Download Print this page

IBM ThinkPad R40 2681 Hardware Maintenance Manual

Lenovo thinkpad r40 2681: hardware guide.
Hide thumbs

Advertisement

IBM Mobile Systems
ThinkPad Computer
Hardware Maintenance Manual
March 2004
This manual supports: ThinkPad R40

Advertisement

Chapters

   Related Manuals for IBM ThinkPad R40 2681

   Summary of Contents for IBM ThinkPad R40 2681

  • Page 1

    IBM Mobile Systems ThinkPad Computer Hardware Maintenance Manual March 2004 This manual supports: ThinkPad R40...

  • Page 2

    Note Before using this information and the product it supports, be sure to read the general information under “Notices” on page 178. First Edition (March 2004) The following paragraph does not apply to the United Kingdom or any country where such provisions are inconsistent with local law: INTERNATIONAL BUSINESS MACHINES CORPORATION PROVIDES THIS PUBLICATION “AS IS”...

  • Page 3: Table Of Contents

    Contents About this manual Introduction Important service information . Strategy for replacing FRUs . How to use error messages . Diskette compatibility matrix . Safety notices: multilingual translations . Safety information . . 17 General safety . . 17 Electrical safety .

  • Page 4

    1030 Hard-disk drive . . 66 1040 DIMM . 68 1050 Mini PCI adapter . 70 1060 Keyboard . 73 1070 Backup battery . . 81 1080 Optical storage in the fixed bay . . 82 1090 PC Card slot assembly .

  • Page 5: About This Manual

    About this manual This manual contains service and reference information for IBM ThinkPad R40 product. Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, and safety information required in servicing computers.

  • Page 6

    ThinkPad R40...

  • Page 7: Introduction

    Introduction Important service information Important BIOS and device driver fixes are customer-installable. The BIOS and device drivers are posted on the IBM support site http://www.ibm.com/pc/support Advise customers to contact the PC Company HelpCenter at 800-772-2227 if they need assistance in obtaining or installing any diskette fixes. Customers in Canada should call IBM HelpPC at 800-565-3344 for assistance or download information.

  • Page 8: How To Use Error Messages

    Important service information Strategy for replacing a hard-disk drive Always try to run a low-level format before replacing a hard-disk drive. Attention: The drive startup sequence in the computer you are servicing may have been changed. Be extremely careful during write operations such as copying, saving, or formatting.

  • Page 9: Safety Notices: Multilingual Translations

    Safety notices Safety notices: multilingual translations In this manual, safety notices appear in English with a page number reference to the appropriate multilingual, translated safety notice found in this section. The following safety notices are provided in English, French, German, Hebrew, Italian, and Spanish. Safety notice 1 Before the computer is powered-on after FRU replacement, make sure all screws, springs, and other small parts are in place and...

  • Page 10

    Safety notices (continuation of safety notice 1) Antes de encender el sistema despues de sustituir una FRU, compruebe que todos los tornillos, muelles y demás piezas pequeñas se encuentran en su sitio y no se encuentran sueltas dentro del sistema. Compruébelo agitando el sistema y escuchando los posibles ruidos que provocarían.

  • Page 11

    Safety notices Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing.

  • Page 12

    Safety notices (continuation of safety notice 2) Alcune batterie di riserva contengono una piccola quantità di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell’acqua né cortocircuitarle. Smaltirle secondo la normativa in vigore (DPR 915/82, successive disposizioni e disposizioni locali).

  • Page 13

    Safety notices Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack.

  • Page 14

    Safety notices (continuation of safety notice 3) Las baterías contienen pequeñas cantidades de níquel. No las desmonte, ni recargue, ni las eche al fuego o al agua ni las cortocircuite. Deséchelas tal como dispone la normativa local. Utilice sólo baterías que se encuentren en la lista de piezas al sustituir la batería.

  • Page 15

    Safety notices Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations.

