GAS GAS FSE 400 - 2004 Service Manual page 57

TROUBLE
17 Shock absorption too hard
18 Shock absorption too soft
19 Abnormal train noise
20 Handlebar shakes or excessivery
vibrates
Motorcycle pull to one side
21
CAUSE
- Front fork oil viscosity too hight.
- Front fork leg bent.
- Tire air pressure too high.
- Rear shock absorber maladjusted.
- Front fork oil insufficient and/ or leaking.
- Front fork oil viscosity too low.
- Front fork leg bent.
- Tire air pressure too small.
- Rear shock absorber maladjusted.
- Drive chain adjusted improperly.
- Chain worn.
- Rear and/or engine sprocket worn.
- Chain lubrication insufficient.
- Rear wheel misaligned.
- Oil front fork insufficient or too thin.
- Spring weak or broken.
- Disc brake worn.
- Pad installed incorrectly or surface glazed.
- Cylinder damaged.
- Bracket, nut, bolt, etc. not properly
mounted or tightened.
- Tire, swing arm sleeve or needle bearin
damaged.
- Rim warped.
- Wheel misaligned.
- Front/ rear axle runout excessive.
- Frame bent.
- Steering maladjusted.
121
EC FSE 2004 - -
REMEDY
- Empty oil from fork and go to specialized garage.
- Change it. Go to a specialized garage.
- Check tire air pressure.
- Check rear shock absorber.
- Fill up until correct level.
- Empty oil from fork and fill up with suitable viscosity oil.
- Change front fork. Go to specialized garage.
- Check tire air pressure.
- Check rear shock absorber.
- Adjust chain.
- Change chain and rear engine sprocket.
- Change it.
- Lubricate with apropiate chain oil.
- Align rear wheel.
- Add oil until correct level.
- Change spring.
- Change disc brake.
- Replace pad or change.
- Change cylinder damaged.
- Go to specialized garage.
- Change it for new pieces.
- Centre rim.
- Check wheel rim pressure. Adjust if it is necessary.
- Check rear/ front axle steering. Adjust if it's necessary.
- Go to specialized garage.
- Adjust steering. Go to specialized garage.