Subscribe to Our Youtube Channel
Related Manuals for Smittybilt SB61449DW-PW
Summary of Contents for Smittybilt SB61449DW-PW
- Page 1 Installation Instructions Toyota Tacoma Swing Gates Part # S/B61449DW-PW For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
-
Page 2: Tools Required
Introduction Thank you for choosing Smittybilt accessories for your Toyota Tacoma. If you would like to view our full range of available accessories, please visit us at www.smittybilt.com Toyota® and Tacoma® are registered trademarks of Toyota Motor Corporation. Important Notes Before Starting Carefully read through this entire instruction manual thoroughly before attempting to install this part. -
Page 3: Box Contents
FRAME TERTIARY BRACKET - DRIVER 1040AASG800 SWING GATE PIN 1040AASG1600 HINGE COVER PLATE 1040AASG1700 OVERLAND TABLE 1040AASG2000 BRASS PRESS-IN BUSHING For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW... - Page 4 FRAME TERTIARY BRACKET - PASSENGER 1040AASG800 SWING GATE PIN 1040AASG1600 HINGE COVER PLATE 1040AASG1700 OVERLAND TABLE 1040AASG2000 BRASS PRESS-IN BUSHING For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 5 90-1040AASG2400 OVERLAND TABLE FOAM COMPRESSION PAD 94645A205 M6X1 NYLOCK GR10.9 CZ 91166A250 M6 FLAT WASHER CZ For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
-
Page 6: Important Note
Step 1: Remove Tacoma Rear Bumper (if installed) If SmittyBilt Tacoma Rear Bumper is installed on vehicle, remove and place on a working surface.Refer to SB61448 Tacoma Rear Bumper Instructions for removal. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com... - Page 7 Torque of these nuts is not critical. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 8 Studs IMPORTANT NOTE Wear Pads Refer to page 16 for Torque Specifications. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 9 (f) using a 4mm Hex Bit Socket, and slide the plastic corner cover off the bumper. If your Smittybilt bumper is equipped with Blind Spot sen- IMPORTANT NOTE sors, the sensors and brackets will have to be removed.
- Page 10 (l) securing the outside corner section of the hitch receiver to the frame. IMPORTANT NOTE Set bolts aside for re-use later. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 11 (Continued next page) For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 12 4X bolts to the housing (t). Secure but do not over tighten. Over tightening could lead to plastic part failure. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 13 BY HAND. Continue rocking the gate up and down slightly (again ensure not to knock the Brass Bushing out of its pocket) until the pin is thread in. CONTINUED NEXT PAGE... For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 14 If door is difficult to close, adjust dovetail on bumper-side downwards. Ensure black plastic on swing gate is not hitting dovetail on bumper-side. Refer to Torque Specifications on page 16. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
- Page 15 Reconnect battery and test functionality of all lights, camera, and sensors. Your Installation is Now Complete For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
-
Page 16: Bolt Torque Specifications
Use this only as a guide for hardware without a called out torque specification in the instruction manual. For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW... - Page 17 Rollover and other types of vehicle accidents may result in serious injury or death to you, your passengers and others sharing the road. Smittybilt accessories are decorative and are not intended to reduce or avoid injury or damage in the event of an accident.
-
Page 18: Installation Instructions
Installation Instructions For Technical Support / Warranty Information please call 800-776-0767 EXT 1317 or Email at info@smittybilt.com Toyota Tacoma Swing Gates Rev 1/18/2023 Part # S/B61449DW-PW...
Need help?
Do you have a question about the SB61449DW-PW and is the answer not in the manual?
Questions and answers