  • Page 16

    Safety notices (continuation of safety notice 4) La batteria di supporto e una batteria al litio e puo incendiarsi, esplodere o procurare gravi ustioni. Evitare di ricaricarla, smontarne il connettore polarizzato, smontarla, riscaldarla ad una temperatura superiore ai 100 gradi centigradi, incendiarla o gettarla in acqua.

  • Page 17

    Safety notices Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing.

  • Page 18

    Safety notices Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation.

  • Page 19

    Safety notices Safety notice 7 DANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de courant pour brûler des matériaux combustibles ou causer des brûlures corporelles graves.

  • Page 20

    Safety notices Safety notice 8 DANGER Before removing any FRU, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface.

  • Page 21: Safety Information

    Safety information Safety information The following section presents the safety information that you need to be familiar with before servicing an IBM mobile computer. General safety Follow these rules to ensure general safety: v Observe good housekeeping in the area of the machines during and after maintenance.

  • Page 22: Electrical Safety

    Safety information v After service, reinstall all safety shields, guards, labels, and ground wires. Replace any safety device that is worn or defective. v Reinstall all covers correctly before returning the machine to the customer. Electrical safety Observe the following rules when working on electrical equipment.

  • Page 23: Safety Inspection Guide

    Safety information – When using testers, set the controls correctly and use the approved probe leads and accessories for that tester. – Stand on suitable rubber mats (obtained locally, if necessary) to insulate you from grounds such as metal floor strips and machine frames. Observe the special safety precautions when you work with very high voltages;...

  • Page 24: Handling Devices That Are Sensitive To Electrostatic Discharge

    Safety information If any unsafe conditions are present, you must determine how serious the apparent hazard could be and whether you can continue without first correcting the problem. Consider these conditions and the safety hazards they present: v Electrical hazards, especially primary power (primary voltage on the frame can cause serious or fatal electrical shock) v Explosive hazards, such as a damaged CRT face or a...

  • Page 25: Grounding Requirements

    Safety information damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge. Notes 1. Use product-specific ESD procedures when they exceed the requirements noted here. 2.

  • Page 26: Laser Compliance Statement

    Laser compliance statement Laser compliance statement Some IBM Personal Computer models are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. They are also sold separately as options. The drive is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations (DHHS 21 CFR) Subchapter J for Class 1 laser products.

  • Page 27

    Laser compliance statement When a CD-ROM drive, DVD drive or the other laser product is installed, note the following: CAUTION: Use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure. O uso de controles, ajustes ou desempenho de procedimentos diferentes daqueles aqui especificados pode resultar em perigosa exposição à...

  • Page 28

    Laser compliance statement Some CD-ROM drives, DVD-ROM drives, or other optical storage devices contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam.

  • Page 29: General Descriptions

    General descriptions This chapter includes descriptions for any ThinkPad model that has the PC-Doctor DOS diagnostics program. Some descriptions might not apply to your particular computer. Read this first Before you go to the checkout guide, be sure to read this section.

  • Page 30

    Read this first __ 4. Date of purchase __ 5. Failure symptoms, error codes appearing on the display, and beep symptoms __ 6. Procedure index and page number in which the failing FRU was detected __ 7. Failing FRU name and part number __ 8.

  • Page 31

    Read this first v If the spindle of a hard-disk drive becomes noisy, it may have been subjected to excessive force, or dropped. General descriptions...

  • Page 32: Related Service Information

    Related service information Related service information This section provides information about the following: v “Service web site” v “Restoring the preloaded system” v “Passwords” on page 30 v “Power management” on page 33 Service web site When the latest maintenance diskette and the system program service diskette become available, a notice will be posted on http://www.ibm.com/pc/partner/infotips Restoring the preloaded system...

  • Page 33: Using The Recovery Cd

    Related service information The Product Recovery program is in a section of your hard disk drive that is not displayed by Windows Explorer. Note: The recovery process might take up to 2 hours. Attention All of the files on the primary hard disk partition (usually drive C) will be lost in the recovery process.

