1. Manuals
  2. Brands
  3. Monterey Manuals
  4. Boat
  5. Elite 27 Outboard
  6. Owner's manual

Monterey Elite 27 Outboard Owner's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Owner's Manual For The
Elite 27 Outboard and Elite 30 Outboard
Monterey Elite 27 Outboard
Monterey Elite 30 Outboard

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Elite 27 Outboard and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Monterey Elite 27 Outboard

Summary of Contents for Monterey Elite 27 Outboard

  • Page 1 Owner’s Manual For The Elite 27 Outboard and Elite 30 Outboard Monterey Elite 27 Outboard Monterey Elite 30 Outboard...
  • Page 3 Dear Valued Customer, Welcome to the Monterey Life! We would like to extend to you our “Thank You” for choosing a Monterey boat! You have made an investment in our product and we are confident you will enjoy many years of boating pleasure. Your new boat has been built to the standards set forth by the United States Coast Guard, the National Marine Manufacturers Associa- tion, and International ISO Standards.
  • Page 4 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 5: Table Of Contents

    TABLE OF CONTENTS TABLE OF CONTENTS WELCOME ......................... 3 SAFETY INFORMATION ......................9 BOAT INFORMATION ......................11 CERTIFICATIONS ......................12 INTRODUCTION & IMPORTANT INFORMATION ...............13 OWNER/OPERATOR INFORMATION ..................15 NEW BOAT DELIVERY ......................16 Chapter 1: SAFETY EQUIPMENT 1.1 General ........................17 1.2 Engine Alarm ......................17 1.3 Neutral Safety Switch ....................17 1.4 Engine Stop Switch .....................18 1.5 Required Safety Equipment ..................18...

  • Page 6: Welcome

    WELCOME TABLE OF CONTENTS Chapter 4: HELM CONTROL SYSTEMS 4.1 General ........................54 4.2 Engine Throttle and Shift Controls .................54 4.3 Engine Stop Switch .....................57 4.4 Neutral Safety Switch ....................57 4.5 Outboard Power Tilt and Trim ..................58 4.6 Steering System ......................59 4.7 Joystick Controls ......................60 4.8 Trim Tabs ........................61 4.9 Control Systems Maintenance ..................62...
  • Page 7 TABLE OF CONTENTS TABLE OF CONTENTS Chapter 10: EXTERIOR EQUIPMENT 10.1 Deck Equipment ......................92 10.2 Drum Windlass Assembly ...................95 10.3 Hull Equipment ......................96 10.4 Cockpit Equipment - All Models ...................99 10.5 Cockpit Features .....................100 10.6 Cockpit Equipment ....................102 Chapter 11: INTERIOR EQUIPMENT 11.1 Head Compartment ....................113 11.2 Marine Head Systems ....................114...
  • Page 8 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 9: Safety Information

    SAFETY INFORMATION Safety Cautions and Warnings Your Monterey owner’s manual has been written to include a number of safety instructions to assure the safe operation and maintenance of your boat. These instructions are in the form of DANGER, WARNING, and CAUTION statements. The following definitions apply:...
  • Page 10 SAFETY INFORMATION SAFETY INFORMATION STATE OF CALIFORNIA SAFETY REQUIREMENTS State of California Safety Requirements WARNING PROPOSITION 65 A WIDE VARIETY OF COMPONENTS USED ON THIS VESSEL CONTAIN OR EMIT CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER AND BIRTH DEFECTS AND OTHER REPRODUCTIVE HARM. EXAMPLES INCLUDE: •...

  • Page 11: Boat Information

    BOAT INFORMATION BOAT INFORMATION Please fill out the following information section and leave it in your Monterey owner’s manual. This information will be important for you and Monterey service personnel to know, if you may need to call them for technical assistance or service.

  • Page 12: Identification Numbers

    To be in compliance with European directives for recreational boats as published by the International Organization for Standardization (ISO) in effect at the time this boat was manufactured, we are providing the following information. Manufacturer: Name SEABRING MARINE INDUSTRIES, INC., d.b.a. Monterey Boats Address 1579 SW 18th St. Zip Code: Williston, FL...

  • Page 13: Introduction & Important Information

    Warranty and Warranty Registration Cards The Monterey Limited Warranty Statement is posted on the Monterey Boats website in the “For Own- It is essential that we have your warranty ers” section. https://www.montereyboats.com/ registration card complete with your name...
  • Page 14 All information, illustrations, and specifica- tions contained in this manual are based on the latest product information available at the time of publication. Monterey Boats reserves the right to make changes at any- time, without notice, in colors, materials, equipment, specifications, and models.

  • Page 15: Owner/Operator Information

    OWNER/OPERATOR INFORMATION OWNER/OPERATOR INFORMATION Registration and Numbering in reporting an accident. If you need additional information regarding accident reporting, please Federal law requires that all vessels equipped with call the Boating Safety Hotline, 800-368-5647. propulsion machinery be registered in the State of principal use.

  • Page 16: New Boat Delivery

    Monterey Boats for filing with your boat’s construction records. At the time of new boat delivery, your Monterey Dealer will ask you to sign the completed Inspection Report along with the Warranty Registrations for the boat and other accessory equipment. By signing these documents, you acknowledge that you have reviewed and understand all information.

  • Page 17: Safety Equipment

    If there is a problem with one of these systems, Control adjustments may be required to correct it will sound an alarm until the problem is found this condition should it persist. See your Monterey and resolved. dealer for necessary control adjustments. Please refer to the Helm Control Systems chapter for more information on the neutral safety switch.

  • Page 18: Engine Stop Switch

    All Besides the equipment installed on your boat by Monterey boats must be equipped with at least Monterey, certain other equipment is required by one Type I, II or III PFD for each person on board, the U.S.

  • Page 19: Bilge And Fuel Fires

    Safety Equipment Safety Equipment • Launchers for aerial red meteors or parachute the U.S. Coast Guard at the time of manufacture. flares. It is up to you to make sure they are operational and turned on when required. WARNING Fire Extinguishers It is required that you carry at least two 5B:C portable fire extinguishers.

