Enfield Service Centre to inspect the brake system. Royal Enfield All New Classic 350/Signals 350...
  • Page 56 Ensure the motorcycle is made upright and is on its  center stand. Ensure gears are in correct neutral and the neutral  lamp is glowing in the instrument console. Royal Enfield All New Classic 350/Signals 350...

  • Page 57: Pre-Operational Checks

    Cable for fraying or crimping and free operation. Failure to do so may affect safe operation, damage your Engine oil level. motorcycle and could result in an accident causing Alloy wheels for proper tightness. serious injury. Royal Enfield All New Classic 350/Signals 350...

  • Page 58: Running In Period

    RUNNING IN PERIOD Ride at proper speed and avoid sudden The Royal Enfield motorcycle as you would be accelerations and braking. experiencing is capable of consistent high speeds. Avoid riding motorcycle continuously for over an However as with any new motorcycle, a “Running-In”...

  • Page 59: Starting

    Turn ignition key to “ON” position and engine kill  switch on right hand side handle bar to “RUN” position When both ignition  engine kill switch “ON” position Royal Enfield All New Classic 350/Signals 350...
  • Page 60 In case the last bar is blinking continuously, it indicates low fuel level in the tank. Please re-fuel immediately. Don’t run the vehicle in low fuel condition in longer  duration, which may damage the fuel pump. Royal Enfield All New Classic 350/Signals 350...
  • Page 61 Ensure side stand is removed before vehicle  to raise. Failure to adhere to this important moving/ starting. Royal Enfield All New Classic 350/Signals 350...
  • Page 62 WARNING Please exercise extreme care while riding the motorcycle. Failure to do so can result in an accident causing injury to you or to other road users/passerby. Royal Enfield All New Classic 350/Signals 350...
  • Page 63 Do not release the button before engine starts. Do not press the starter button more than 5 sec  After three successive cranking, wait for 15 to 20 sec the battery to recover. Royal Enfield All New Classic 350/Signals 350...

  • Page 64: Gear Shifting, Riding And Stopping

    (Engine rpm around idling to 2000 rpm) at 1 gear the engine besides causing damage to transmission condition. In other gears and higher rpm avoid parts. using half clutch which will proportionately reduce Royal Enfield All New Classic 350/Signals 350...
  • Page 65 GEAR SHIFT PATTERN stalling or straining to pull. 1 -- N -- 2 -- 3 -- 4 -- 5 The clutch lever must be fully depressed before attempting Royal Enfield All New Classic 350/Signals 350...
  • Page 66 Down Shift life to rider/other road users/passed by besides damage to the motorcycle. Royal Enfield All New Classic 350/Signals 350...
  • Page 67 When the engine speed decreases or while climbing ignition and switch “OFF” engine kill switch. a gradient or running at a reduced speed, shift to the appropriate lower gear to prevent the engine from stalling or straining to pull. Royal Enfield All New Classic 350/Signals 350...

  • Page 68: Parking

    Parking in a soft ground may cause stand to sink and the stand and pull motorcycle backwards, gently. motorcycle to fall, causing injury to you or to others and damage to the motorcycle parts. Royal Enfield All New Classic 350/Signals 350...

  • Page 69: Tools Kit

    Ring spanner 24x14-24 (Eye wrench) x 14 (open end) Combination Open end spanner 17 x 13 D/E Spanner 10 x 12 Screw driver 06 x 120/135 C-Spanner Extension tube 28x7 & 24 x 14 Royal Enfield All New Classic 350/Signals 350...

  • Page 70: Minor Maintenance Tips

    CONTROL CABLES Lubricate after water washing motorcycle or if used CENTER/SIDE STAND PIVOTS during rainy conditions. Apply a few drops of  oil on the pivots after cleaning the area of dirt. Royal Enfield All New Classic 350/Signals 350...
  • Page 71 Do not inspect the oil level window immediately  Engine oil level should be “Max” level.  working up allow it to settle properly. Do not overfill the engine oil above “Max”.  Royal Enfield All New Classic 350/Signals 350...
  • Page 72 LH & RH chain adjuster at every 500km interval. by using 6 mm allen key. Please check the front and rear wheels are correctly aligned, after the chain adjustment. Royal Enfield All New Classic 350/Signals 350...
  • Page 73 Check and set the electrode gap between 0.70 to  0.80mm. Refit the spark plug on the cylinder head and refit  the spark plug cap on the spark plug. Royal Enfield All New Classic 350/Signals 350...
  • Page 74 Front : Check that the brake fluid reservoir is Do not mix Dot 4. horizontal and that the fluid level is above middle of the oil window. Oil window middle to be considered as “Min” mark. Royal Enfield All New Classic 350/Signals 350...
  • Page 75 ABS please clean the area immediately with a soft cloth hydraulic unit valves. to avoid damage. Royal Enfield All New Classic 350/Signals 350...
  • Page 76 Check proper seating of the tyre beading on the rim Royal Enfield, failure to adhere the same may result  in tyre damage and may cause injury to the rider.
  • Page 77 Royal Enfield has provided your new motorcycle with NOTE the optimum brake pad friction material available. After sanding the glazed areas, clean the brake shoe It gives the best with a cloth. performance under dry, Royal Enfield All New Classic 350/Signals 350...
  • Page 78 NOTE For checking the battery voltage check with multi-  The poor contact or loose fitments of battery terminals meter in voltage mode or contact Royal Enfield may cause electrical/electronic parts failure. Authorised Service Centre or battery service center. Royal Enfield All New Classic 350/Signals 350...
  • Page 79 The adjusting screw is used to increase or decrease  the height of the headlight beam in vertical direction only. This may be required to increase the visibility and to help prevent the other riders/ vehicles passing nearby. Royal Enfield All New Classic 350/Signals 350...
  • Page 80 MINOR MAINTENANCE TIPS Fuse & Fuse carrier located in RH side cover. EMS FUSES Royal Enfield All New Classic 350/Signals 350...
  • Page 81 Failure to do so may result in repeated fuse failure. Usage of fuses other than specified rating or usage of any other conductive materials or low grade fuses will damage the complete electrical system Royal Enfield All New Classic 350/Signals 350...