  • Page 34: Passwords

    Related service information Note: If you do not want to create the service partition, press N key, and then go to step 8. 5. At next window, press Enter to continue. v The service partition is created. The system automatically reboots during this process. v The recovery process copies some files to the service partition, and PKUNZIPs others.

  • Page 35: Supervisor Password

    Related service information Power-on password: A power-on password (POP) protects the system from being powered on by an unauthorized person. The password must be entered before an operating system can be booted. Hard-disk password: There are two hard-disk passwords (HDPs): v User HDP—for the user v Master HDP—for the system administrator, who can use it to get access to the hard disk even if the user has...

  • Page 36: How To Remove The Hard-disk Password

    Related service information 4. Turn on the computer and wait until the POST ends. After the POST ends, the password prompt does not appear. The POP has been removed. 5. Reinstall the backup battery and the battery pack. (B) If an SVP has been set and is known by the servicer: 1.

  • Page 37: Power Management

    Related service information Power management To reduce power consumption, the computer has three power management modes: screen blank, standby, and hibernation. Notes v Screen blank mode is called standby mode in Windows 95 and Windows NT. v Standby mode is called suspend mode in Windows 95 and Windows NT.

  • Page 38: Hibernation Mode

    Related service information v If the battery indicator blinks orange, indicating that the battery power is low. (Alternatively, if Hibernate when battery becomes low has been selected in the “Power Management Properties” window, the computer goes into hibernation mode.) Note for the APM operating system: Even if you do not set the low-battery alarm, the charge indicator notifies you when the battery is low, and then the computer enters the power-saving mode automatically.

  • Page 39

    Related service information v The system is powered off. Note: If the computer enters the hibernation mode while it is docked to the docking station, do not undock it from the docking station before resuming normal operation. If you do undock it and then try to resume normal operation, you will get an error message, and you will have to restart the system.

  • Page 40: Checkout Guide

    Checkout guide Checkout guide Use the following procedures as a guide in identifying and correcting problems with the ThinkPad computer. Note: The diagnostic tests are intended to test only IBM products. The use of non-IBM products, prototype cards, or modified options can lead to false indications of errors and invalid system responses.

  • Page 41

    Checkout guide If an error code appears, go to “Symptom-to-FRU index” on page 53. On the first screen, select the model and press Enter. Follow the instructions on the screen. 2. The main panel of PC-Doctor appears. 3. Select Diagnostics with the arrow keys, and press Enter.

  • Page 42: Detecting System Information With Pc-doctor

    Checkout guide Diagnostics I n t e r a c t i v e Te s t s Hardware Info U t i l i t y F1=Help Quit Run Normal Test Run Quick Test CPU/Coprocessor Systemboard Video Adapter Serial Ports Parallel Ports Fixed Disks Diskette Drives...

  • Page 43: Power System Checkout

    Checkout guide Power system checkout To verify a symptom, do the following: 1. Power off the computer. 2. Remove the battery pack. 3. Connect the ac adapter. 4. Check that power is supplied when you power on the computer. 5. Power off the computer. 6.

  • Page 44: Checking Operational Charging

    Checkout guide v If the problem persists, go to “Product overview” on page 45. Note: Noise from the ac adapter does not always indicate a defect. Checking operational charging To check whether the battery charges properly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer.

  • Page 45

    Checkout guide Terminal Voltage (V dc) + 0 to + 16.8 1(+) Ground (−) 5(-) 3. If the voltage is less than +14.4 V dc, the battery pack has been discharged. Note: Recharging will take at least 3 hours, even if the indicator does not turn on.

  • Page 46: Checking The Backup Battery

    Checkout guide If the resistance is not correct, replace the battery pack. If the resistance is correct, replace the system board. Checking the backup battery Do the following: 1. Power off the computer, and unplug the ac adapter from it. 2.

  • Page 47: Thinkpad R40

    ThinkPad R40 Product overview . . 45 Specifications . . 45 Status indicators . . 48 FRU tests . . 50 Fn key combinations . . 52 Symptom-to-FRU index . . 53 Numeric error codes . . 53 Error messages .