  • Page 20: Portable Extinguishers

    Recommended Portable Extinguisher Locations For Recommended Portable Extinguisher Locations For OF YOUR PASSENGERS, THE INTENSITY OF THE FIRE AND Monterey Boats Are Marked With This ISO Symbol Monterey Boats Are Marked With This ISO Symbol THE POSSIBILITY OF AN EXPLOSION IN YOUR DECISION.

  • Page 21: First Aid

    Safety Equipment Safety Equipment Drug or alcohol use increases the effect of CO supplies in your first-aid kit. Replace old supplies exposure. Individuals with cardiac or respiratory whether they have been used or not. conditions are very susceptible to the dangers of carbon monoxide.
  • Page 22 Safety Equipment Safety Equipment Additional Equipment to Consider: Cell Phone Fenders Rear View Mirror First Aid Kit Tool Kit Flashlight & Batteries Anchor Search light Boat Hook Sunburn Lotion Mooring Lines Ring Buoy Binoculars Extra Clothing Portable Radio Marine Hardware Chart and Compass Spare Keys Sunglasses...

  • Page 23: Caution & Warning Labels

    Immediately contact your dealer or The actual labels and their location could vary on Monterey Customer Service for a replacement. your boat. Elite 30 Outboard Warning Labels and Portable Extinguisher Locations CAUTION...
  • Page 24 Safety Equipment Elite 27 Outboard Warning Labels And Portable Extinguisher Locations CAUTION TO AVOID INJURY, DOOR MUST BE SECURED IN A CLOSED AND LOCKED POSITION WHEN BOAT IS UNDERWAY. DANGER ROTATING PROPELLER WILL CAUSE SERIOUS INJURY OR DEATH. SHUT OFF ENGINE WHEN NEAR PERSONS IN THE WATER.

  • Page 25: General

    OPERATION OPERATION 2.1 General in accordance with the sea conditions, boat traffic Before you start the engine(s) on your Monterey, and weather conditions. you should become familiar with the various component systems and their operation and per- Remember, it is the operator’s responsibility formed a “Precruise System Check.”...

  • Page 26: Operation

    Operation Operation Overtaking Situations When one motor boat is overtaking another mo- tor boat, the boat that is being passed has the right of way. The overtaking boat must make the adjustments necessary to provide clearance for a safe passage of the other vessel. The boats should sound the appropriate signals.
  • Page 27 Operation Operation...

  • Page 28: Pre-Cruise Check

    Operation Operation • Check the bilge water level. Look for other NOTICE: signs of potential problems. Monitor for the Storms and wave action can cause buoys to scent of fuel fumes. move. You should not rely on buoys alone • Test the automatic and manual bilge pump to determine your position.

  • Page 29: Operating Your Boat

    Operation Operation • Alcohol makes it difficult to correctly judge • Recommended spare parts to have on board: speed and distance, or track moving objects. Extra light bulbs Spark plugs Fuses and Circuit breakers Main 12 volt fuses Assorted stainless screws •...

  • Page 30: Single Engine Docking, Anchoring & Mooring

    Operation Operation After Operation: • Your Monterey is a heavy boat that will pro- • If operating in saltwater, wash the boat and all duce a large wake at certain speeds. You are equipment with soap and water. responsible for any damage and injury caused by your boat’s wake.
  • Page 31 Operation Operation Dock lines are generally twisted or braided nylon. Nylon is strong and stretches to absorb shock. It also has a long life and is soft and easy on the hands. The line’s size will vary with the size of the boat.

  • Page 32: Twin Engine Docking, Anchoring & Mooring

    Operation Operation Leaving the Dock Always start the engine and let it warm up for several minutes before releasing the lines. Boats WARNING steer from the stern and it is important that you achieve enough clearance at the stern to maneu- ver the boat as quickly as possible.
  • Page 33 Operation Operation Maneuvering to the Dock Approach the dock slowly at a 30 to 40 degree angle. Whenever possible, approach against the After Bow Spring Cleat wind or current. Turn the outdrives straight & shift Stern Cleat to neutral when you feel you have enough momen- Bow Cleat tum to reach the dock.

  • Page 34: Controls, Steering Or Propulsion System Failure

    Operation Operation crew member on the bow to retrieve the mooring with a boat hook and secure the line. Keep the 2.7 Controls, Steering or engines running until the line is secured. Propulsion System Failure Leaving a Mooring If the propulsion, control or steering system fails Start the engines and let them warm up for sev- while you are operating the boat, bring the throttle eral minutes before releasing the mooring line.

  • Page 35: Flooding Or Capsizing

    THE MOORING CLEATS, SKI TOW FITTINGS, WAKEBOARD rather than just a group of people in the water. If TOWERS AND ARCHES ON MONTEREY BOATS ARE NOT your boat is equipped with an EPIRB, make sure it DESIGNED OR INTENDED TO BE USED FOR TOWING is activated.
  • Page 36 Operation Operation before pulling a skier. The driver should also know the skier’s ability and drive accordingly. Always use high quality tow ropes with attach- ment loops when pulling wakeboarders or skiers and only attach the tow rope to the hardtop tower. Never use mooring cleats or grab rails to pull ski- ers.

  • Page 37: Wake/Teak Surfing

    Operation Operation 2.13 Wake/Teak Surfing • When turning around to pick up a fallen skier, make sure to look for other boat traffic in the Wake or Teak Surfing is a dangerous boating fad direction of the turn before you turn the boat. that involves an individual holding on to the swim platform of a vessel while a wake builds up then •...

  • Page 38: Man Overboard

    Operation Operation WARNING • Always make sure to slowly pull the slack out of the ski rope and wait for the OK from the skier before advancing MOVING PROPELLERS ARE DANGEROUS. THEY CAN the throttle to ensure the rope is not wrapped around CAUSE DEATH, LOSS OF LIMBS, OR OTHER SEVERE IN- the skier and that the skier is ready.

  • Page 39: Trash Disposal

    26 feet in the aft storage compartment hatch. It is the boat owner’s responsibility to make sure this placard length, consequently your Monterey Elite boat is equipped with a Yactht Certification Plate. remains mounted and legible in accordance with the law.
  • Page 40 HULL. HULL DAMAGE RESULTING FROM IMPROPER TRAILER motor, and equipment. The gross vehicle SUPPORT IS NOT COVERED BY THE MONTEREY WARRANTY. weight rating must be shown on the trailer. Make sure the weight of the boat, engine, gear, fuel and trailer is not more than the gross...
  • Page 41 Operation Operation Before Going Out On The Highway: • Check the brakes. On a level parking area roll • Side curtains, clear connector, and aft curtain forward and apply the brakes several times at must be removed when trailering. Canvas increasing speeds to determine if the brakes enclosures are not designed to withstand the on the tow vehicle and trailer are working...
  • Page 42 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 43: Propulsion System

    If the boat is to be left in saltwater, the hull and lower unit must be protected with antifouling paint. It is extremely important that the proper antifouling paint is used on each component. Contact your Monterey...

  • Page 44: Engine Lubrication

    T O P R O T E C T T H E L O W E R U N I T F R O M G A LVA N I C well. Large four-stroke outboards include a fuel/water CORROSION. CONTACT THE ENGINE MANUFACTURER OR YOUR MONTEREY DEALER FOR THE PROPER ANODE TO separator filter in the bilge area of the boat. This can USE IN YOUR BOATING AREA.

  • Page 45: Engine Cooling System

    Propulsion System Propulsion System 3.4 Engine Cooling System Outboard engines are raw water (seawater) cooled. Water is pumped through the water inlets, circulated through the engine block, and relin- quished with the exhaust gases through the pro- peller hub. expelled through the exhaust system. In most outboard motors, some cooling water is diverted through ports below the engine cowling.

  • Page 46: Helm And Engine Instrumentation

    Your boat was shipped to the dealership with the propeller(s). propellers that provide optimum performance for your boat according to Monterey factory testing. There are a number of factors that can affect Some or all of the following data could be performance and propeller requirements.

  • Page 47: Temperature Gauge

    Propulsion System Propulsion System Elite 30 Outboard Helm With Dual Controls CAUTION CONTINUED OPERATION OF AN OVERHEATED ENGINE CAUTION CAN RESULT IN ENGINE SEIZURE. IF AN UNUSUALLY HIGH TEMPERATURE READING OCCURS, SHUT THE ENGINE OFF IMMEDIATELY. THEN INVESTIGATE AND CORRECT THE MAINTAINING MAXIMUM, OR CLOSE TO MAXIMUM RPM PROBLEM.
  • Page 48 Propulsion System Gauges/Controls Propulsion System Gauges/Controls Full Screen Display With Gauges Centered, Switches On Both Sides (Display Can Be Modified Per Customer Preference) Vertical Split Screen, Switch Icon Parked On The Left, Critical Switches Displayed Above The Gauges Vertical Split Screen, Depth/Sonar Screen Added...

  • Page 49: Instrument Maintenance

    Propulsion System Propulsion System indication of the available fuel supply and not a calibrated instrument. Trim angles, positioning of passengers and gear are some of the things that can affect the fuel gauge reading. Voltmeter The voltmeter displays the voltage for the battery and the charging system.
  • Page 50 Propulsion System Gauges/Controls Propulsion System Gauges/Controls Click Here to Create A New Split Screen View Drag Desired Apps Onto the Display Click “Save”...
  • Page 51 Propulsion System Gauges/Controls Propulsion System Gauges/Controls New Horizontal Split Screen Poco Menu For Customizing Light Colors Color and Brightness Menu...
  • Page 52 Propulsion System Gauges/Controls Propulsion System Gauges/Controls Other Apps Available For Viewing on the Digital Display C-Zone Remote Fob, Controls Battery Switches and Lighting...
  • Page 53 Propulsion System Propulsion System Gauges/Controls Remote Fob Standard equpment on the E30 includes a remote C-Zone fob that controls battery switches for the engine and house batteries (Smart Battery Hub). The fob also controls accent lighting in the cockpit and hardtop. The fob’s range is over 50 feet, so you can switch on your batteries and lighting before boarding at night.
  • Page 54 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 55: Helm Control Systems

    Single Engine Controls boat weight, etc will require re-programming by a certified Mercury technician. Please see your dealer or the Monterey Customer Service Depart- ment for details. 4.2 Engine Throttle and Shift Controls The shift and throttle controls on your boat may vary depending on the engine options.
  • Page 56 Helm Control Systems Helm Control Systems • Active trim, provides optimal running attitude Switches built into the control or control handle are while on plane and enables automatic adjust- used by the operator to select available features. ment for weight distribution. The most common features activated by control These features and others require specific pro- switches are:...
  • Page 57 Helm Control Systems Helm Control Systems Helm Control Systems MONTEREY BOATS CAUTION ALWAYS RETURN THE ENGINE THROTTLE LEVER TO THE NEUTRAL POSITION BEFORE SHIFTING. NEVER SHIFT THE UNIT WHILE ENGINE SPEED IS ABOVE IDLE RPM. Twin Engine Electronic Engine Controls The following control description is typical of most electronic control installations.

  • Page 58: Engine Stop Switch

    If the starter engages with the control levers in any tem adjustments may be required to correct this position other than the neutral position, then the condition, should it persist. See your Monterey neutral safety switch is not functioning properly dealer for necessary control adjustments.

  • Page 59: Outboard Power Tilt And Trim

    Helm Control Systems Helm Control Systems 4.5 Outboard Power Tilt and Trim /Active Trim All outboard controls have a tilt and trim feature. This allows the operator to adjust the position of each engine from the helm. Moving the engine closer to the boat transom is called trimming “in”...

  • Page 60: Steering System

    The maximum trim angle for the outboard engines is preset at the factory. If necessary, the maximum trim angle can be adjusted by your Monterey dealer. WARNING EXCESSIVE TRIM FOR THE OPERATING CONDITIONS, EITHER TRIM UP OR DOWN, CAN CAUSE BOAT INSTABILITY, PROPELLER CAVITATION, OR MAKE STEERING THE BOAT MORE DIFFICULT.

  • Page 61: Joystick Controls

    Helm Control Systems Helm Control Systems Twin Engine Electronic Steering Twin engine boats equipped with the joystick con- trol option are equipped with an electronic steer- ing system that provides precise and responsive steering. The system is 100% electronic and there are no mechanical connections between the steering wheel and the engines.

  • Page 62: Trim Tabs

    Helm Control Systems Helm Control Systems Helm Control Systems by pressing the ON/OFF button at the base of the joystick or by moving the shift and throttle control levers. Joystick control systems are 100% electronic. Always refer to the engine manufacturer owner’s manuals for specific information on the operation and maintenance for the joy- stick and steering control systems.

  • Page 63: Control Systems Maintenance

    Control system adjustments may become neces- ing fluid, excessive wear, or deterioration should sary. If adjustment becomes necessary, see your be corrected immediately. The transom area in Monterey dealer. the bilge should be regularly checked for leakage around fuel filters or hydraulic lines. WARNING...
  • Page 64 DO NOT ATTEMPT ADJUSTMENTS YOURSELF. CONTACT to be changed when they are 75% of their original YOUR DEALER OR MONTEREY CUSTOMER SERVICE DE- size. Refer to the Routine Maintenance chapter of PARTMENT FOR ASSISTANCE. DO NOT USE THE BOAT UNTIL THE SITUATION IS CORRECTED.

  • Page 65: Fuel System

    Chapter 5: FUEL SYSTEM FUEL SYSTEM 5.1 General The gasoline fuel system used in Monterey boats is designed to meet or exceed the emission con- trol standards established bythe Environmental Protection Agency (EPA), the California Air Re- sources Board (CARB), American Boat and Yacht Council(ABYC) and the U.S.

  • Page 66: Fuel Filter

    AND WASTE PUMPS ARE NOT DESIGNED TO PUMP FUEL changed as recommended by the engine manu- AND A FIRE OR EXPLOSION COULD RESULT. CONTACT YOUR DEALER OR THE MONTEREY CUSTOMER SERVICE facturer to assure an adequate supply of clean, DEPARTMENT FOR ASSISTANCE IN HAVING THE FUEL dry fuel to the engine.

  • Page 67: Fueling Instructions

    Fuel System Fuel System 5.3 Fueling Instructions All Monterey boats are built with fuel systems designed to meet emission control standards established by the U.S. Environmental Protection Agency and the Californial Air Resources Board (CARB). DANGER FUEL IS VERY FLAMMABLE AND THE VAPORS CAN EXPLODE.

  • Page 68: Fuel System Maintenance

    • Make sure the nozzle is equipped with an dealer or Monterey customer service. automatic shutoff valve, then put the nozzle in the fuel fill opening and make sure it stays Frequently inspect and lubricate the fuel fill cap in contact with the fuel fill fitting during the O-ring seal with silicone-based grease.
  • Page 69 Fuel System Fuel System WARNING LEAKING FUEL IS DANGEROUS AND CAN CAUSE A FIRE AND/ OR EXPLOSION. DO NOT DRAIN ANY FUEL INTO THE BILGE. AFTER THE FILTER ELEMENT HAS BEEN CHANGED, PRIME THE FUEL SYSTEM AND CHECK ALL FITTINGS FOR LEAKS BEFORE AND AFTER STARTING THE ENGINE FOLLOWING ANY FUEL SYSTEM SERVICE.
  • Page 70 Fuel System THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 71: Electrical System

    ELECTRICAL SYSTEM 6.1 General 6.2 Single Engine Battery Systems Your Monterey is equipped with a 12 volt DC elec- The 12 volt electrical system on single engine trical system and a 120 volt AC battery charging boats is a standard marine system. One start system.

  • Page 72: Twin Engine Battery Systems

    Electrical System Electrical System Always consult your dealer before changing the type of batteries in your boat or if you questions regarding the batteries. 6.3 Twin Engine Battery Systems 6.3 Twin Engine Battery Systems The Elite 30 Outboard model has 3 batteries and The Elite 30 Outboard model has 3 batteries and five battery switches including a s five battery switches including a switch for each...

  • Page 73: Volt Accessory Switch Panels

    Electrical System Electrical System 6.4 12 volt Accessory Switch Panels The main accessory switch panel is located on the port helm of the E27 and E30. The engine key switch(es) are located in the console beneath the armrest of the E30 and on the aft face of the E27 console.

  • Page 74: Ignition Switch

    Electrical System Electrical System Ignition Switch Each ignition switch is a separate, key activated switch, located inside the armrest of the Elite 30 model and on the aft face of the Elite 27 console. To start the engine(s), make sure the engine is down and your hand is on the engine control handle in the neutral position.
  • Page 75 Electrical System Electrical System NOTICE: The bilge pumps will start automatically when there is sufficient water in the bilge to acti- vate the automatic water level switch con- nected to each pump. The automatic switch is protected by a circuit breaker located in the battery switch panel and is always supplied current when the batteries are connected.
  • Page 76 Electrical System Electrical System Bow and Stern Stereo Remotes Located in the aft cockpit and bow seating areas. They are battery powered bluetooth touch pads that control the volume, fast forward,pause and source functions. Refer to the stereo owner’s manual for details on operating the stereo remote control pads.

  • Page 77: Circuit Breaker Panel

    Electrical System Electrical System Elite DDS Module and Breaker Panel In Head 6.5 Circuit Breaker Panel 6.5 Circuit Breaker Panel Power is distributed to most of the 12 volt accessories through individual circuit breakers located in the DC breaker panel. The following is a description of circuit breaker panels and the accessories they control.
  • Page 78 Electrical System Electrical System Amplifier A “push to reset” circuit breaker that provides pro- tection and power for the stereo amplifier for the boat speaker system. This breaker is supplied cur- rent when the battery selector switch is activated. Bilge Pump Provides protection and power for the automatic float switch on the aft bilge pump.

  • Page 79: Ac Battery Charging System

    Electrical System Electrical System Electronics WARNING Provides protection and electrical current directly to the electronics in the helm. IN THE EVENT OF A CHARGER MALFUNCTION, DO NOT AT- Accessory TEMPT TO CORRECT THE WIRING YOURSELF. ELECTRIC Reserved for additional 12 volt equipment. SHOCK CAN CAUSE SEVERE INJURY OR EVEN DEATH.

  • Page 80: Bonding System

    Electrical System Electrical System 6.9 Bonding System Your boat is equipped with a bonding system that interconnects all underwater metal hardware and thru-hull fittings to ensure that they are of the same electrical potential. Anodes are attached to the bonding system at the transom plates, trim tab planes and lower unit(s).
  • Page 81 Electrical System Electrical System WARNING CORROSION ALLOWED TO BUILD ON THE ELECTRICAL C O N N E C TO R S C A N C AU S E A P O O R C O N N E C T I O N RESULTING IN SHORTS, GROUND FAULTS OR POOR GROUND CONNECTIONS.
  • Page 82 Electrical System Electrical System Windlass Circuit Breaker Forward Bow Circuit Breaker Panel And Battery Switches Head Compartment Smart Battery Switch Hub And TVM, Bilge Compartment...
  • Page 83 Electrical System Electrical System Optional Air Inflator Waterproof/Wireless Charger Battery Charger Deck Inlet Fitting...
  • Page 84 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 85: Fresh Water System Maintenance

    DO NOT ATTEMPT TO PUMP IT OUT YOURSELF. CONTACT DO NOT ALLOW THE FRESH WATER PUMP TO RUN DRY. THE YOUR DEALER OR THE MONTEREY BOATS CUSTOMER FRESH WATER PUMP WORKS ON DEMAND AND WILL NOT SERVICE DEPARTMENT FOR ASSISTANCE IN HAVING THE SHUT OFF AUTOMATICALLY WHEN THE TANK IS EMPTY.
  • Page 86 Fresh Water System Fresh Water System • Activate the system and allow the water to run • Periodically remove the lid on the shower sump for about one minute at each faucet. Let the assembly. Clean debris from the sump and treated water stand for 4-6 hours.

  • Page 87: Fresh Water System Components

    Fresh Water System Fresh Water System 7.4 Fresh Water System Components Elite 30 Fresh Water Fill Behind Passenger Helm Seat E30 Starboard Cockpit Washdown E30 Wetbar Sink Transom Shower/Washdown STRAINER Head Sink w/ Shower Head Typical Water Pump & Strainer...
  • Page 88 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 89: Drainage Systems

    Chapter 8: Chapter 8: DRAINAGE SYSTEMS DRAINAGE SYSTEMS 8.1 General Most water in the cockpit area is drained by gravity to the bilge and where it is pumped over- board by the bilge pump. The gutters around aft hatch/compartment openings drain by gravity to overboard thru-hull fittings in the hull sides.

  • Page 90: Cockpit And Deck Drains

    Drainage Systems Drainage Systems pump automatic switch. The alarm is connected to the house battery and is protected by the emer- gency pump “push to reset” breaker located in the engine compartment breaker panel. It remains activated when the battery switches are in the “OFF”...

  • Page 91: Head Compartment Drains

    Drainage Systems Drainage Systems with a gutter system that drains the water to thru- hull fittings in the transom. Wet Bar Sink Drains The wet bar sink and refrigerator are drained by gravity to a thru-hull fitting in the hull side. Storage compartments are drained to the cock- pit.
  • Page 92 Drainage Systems Drainage Systems • Flush all gravity drains with fresh water to keep them clean and free flowing. • Clean and inspect the shower and drain sump system. Remove accumulated debris and flush with fresh water. • If your boat is equipped with the optional grey water system, periodically clean and inspect the drain sump system.

  • Page 93: Head Compartment Ventilation

    Chapter 9: Chapter 9: VENTILATION SYSTEM VENTILATION 9.1 Head Compartment Ventilation Ventilation to the head compartment is provided by port windows on the port and starboard sides of the console. Each window opens to provide ventilation into the area and is equipped with a removable screen.

  • Page 94: Ventilation System

    Ventilation System Ventilation System Ventilation System 9.2 Carbon Monoxide & Extreme caution must be taken while at anchor or Proper Ventilation in a slip when an auxiliary power generator is operating in nearby boats. Nights where the wind is still can easily allow exhaust fumes, containing high concentrations of CO, from the generator an CAUTION adjacent boat’s generatorto enter your boat.

  • Page 95: Exterior Equipment

    Any problems should be corrected immediately. WARNING MONTEREY BOATS ARE NOT EQUIPPED WITH HARDWARE DESIGNED FOR TOWING PURPOSES. THE MOORING CLEATS ARE NOT TO BE USED FOR TOWING ANOTHER VESSEL OR HAVING THIS BOAT TOWED.

  • Page 96: Drum Windlass Assembly

    IS STORED IN THE ANCHOR LOCKER. DAMAGE RESULTING FROM THE ANCHOR BOUNCING IN THE ANCHOR LOCKER IS NOT COVERED BY THE MONTEREY WARRANTY. Periodically remove the anchor line from the locker, rinse it with fresh water and allow it to dry in the sun.
  • Page 97 Exterior Equipment Exterior Equipment Exterior Equipment removing the center bow cushion. The compart- ment also houses the windlass breaker. To secure the anchor in the up and stored position, raise the anchor until it seats firmly in the hull stem with the chain snug.
  • Page 98 Exterior Equipment Exterior Equipment Exterior Equipment is especially important while the boat is underway. A partially lowered and loose anchor can cause considerable damage to the hull. Do not use a windlass as a sole means of securing an anchor. The windlass manufacturer provides an owner’s manual with its product.

  • Page 99: Hull Equipment

    Exterior Equipment Exterior Equipment Exterior Equipment 10.3 Hull Equipment Swim Platform and Stern Ladder Your boat is equipped with an integral, fiber- glass swim platform located at the stern of the boat. The standard swim platform is equipped with a gelcoat non-skid surface. A synthetic teak (SeaDek) inlay is optional.

  • Page 100: Docking Lights

    Exterior Equipment Exterior Equipment Exterior Equipment Elite 27 & 30 Stern Compartments A large storage compartment is located below the the aft sunpad. The compartment drains to thru- hull fittings in the hull side and is equipped with “dry deck” padding to allow for better drainage and air circulation in the compartment.

  • Page 101: Cockpit Equipment

    Exterior Equipment Exterior Equipment Exterior Equipment Elite 30 Aft Sunpad Compartments 10.4 Cockpit Equipment Hatch Latches Some of the hatches and doors in the cockpit are secured with special flush mounted, twist lock latches with handles that store flush in the latch. Others are secured with push to close latches.
  • Page 102 Exterior Equipment Exterior Equipment Exterior Equipment WARNING IN CERTAIN CONDITIONS, OPEN DOORS AND HATCHES THAT ARE NOT SECURED PROPERLY CAN SLAM CLOSED UNEXPECTEDLY WHILE UNDERWAY AND CAUSE INJURY TO PASSENGERS OR DAMAGE TO THE BOAT. MOST DOORS AND HATCHES ARE EQUIPPED WITH GAS SPRINGS OR SPECIALIZED HINGES TO SECURE THEM IN THE OPEN POSITION.

  • Page 103: Cockpit Features

    Exterior Equipment Exterior Equipment Exterior Equipment 10.5 Cockpit Features Side Storage Compartments There are are storage compartments on both sides of the cockpit below the gunnels. They provide storage for lines or small items. There are also drink holders conveniently located near all seat- ing areas.
  • Page 104 Exterior Equipment Exterior Equipment Exterior Equipment and push it back above the seat cushion. The helm and passenger seats adjust fore and aft. Lifting the lever located at the front of the seat base allows the seat to be adjusted fore and aft. The standard helm seats on the Elite 27 model are equipped with a swivel feature that allows them to rotate to an aft-facing arrangement.

  • Page 105: Transom Door

    Exterior Equipment Exterior Equipment Exterior Equipment each seat cushion that house carry-on coolers. All bow storage compartments drain to the bilge. The side seat cushions are secured with gas springs that allow the them to be pulled upward and remain open for access to the coolers below. The area is illuminated by LED courtesy lights recessed into the seat bases.
  • Page 106 Exterior Equipment Exterior Equipment Exterior Equipment position. To close, swing the door back until it latches onto the magnet in the deck coaming. This will open the walkway for access to the swim platform and engine(s). The walkway to the swim platform should be open only when the boat is not in motion.
  • Page 107 Exterior Equipment Exterior Equipment Exterior Equipment storage areas beside the port and starboard bow cushions as well as storage compartments behind the bow backrests. WARNING DO NOT STORE FUEL OR FLAMMABLE LIQUIDS IN THE TRANSOM STORAGE COMPARTMENT. VENTILATION WAS NOT PROVIDED FOR EXPLOSIVE VAPORS.
  • Page 108 Exterior Equipment Exterior Equipment Exterior Equipment senger by the motion of the boat if it is allowed to senger by the motion of the boat if it is allowed to swing free. It should be in the closed position and swing free.
  • Page 109 10.8 Canvas Options The canvas for Monterey boats is custom fit to each boat. An optional bow cover protects the seats and equipment forward of the windshield.

  • Page 110: Aftermarket Arch

    Monterey Limited Warranty. Additionally, Monterey will not be responsible for any damage resulting from the installation of a fabrication not installed at the Monterey factory. If you intend to install an aftermarket hardtop or arch on your boat, please contact your authorized Monterey dealer.
  • Page 111 Exterior Equipment Exterior Equipment E27 Sunpad Bolsters Facing Aft 298SS Engine Hatch E30 Trash Receptacle in The Wetbar E27 Helm and Controls E27 Aft Sunpad E27 Wetbar and Aft Cockpit Seating...
  • Page 112 Exterior Equipment Exterior Equipment Exterior Equipment 11.9 Optional Air Inflator System Your boat may be equipped with an optional air inflator system for water toys and other inflatable items. The inflator has the ability to inflate to a pre-specified target pressure, so it is important to always know the capacity of the item you are connecting to the system.
  • Page 113 Chapter 12: Exterior Equipment Exterior Equipment Exterior Equipment 298SS Helm Seat With Bolster Down Elite 30 Wetbar Fold Away Towel Rack Elite 27/30 Battery Charger Deck Plug Elite 27/30 Head Door, Forward Bow Elite 30 Key Switches in Armrest Compartment...
  • Page 114 Exterior Equipment Exterior Equipment Exterior Equipment USB Charging Port and Aft Cockpit Bluetooth Stereo Remote Bow Storage Compartment With Drop-In Cooler Forward Bow Floor Storage...
  • Page 115 Exterior Equipment Exterior Equipment Exterior Equipment E30 With Optional Bow and Aft Shades Hardtop/Windshiled Frame Assembly...
  • Page 116 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 117: Interior Equipment

    INTERIOR EQUIPMENT Chapter 11: Chapter 11: INTERIOR EQUIPMENT 11.1 Head Compartment Head Compartment The E27 and E30 models are equipped with a head compartment. The compartment is equipped with a sink that has a retractable water hose and spray handle. These models have cold water showers and the compartment drains to the bilge.

  • Page 118: Marine Head Systems

    Interior Equipment Interior Equipment Interior Equipment 11.2 Marine Head Systems Portable Head System The portable head is standard on the Elite 27 Outboard. The system is made up of two major components, an upper tank and a lower tank. The upper tank contains the fresh water supply, a bellows pump, a seat and the lid.
  • Page 119 Interior Equipment Interior Equipment Interior Equipment the Elite 30 model. The toilet is connected to the pressurized fresh water system which results in less odor in the head compartment. It has an automatic pumping device that fills and empties the bowl. To activate the system, push the “fill” button on the control panel.
  • Page 120 Interior Equipment Interior Equipment Interior Equipment is pumped. Release the switch and to turn off the Head System Maintenance discharge pump when pumping is complete, then The head should be cleaned and inspected for close the seacock at the thru-hull fitting. leaks regularly.

  • Page 121: Routine Maintenance

    DESIGNED FOR USE WITH OUTBOARD MOTORS. ALWAYS LEAVE A ONE INCH BARRIER BETWEEN THE HULL BOTTOM PAINT AND ENGINE. Your Monterey hull is manufactured using state- of-the-art materials and processes. A layer of resin with high density and superior adhesion Most bottom paints require some maintenance.
  • Page 122 Routine Maintenance Routine Maintenance Routine Maintenance The anodes are less noble than copper based alloys, aluminum, cast iron and stainless steel. They will deteriorate first, protecting the more noble engine and underwater hardware against galvanic corrosion. Anodes should be checked monthly and changed when they are 75% of their original size.
  • Page 123 Routine Maintenance Routine Maintenance Routine Maintenance Fiberglass Gelcoat Surfaces apply wax and polish all fiberglass surfaces except • Keep the gelcoat surfaces out of direct sunlight the nonskid areas. or covered when boat is not in use. If the fiberglass should become damaged and need repair, contact your dealer for an authorized •...
  • Page 124 Routine Maintenance Routine Maintenance Routine Maintenance GEMLUX MAINTENANCE INSTRUCTIONS Cleaning Agents Method Comments Apply with a sponge Once your stainless is Routine Cleaning Soap and Water or soft cloth. Dry area free of discoloration completely. and/or bleeding, spray GEMLUX Passivation S o l u t i o n d i r e c t l y onto stainless.
  • Page 125 With proper care, anodized alumi- frame. You should also contact Monterey Boats num will provide many years of service. Customer Service...

  • Page 126: Upholstery, Canvas And Enclosures

    Routine Maintenance Routine Maintenance Routine Maintenance Chrome Hardware • Do not use masking tapes, duct tapes or pack- ing tapes on your acrylic materials. Use a good chrome cleaner and polish on all chrome hardware. • Do not drill holes in your acrylic materials without proper drill bits (special bits are used Acrylic Plastic Glass in acrylic material to avoid damage).
  • Page 127 Routine Maintenance Routine Maintenance Routine Maintenance • Ballpoint Ink, Permanent Marker – Ink spots • Candy, ice cream, coffee, tea, fruit stains, will stain vinyl permanently. Immediate wiping liquor, wine, suntan lotion, soft drinks. - Use with rubbing alcohol in a well-ventilated area clear lukewarm water and a sponge repeatedly.
  • Page 128 Routine Maintenance Routine Maintenance Routine Maintenance Normal Care and Cleaning • Food grease and oily stains - Spray immedi- ately using either Fantastik Cleaner® or Tan- Remove ordinary dirt and smudges with a mild nery Car Care Cleaner®, wiping with a soft soap and water solution and a clean, soft cloth cloth.
  • Page 129 SINCE THESE SOLVENTS COULD SERIOUSLY DAMAGE available water proofing designed for this pur- THESE MATERIALS. pose. Monterey recommends 303 High Tech Fabric Guard. Stain Removal To apply waterproofing, wash the canvas and al- low it to dry completely. Then apply a thin, even If a spill does occur, it can easily be removed by following the stain removal chart.
  • Page 130 Your Monterey boat is basically an open ves- sel. Therefore, in spite of well-designed and glass and clear plastic protector to extend the life glass and clear plastic protector to extend the life of the curtains.

  • Page 131: Head Interior

    NEVER TRAILER YOUR BOAT WITH THE CANVAS ENCLOSURE contact your dealer or Monterey Customer Service (INCLUDING WEATHER CURTAINS, AFT CURTAIN, BOW for instructions.

  • Page 132: Drainage System

    10%. 12.5 Drainage System Do Not Use E-15 Fuel In Your Monterey Boat It is essential that the following items be done periodically to maintain proper drainage of your boat: •...

  • Page 133: Seasonal Maintenance

    Chapter 13: Chapter 13: Chapter 13: SEASONAL MAINTENANCE SEASONAL MAINTENANCE SEASONAL MAINTENANCE Lifting 13.1 Lay-up and Storage It is essential that care be used when lifting your Before Haul Out: boat. Make sure the spreader bar at each sling • Pump out the head and holding tank.
  • Page 134 SUPPORT FOR THE HULL. HULL DAMAGE RESULTING NOTICE: FROM IMPROPER CRADLE OR TRAILER SUPPORT IS NOT COVERED BY THE MONTEREY WARRANTY. It is recommended that a mildew preventer be hung in the head compartment before it is closed for storage.

  • Page 135: Winterizing

    NOTICE: mercially available non toxic, fresh water system Make sure you follow the marine toilet manu- antifreeze. (Your dealer or the Monterey Customer facturer’s winterizing instructions exactly. service department can recommend an appropri- ate potable antifreeze).

  • Page 136: Seasonal Maintenance

    Seasonal Maintenance Seasonal Maintenance Seasonal Maintenance tors and buss bars in the helm compartment with NOTICE: a protecting oil. Whether the boat is being stored indoors or outdoors, open all drawers, lockers, Clean the aluminum frame with soap and water cabinets, and hatches slightly.
  • Page 137 Seasonal Maintenance Seasonal Maintenance Seasonal Maintenance • Check all hose clamps for tightness. • Pump the antifreeze from the fresh water sys- tem and flush several times with fresh water. • Check and lubricate the steering system. • Clean and wash the boat. •...
  • Page 138 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 139: Appendix A: Maintenance Log

    Appendix A: Appendix A: MAINTENANCE LOG Maintenance Log Service/Repairs Date Dealer Hours...
  • Page 140 Maintenance Log Maintenance Log Maintenance Log Service/Repairs Date Dealer Hours...
  • Page 141 Maintenance Log Maintenance Log Maintenance Log Service/Repairs Date Dealer Hours...
  • Page 142 Maintenance Log Maintenance Log Maintenance Log Service/Repairs Date Hours Dealer...

  • Page 143: Appendix B: Float Plan

    Float Plan Monterey Boats recommends filling out a float plan each time you use your boat for an offshore day trip or a long cruise. Leave this information with a responsible person ashore, like a close friend or relative that you know well.
  • Page 144 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 145: Boating Accident Reporting

    Appendix C: Appendix C: BOATING ACCIDENT REPORTING Boating Accident Reporting Federal law requires the operator or owner of a recreational vessel to file a boating accident report with the State reporting authority if the recreational vessel is involved in an accident that results in any of the following: •...
  • Page 146 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 147: Appendix D: Glossary Of Terms

    Appendix D: Appendix D: GLOSSARY OF TERMS Glossary of Terms Boarding: Entering or climbing into a boat. baft – Behind you when you are facing forward Boarding Ladder: Set of steps temporarily fitted Active Trim: Automated GPS based trim system for over the side of a boat to assist persons coming maintaining optimum engine RPM at all speeds.
  • Page 148 Glossary of Terms Glossary of Terms Glossary of Terms Closed Cooling System: A separate supply of fresh water that is used to cool the engine and circulates only within the engine. Fender: A soft object of rubber or plastic used to protect the topsides from scarring and rubbing Coaming: The vertical deck surface around the against a dock or another vessel.
  • Page 149 Glossary of Terms Glossary of Terms Glossary of Terms Helm: The steering and control area of a boat. between signal pulses received from widely spaced radio transmitters. Hull: The part of the boat from the deck down. Lunch hook: A small light weight anchor typically nboard: A boat with the engine mounted within used instead of the working anchor.
  • Page 150 Glossary of Terms Glossary of Terms Glossary of Terms Porthole (port): The opening in the side of a boat Sheer: The uppermost edge of the hull. to allow the admittance of light and air. Sling: A strap which will hold the boat securely Propeller: A device having two or more blades that while being lifted, lowered, or carried.
  • Page 151 Glossary of Terms Glossary of Terms Glossary of Terms the boat. If you see a sign that says “No Wake Topsides: The side skin of a boat between the wa- Zone,” it’s telling you to proceed very slowly so terline or chine and deck. as not to create a large wake.
  • Page 152 CAUSE AND SOLUTION THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 153: Troubleshooting Guide

    Note: Always refer to the engine and other vendor manual(s) provided when diagnosing an issue. Repairs should always be performed by a trained dealer service professional. Repairs must also be pre-authorized by the Monterey Customer Service Department. Failure to follow this procedure could void your warranty.

  • Page 154: Engine Problems

    Troubleshooting Guide Troubleshooting Guide Troubleshooting Guide PROBLEM CAUSE & SOLUTION The boat vibrates at cruising speeds. • Propellers may be damaged & need repair. • A propeller or propeller shaft is bent. Repair or replace damaged components. • The running gear is fouled by marine growth or rope. Clean running gear.
  • Page 155 Troubleshooting Guide Troubleshooting Guide Troubleshooting Guide PROBLEM CAUSE & SOLUTION The fresh water pump switch is on but the pump fails to run. • The water system circuit breaker has tripped. Reset the circuit breaker. • •There is a loose or corroded wiring connection. Find and repair the bad connection •...
  • Page 156 Troubleshooting Guide Troubleshooting Guide Troubleshooting Guide PROBLEM CAUSE & SOLUTION The bilge pump will not run when the manual switch is • The circuit breaker supplying the switch has tripped. Replace activated. or reset the circuit breaker. • The battery switch is off. Turn on the battery switch and bilge pump breaker.

  • Page 157: Appendix F: Wiring Diagrams

    Appendix F: Appendix F: WIRING DIAGRAMS Wiring Diagrams...
  • Page 158 Wiring Diagrams Wiring Diagrams...
  • Page 159 Wiring Diagrams Wiring Diagrams...
  • Page 160 Wiring Diagrams Wiring Diagrams...
  • Page 161 Wiring Diagrams Wiring Diagrams...
  • Page 162 Wiring Diagrams Wiring Diagrams...
  • Page 163 Wiring Diagrams Wiring Diagrams...
  • Page 164 Wiring Diagrams Wiring Diagrams...
  • Page 165 Wiring Diagrams Wiring Diagrams...
  • Page 166 Wiring Diagrams Wiring Diagrams...
  • Page 167 Wiring Diagrams Wiring Diagrams...
  • Page 168 THIS PAGE WAS LEFT BLANK INTENTIONALLY...

  • Page 169: Appendix G: Specifications

    Appendix G: Appendix G: SPECIFICATIONS Specifications (2025) Elite 27 OB - EB Rev 2(6/19/24 BA) LOA w/Swim Platform 27'-8" 8.43 m Beam 8'10" 2.69 m 21° 21° Deadrise 18" 45.7 cm Draft - Engine Up 36" 91.4 cm Draft - Engine Down Bridge Clearance w/ Hardtop 8' 4"...
  • Page 170 Specifications Specifications...
  • Page 171 Specifications Specifications Specifications (2025) Elite 30 OB - ED Rev 2, 6/19/24 (BA) LOA w/Engines 32' 6" 9.93 m LOA w/Swim Platform 30' 0" 9.14m Beam 9'-10" 2.99 m Deadrise 21° 21° Draft - Engine Up 23" 58.4 cm Draft - Engine Down 32"...
  • Page 172 Specifications Specifications...
  • Page 174 MONTEREY BOATS 1579 S.W. 18th Street Williston, FL 32696 Phone 352-529-9181 Fax 352-529-9173 www.montereyboats.com P/N 63106700-00-MANU Rev. 10/15/24...

This manual is also suitable for:

Elite 30 outboard

Table of Contents