  • Page 82: Rear Suspension Setting

    Ensure adjuster are clear of all dirt and debris  Make the same adjustments on both sides, uneven  before adjusting, if they have dirt or debris please adjustment may lead to discomfort to the rider. clean it suitably before adjusting. Royal Enfield All New Classic 350/Signals 350...
  • Page 83 Laden / Two up / Rider + Pillions / payload (Inc of rider weight, Rider + Pillion + Accessories pillion weight and accessories) *Ensure the preload is set equally on the LH and RH rear suspension. Royal Enfield All New Classic 350/Signals 350...

  • Page 84: Long Trip Precautions

    Bulbs for headlight, trafficator light and fuse.  CHECKS AFTER EVERY 1,000 KM OF RUN Accelerator and clutch cables.  Any loose fasteners.  Spark plug, spark plug cap, fuel hose.  Condition of the tyres.  Royal Enfield All New Classic 350/Signals 350...

  • Page 85: Washing Procedure

    & exhaust outlets. cold condition. Do not apply any corrosive solvent on painted  Do not remove side panel while washing to avoid  surfaces or rubber parts. water entry. Royal Enfield All New Classic 350/Signals 350...
  • Page 86 (i.e. during winter in places where road should not be washed with soap or chemical, use salt is used) or near coastal areas it is recommended only with plain water. to wash your motorcycle with cold water after the Royal Enfield All New Classic 350/Signals 350...
  • Page 87 Start the engine and allow to run at an idling speed  for a few minutes to warm up engine. Drive the motorcycle slowly, apply both the brakes  intermittently to dry up the water in brake pads. Royal Enfield All New Classic 350/Signals 350...

  • Page 88: Storage Precautions

    Wipe off excess lubricant after 5min of application.  Battery (+ve) connector can be disconnected to  Remove charging circuit fuse from the fuse box.  avoid battery drain issue in longterm. Royal Enfield All New Classic 350/Signals 350...

  • Page 89: Environment Care

    BE AN ENVIRONMENTALLY CONSCIOUS RIDER You’ve ridden through some beautiful places on your Royal Enfield. Won’t you like to keep them that way? Here are some tips to help you keep those places unspoilt so that others can enjoy them too:...
  • Page 90 Tyre(s) / Plastic / Electrical / Electronic parts / Oil Filter If your Royal Enfield’s tyre(s) / plastic / electrical / electronic part(s) / oil filter need to be replaced make sure you hand them over to an authorised recycling agent or a Royal Enfield service centre. They will follow the local authority’s guidelines to get rid of them in an environmentally friendly manner.

  • Page 91: Periodical Maintenance Chart

    The frequency of the maintenance must be shortened depending upon the severity of the driving condition or if the motorcycle is used in a very dusty environment. Contact the nearest Royal Enfield Authorised Dealer / Service Centre for expert advice and to carry out the required maintenance.
  • Page 92 & drain the overfilled by removing plug. Spark plug C&A C&A C&A HT lead for crack Air filter element Clean/Replace more frequently if operated in dusty condition Vent pipe under air filter box Royal Enfield All New Classic 350/Signals 350...
  • Page 93 Fuel filter in fuel pump Front fork oil Inspect/adjust, if required lubricate for every 5,000 km Steering ball races play or earlier as required. Replace if necessary. Wheel rim run out front & rear Royal Enfield All New Classic 350/Signals 350...
  • Page 94 I&R I&R Front & rear brake hose & banjo bolt Brake fluid level, front & rear disc Adjust every 1,000 km or earlier as required & Clutch lever/cable free play replace if required. Royal Enfield All New Classic 350/Signals 350...
  • Page 95 Pivot-side stand, center stand, pillion foot rest, gear shifter, brake pedal, levers Throttle cable Adjust every 5,000 km or earlier if required Brake pads - front & rear Side stand switch operation All mounting fasteners in vehicle for tightness Royal Enfield All New Classic 350/Signals 350...
  • Page 96 The frequency of the maintenance must be shortened depending upon the severity of the driving condition or if the motorcycle is used in a very dusty environment. severe climatic cold and hot conditions. bad roads, stagnant water etc ., Contact a nearest Royal Enfield Authorised Dealer/ Service Centre for expert advice and to carry out the periodical maintenance.

  • Page 97: Warranty Terms And Conditions

    In order to effect Warranty. it is a prerequisite that the maintenance schedule prescribed by Royal Enfield in this owner’s manual and warranty repairs if any, has been carried out at the Authorised Distributor’s service facility or at their Authorised dealership’s service facility.
  • Page 98 During the warranty period, Royal Enfield’s obligation is limited to repair or replacing free of charge, such part or parts of the motorcycle which in examination shall be deemed defective in the opinion of Royal Enfield and/ or their distributors/authorised dealers. Such defective part(s). which has been replaced, shall become the property of Royal Enfield.
  • Page 99 WARRANTY TERMS AND CONDITIONS 8. Warranty will become void under the following conditions: Damages due to lack of proper maintenance, periodic services not carried out as per Royal Enfield  recommendation etc. Damages caused by any unauthorised repairs carried out in any part of the motorcycle.
  • Page 100 Royal Enfield and may render this warranty void.

  • Page 101: Emission Warranty

    EMISSION CONTROL SYSTEM WARRANTY YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Royal Enfield Motor Company are pleased to explain the emission control system warranty on your new motorcycle. In California, new motor vehicles must be designed, built and equipped to meet the State’s stringent anti-smog standards.
  • Page 102 If any emission related part on your motorcycle is defective, the part will be repaired or replaced by Royal Enfield Motor Company. This is your emission control system defects warranty.
  • Page 103 EMISSION CONTROL SYSTEM WARRANTY You are responsible for presenting your motorcycle to an authorized Royal Enfield dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days.
  • Page 104 EMISSION CONTROL SYSTEM WARRANTY We recommend that you take your motorcycle to an authorized Royal Enfield dealer for repairs under this warranty. The dealer has factory-trained mechanics and genuine Royal Enfield parts. However, in the case of an "emergency" (as defined below), you could have repairs performed at any available service establishment or by the owner, using any replacement part.
  • Page 105 Enfield parts are warranted by their manufacturer to be equal in quality to Genuine Royal Enfield parts in both performance and durability. The use of non-Royal Enfield replacement parts does not invalidate the existing warranty, if any, on other Royal Enfield components unless the non-Royal Enfield parts cause damage to warranted parts or result in the creation of an emissions non-compliant motorcycle.
  • Page 106 The repair or replacement of “warranted parts” which are scheduled for replacement prior to 30,000 km (18641 mi), once these parts have been replaced at the first replacement interval as part of required maintenance services. Repairs and services performed by anyone other than an authorized Royal Enfield Dealer (except in case of emergency as defined above).
  • Page 107 Warranty. (Applicable only for motorcycles sold within the state of California.) Royal Enfield Motors warrants the first owner and each subsequent owner, that this motorcycle is designed and built so as to conform, at the time of sale, with applicable regulations specified by the U.S. Federal Environmental...
  • Page 108 Any motorcycle in which the odometer has been tampered with, or the speedo cable has been disconnected for any reason or is broken and not replaced immediately, due to which the exact distance covered cannot be determined. Royal Enfield All New Classic 350/Signals 350...
  • Page 109 Repairs to the noise control system may be performed by any other qualified service outlet or individual and use of parts other than genuine Royal Enfield supplied parts is permissible, only if such agency or individuals and the non genuine parts used, are certified to comply with the U.S. Environmental protection agency standards.

  • Page 110: Noise Control System Warranty

    The following warranty applies to the evaporative emission control system. Royal Enfield Motors warrants the first owner and each subsequent owner, that this motorcycle is designed and built so as to conform, at the time of sale, with applicable regulations specified by the evaporative emission control system related parts fitted to this motorcycle are free from defects in materials and workmanship which may cause this motorcycle not to meet applicable regulations period of 24 months from the date of first use of the motorcycle.

  • Page 111: Evap

    Repairs to the evaporative emission control system may be performed by any other qualified service outlet or individual and use of parts other than genuine Royal Enfield supplied parts is permissible. only if such agency or individuals and the non genuine parts used, are certified to comply with the California air resources board.

  • Page 112: Wiring Diagram

    It is recommended that the wiring circuit repair and any other electrical rework should be performed only by an authorized Royal Enfield service centre, failure to adhere this may cause damage to electrical systems and render the warranty of the products as void.

  • Page 113: Radio Type Approval

    15 of the FCC Rules. These limits are designed to provide least20 cm from all persons. reasonable protection against harmful interference in a residential Royal Enfield All New Classic 350/Signals 350...

  • Page 114: Service/Maintenance Record

    SERVICE / MAINTENANCE RECORD S.No. Type of Service Schedule Date Job Card No. Dealer Code Brief Details of Service Royal Enfield All New Classic 350/Signals 350...

  • Page 115: Notes

    NOTES...
  • Page 116 Part No. RAM00359/A Edition : December 2021...

Table of Contents

Save PDF