  • Page 48

    Bottom view for 2681, 2682, 2683, 2722, 2723, 2724 . 130 Front view for 2684, 2685 . . 131 Rear view for 2684, 2685 . . 132 Bottom view for 2684, 2685 . 133 Parts list . . 134 R40 series model matrix .

  • Page 49: Product Overview

    Product overview Product overview This section presents the following product-unique information: v “Specifications” v “Status indicators” on page 48 v “FRU tests” on page 50 v “Fn key combinations” on page 52 Specifications The following table lists the specifications of the ThinkPad R40 series: Feature Description...

  • Page 50

    Product overview Feature Description v 242 bytes CMOS RAM Hard-disk drive 2681, 2682, 2683, 2722, 2723, 2724 v 20.0 GB, 4200 rpm, 2.5-inch, IDE interface v 30.0 GB, 4200 rpm, 2.5-inch, IDE interface v 40.0 GB, 4200 rpm, 2.5-inch, IDE interface v 40.0 GB, 5400 rpm, 2.5-inch, IDE interface v 60.0 GB, 4200 rpm, 2.5-inch, IDE interface 2684, 2685...

  • Page 51

    Product overview Feature Description v Type-II or Type-III PC Card v V.90 modem daughter card (MDC) Communication v Bluetooth Modem daughter card (BMDC) daughter card (CDC) v 72-watt type AC adapter v CD-ROM drive Ultrabay Plus v DVD drive device (standard) v CD-RW/DVD combo drive Preinstalled...

  • Page 52: Status Indicators

    Product overview Status indicators The system status indicators show the status of the computer, as follows: 3 4 5 6 Indicator Meaning 1 Bluetooth Green: Bluetooth is operational. This status indicator is on when the Bluetooth is on and not in suspend mode. 2 Wireless Green: Wireless is operational.

  • Page 53

    Product overview Indicator Meaning 3 Drive in Green: Data is being read from or written to the hard-disk drive, the diskette drive, or the drive in the Ultrabay Plus device. When this indicator is on, do not put the computer into standby mode or turn off the computer.

  • Page 54: Fru Tests

    Product overview FRU tests The following table shows the test for each FRU. Applicable test System board 1. Diagnostics --> CPU/Coprocessor 2. Diagnostics --> Systemboard Power Diagnostics --> Other Devices --> IBM AC Adapter, IBM Battery 1 (IBM Battery 2) LCD unit 1.

  • Page 55

    Product overview Applicable test CD-ROM or 1. Diagnostics --> Other Devices --> DVD drive CD-ROM/DVD 2. Interactive Tests --> CD-ROM/DVD Test Memory 1. If two DIMMs are installed, remove one of them and run Diagnostics --> Memory Test—Quick. 2. If the problem does not recur, return the DIMM to its place, remove the other one, and run the test again.

  • Page 56: Fn Key Combinations

    Product overview Fn key combinations The following table shows the function of each combination of Fn with a function key. Description combination Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Turn off the LCD display, leaving the screen blank. To turn the LCD display on again, press any key or the TrackPoint stick.

  • Page 57: Symptom-to-fru Index

    Symptom-to-FRU index Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.”...

  • Page 58

    Symptom-to-FRU index Symptom or error FRU or action, in sequence 0187 System board. EAIA data access error—The access to EEPROM is failed. 0188 System board. Invalid RFID serialization information area or bad CRC2—The EEPROM checksum is not correct. 0189 System board. Invalid RFID configuration information area—The EEPROM checksum is not...

  • Page 59

    Symptom-to-FRU index Symptom or error FRU or action, in sequence 0250 Replace the backup battery System battery error—System and run IBM BIOS Setup battery is dead. Utility to reset the time and date. 0251 Replace the backup battery System CMOS checksum and run IBM BIOS Setup bad—Default configuration Utility to reset the time and...

  • Page 60: Error Messages

    Symptom-to-FRU index Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in IBM BIOS Setup Utility. 2. Backup battery. 3. System board. Allocation error for device. 1. Load “Setup Defaults” in IBM BIOS Setup Utility. 2.

  • Page 61: Beep Symptoms

    Symptom-to-FRU index Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, 1. Reset the LCD connector. unreadable, or flashing LCD. 2. LCD assembly. 3. External CRT. 4. System board. One long and two short beeps, 1.

  • Page 62: Lcd-related Symptoms

    Symptom-to-FRU index LCD-related symptoms Important The TFT LCD for the notebook computer contains many thin-film transistors (TFTs). A small number of dots that are missing, discolored, or always lighted is characteristic of TFT LCD technology, but excessive pixel problems can cause viewing concerns.

  • Page 63: Intermittent Problems

    Symptom-to-FRU index Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs. When analyzing an intermittent problem, do the following: 1.

  • Page 64: Fru Replacement Notices

    FRU replacement notices FRU replacement notices This section contains notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In IBM ThinkPad computer, this problem is addressed with special nylon-coated screws that have the following characteristics: v They maintain tight connections.

  • Page 65: Retaining Serial Numbers

    FRU replacement notices v Make sure you use the correct screw. If you have a torque screwdriver, tighten all screws firmly to the torque shown in the table. Never use a screw that you removed. Use a new one. Make sure the screws are tightened firmly.

  • Page 66

    FRU replacement notices and stored in the EEPROM of your system board. The algorithm that generates the number is designed to provide unique IDs until the year A.D. 3400. No two computers in the world have the same number. When you replace the system board, you must set the UUID on the new system board as follows: 1.

  • Page 67: Removing And Replacing A Fru

    Removing and replacing a FRU Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified.

  • Page 68: 1010 Battery Pack

    Removing and replacing a FRU 1010 Battery pack DANGER The use only the battery in the parts listing for your computer. Use of an incorrect battery can result in ignition or explosion of the battery. ThinkPad R40...

  • Page 69: 1020 Ultrabay Plus Device

    Removing and replacing a FRU 1020 Ultrabay Plus device For machine type 2681, 2682, 2683, 2722, 2723, 2724 Note Any of Ultrabay Plus devices can be installed into the Ultrabay Plus of the computer. The procedure for installing and removing is the same for every Ultrabay Plus device.

  • Page 70: 1030 Hard-disk Drive

    Removing and replacing a FRU 1030 Hard-disk drive Attention v Do not drop or apply any shock to the hard-disk drive. The hard-disk drive is sensitive to physical shock. Improper handling can cause damage and permanent loss of data. v Before removing the drive, have the user make a backup copy of all the information on the drive if possible.

  • Page 71

    Removing and replacing a FRU When installing: Make sure that the hard-disk connector is firmly attached. ThinkPad R40...

  • Page 72: 1040 Dimm

    Removing and replacing a FRU 1040 DIMM For access, remove this FRU: v “1010 Battery pack” on page 64 Note: Loosen the screws 1 , but do not remove them. Step Screw (quantity) Torque M2.5 x 3.5 mm, +/- Head BK(2) 0.294 Nm (3 kgfcm) (continued)

  • Page 73

    Removing and replacing a FRU When installing: With the notched end of the DIMM toward the socket, insert the DIMM into the socket, and then press it firmly. Pivot the DIMM until it snaps into place. Make sure that the card is firmly fixed in the slot and does not move easily.

  • Page 74: 1050 Mini Pci Adapter

    Removing and replacing a FRU 1050 Mini PCI adapter For access, remove this FRU: v “1010 Battery pack” on page 64 Note: Some models do not have the Mini PCI card socket. Note: Loosen the screw 1a or 1b , but do not remove it.

  • Page 75

    Removing and replacing a FRU Antenna cables 4a and 4b are for the wireless LAN feature. Note: When unplugging the antenna jack, do not pull the cable; it might snap. Unplug the jack by pulling a tab with your fingers. When installing: Plug the gray antenna cable with the tab marked “MAIN”...

  • Page 76

    Removing and replacing a FRU When installing: With the notched end of the card toward the socket, insert the card into the socket, and then press it firmly. Pivot the card until it snaps into place. Make sure that the card is firmly fixed in the slot and does not move easily.

  • Page 77: 1060 Keyboard

    Removing and replacing a FRU 1060 Keyboard For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 For machine type 2681, 2682, 2683, 2722, 2723, 2724 Step Screw (quantity) Torque M2.5 × 8.5 mm, Black (2) 0.294 Nm (3 kgfcm) (continued)

  • Page 78

    Removing and replacing a FRU In step 5 , pull the keyboard a little in the direction of the arrow, and then detach the connector 6 . ThinkPad R40...

  • Page 79

    Removing and replacing a FRU When installing: Install the keyboard, following the directions below. 1. Attach the connector. (Step 6 in the removal procedure.) 2. Make sure that the keyboard edges, shown in the figure as (A) and (B), are under the frame. 3.

  • Page 80

    Removing and replacing a FRU 4. To make sure that the front side of the keyboard is housed firmly, gently press the keys with your thumbs and try to slide the keyboard towards you. 5. Secure the keyboard from the bottom of the computer, using the new screws provided with the keyboard.

  • Page 81

    Removing and replacing a FRU For machine type 2684, 2685 Step Screw (quantity) Torque M2.5 × 8.5 mm, Black (2) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 82

    Removing and replacing a FRU In step 5 , pull the keyboard a little in the direction of the arrow, and then detach the connector 6 . ThinkPad R40...

  • Page 83

    Removing and replacing a FRU When installing: Install the keyboard, following the directions below. 1. Attach the connector. (Step 6 in the removal procedure.) 2. Make sure that the keyboard edges, shown in the figure as (A) and (B), are under the frame. 3.

  • Page 84

    Removing and replacing a FRU 4. To make sure that the front side of the keyboard is housed firmly, gently press the keys with your thumbs and try to slide the keyboard towards you. 5. Secure the keyboard from the bottom of the computer, using the new screws provided with the keyboard.

  • Page 85: 1070 Backup Battery

    Removing and replacing a FRU 1070 Backup battery DANGER The use only the battery in the parts listing for your computer. Use of an incorrect battery can result in ignition or explosion of the battery. For access, remove these FRUs, in order: v “1010 Battery pack”...

  • Page 86: 1080 Optical Storage In The Fixed Bay

    Removing and replacing a FRU 1080 Optical storage in the fixed bay For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1060 Keyboard” on page 73 For machine type 2684, 2685 Step Screw (quantity) Torque M2.5 x 6 mm, Yellow (1) 0.294 Nm...

  • Page 87

    Removing and replacing a FRU Pull the L-shaped bracket to the right of the computer and drag out the built-in optical drive from the computer. Note: There is a sharp object next to the bracket inside the square opening. Be careful not to cut your finger.

  • Page 88

    Removing and replacing a FRU ThinkPad R40...

  • Page 89: 1090 Pc Card Slot Assembly

    Removing and replacing a FRU 1090 PC Card slot assembly For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1040 DIMM” on page 68 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 Step Screw (quantity) Torque...

  • Page 90

    Removing and replacing a FRU When installing: Make sure that the connector of the PC card slot is firmly attached, and then secure the screws. ThinkPad R40...

  • Page 91: 1100 Hinge Cover

    Removing and replacing a FRU 1100 Hinge cover For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 When installing: Attach the hinge cover, aligning the two projections on the rear side with the two small square holes of the base cover. ThinkPad R40...

  • Page 92: 1110 Communication Daughter Card (cdc)

    Removing and replacing a FRU 1110 Communication daughter card (CDC) For access, remove this FRU: v “1010 Battery pack” on page 64 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 Note: Some models do not have the Communication daughter card (CDC).

  • Page 93: Modem Daughter Card (mdc)

    Removing and replacing a FRU Modem daughter card (MDC) (continued) ThinkPad R40...

  • