1. Manuals
  2. Brands
  3. Air Quality Engineering Manuals
  4. Air Cleaner
  5. MiracleAir CM-12
  6. Owner's and service manual

Air Quality Engineering EverClear CM-11 Owner's And Service Manual

Hide thumbs

Advertisement

Table of Contents

OWNER AND SERVICE MANUAL
EverClear
SELF-CONTAINED MEDIA AIR CLEANERS
Mail: Air Quality Engineering
7140 Northland Drive N
Brooklyn Park, MN 55428
USA
 2015
Air Quality Engineering, Inc. copyrights this manual with all rights reserved. Under the
copyright laws, this manual may not be reproduced in any form, in whole or in part, without the
prior written consent of Air Quality Engineering, Inc.
All statements, technical information and recommendations in this manual or related
documents are believed reliable, but the accuracy and completeness thereof are not
guaranteed or warranted, and they are not intended to be, nor should they be understood to be
representation or warranties concerning the products described. Specifications are subject to
change without notice.
Does not meet California air cleaner regulation requirements; cannot be shipped to California.
™
CM-11 and MiracleAir
CM-12
Phone:
1.800.328.0787
763.531.9823
Fax:
763.531.9900
e-mail:
info@air-quality-eng.com
web:
www.air-quality-eng.com
®

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the EverClear CM-11 and is the answer not in the manual?

Questions and answers

Related Manuals for Air Quality Engineering EverClear CM-11

Summary of Contents for Air Quality Engineering EverClear CM-11

  • Page 1  2015 Air Quality Engineering, Inc. copyrights this manual with all rights reserved. Under the copyright laws, this manual may not be reproduced in any form, in whole or in part, without the prior written consent of Air Quality Engineering, Inc.
  • Page 2 This page intentionally left blank. Page 2 of 16 OM-0053 Rev. A 7140 Northland Dr N, Minneapolis, MN 55428 800-328-0787 air-quality-eng.com...
  • Page 3 TABLE OF CONTENTS PAGE SPECIFICATIONS PLANNING THE INSTALLATION INSTALLATION ELECTRICAL INSTALLATION ELECTRICAL SCHEMATIC CHECKOUT MAINTENANCE PARTS LIST WARRANTY Page 3 of 16 OM-0053 Rev. A 7140 Northland Dr N, Minneapolis, MN 55428 800-328-0787 air-quality-eng.com...

  • Page 4: Specifications

    CM-11 SPECIFICATIONS IMPORTANT! THE SPECIFICATIONS GIVEN IN THIS PUBLICATION DO NOT INCLUDE NORMAL MANUFACTURING TOLERANCES; THEREFORE, THIS UNIT MAY NOT MATCH THE LISTED SPECIFICATIONS EXACTLY. ALSO, THIS PRODUCT IS TESTED AND CALIBRATED UNDER CLOSELY CONTROLLED CONDITIONS AND SOME MINOR DIFFERENCES IN PERFORMANCE CAN BE EXPECTED IF THOSE CONDITIONS ARE CHANGED.

  • Page 5: Planning The Installation

    BLOWER WHEEL: The standard prefilter is a ½” thick washable Forward curved, direct drive, 12½” x 4”, single inlet aluminum mesh, PN 41194. Optional disposable wheel. filters are available. FINE PARTICLE FILTER: ODOR / VAPOR FILTER: The main particle filter 41190 has a minimum of 102 The standard MiracleAir®...

  • Page 6: Installation

    CHOOSE LOCATION To ensure even air distribution, the CM-11 and CM-12 units draw air into their center and discharge air in four directions as shown in the figure below. This Coanda airflow pattern ensures that all air in the room passes through the air cleaner.
  • Page 7 3. Remove the two discharge grilles that are 1. Attach four galvanized steel support wires to the individually packaged and located inside the two true ceiling at the location shown in Fig. 1. Twist discharge openings. each wire at least four times to provide safe support for the air cleaner.
  • Page 8 CM-12 INSTALLATION IMPORTANT! WIRING The CM-12 has a standard three-prong plug on a 10 foot [3 m] power cord. It requires only a standard Read these instructions carefully. A hazardous grounded outlet for electrical power. Route the power condition or damage to product could result if cord so that it will be out of the way of the building’s instructions are not followed.
  • Page 9 CM-11 & CM-12 ELECTRICAL INSTALL REASSEMBLE CAUTION! 1. Install the two carbon filters into the two discharge cavities. Make sure the support clips are in place before letting go of the filter modules. Persons qualified to install electrical wiring should only attempt this procedure. All wiring 2.

  • Page 10: Electrical Schematics

    CM-11 ELECTRICAL SCHEMATICS AIR CLEANER MODEL CM-11 REMOTE CONTROL AIR CLEANER MODEL CM-11 Page 10 of 16 OM-0053 Rev. A 7140 Northland Dr N, Minneapolis, MN 55428 800-328-0787 air-quality-eng.com...
  • Page 11 CM-12 ELECTRICAL SCHEMATICS AIR CLEANER MODEL CM-12 REMOTE CONTROL AIR CLEANER MODEL CM-12 CHECKOUT 3. Unit is properly oriented for good air circulation. Before leaving the installation, check to be sure that ASSEMBLY AND OPERATION the air cleaner is properly installed and operates 1.

  • Page 12: Maintenance

    MAINTENANCE furniture and walls off-gassing from previous exposure to higher levels of contamination. CAUTION! Please note that your air cleaner is equipped with a 3- speed control switch. If you are running your unit on 1. The power must be shut off before servicing medium blower speed, you can increase the blower the filters.
  • Page 13 REPLACING THE ODOR/VAPOR FILTERS OF THE retaining bracket to the open position. At this CM-11/CM-12 DELUXE UNITS point, the module can be carefully lowered out of The deluxe EverClear™ Model CM-11 and the unit. MiracleAir® Model CM-12 come with two VOC filters that must be replaced on a periodic basis.

  • Page 14: Parts List And Diagram

    CM-11 PARTS LIST AND DIAGRAM PART PART DESCRIPTION NUMBER DESCRIPTION NUMBER Grille Assembly 05456 Capacitor 40120 Louver Assembly 05454 Prefilter 41147 Switch 3 Speed 10110 95% DOP Filter 41149 Motor Mount (Not Shown) 21645 85% ASHRAE Filter 41155 Hanger Bracket 21654 65% ASHRAE Filter 41154...
  • Page 15 CM-12 PARTS LIST AND DIAGRAM Item number Description Part number Cabinet 05512 Grille Assy 05519 Alum mesh prefilter 41194 Main Filter 41190 Motor Assy with Blower 05459 Louver Grille 21906 05527 Carbon Module, includes frame (two required) 07163 Disposable Filter Kit, includes 20 disposable filters, one req'd per unit Control Switch 07156...

  • Page 16: Certificate Of Warranty

    (“product”) fail to perform by reason of improper workmanship or material, Air Quality Engineering, Inc., (AQE) will, during the period of three (3) years from the date of original purchase either (i) replace the Product or (ii) provide all necessary parts to repair the Product, without charge.

This manual is also suitable for:

Miracleair cm-12

Table of Contents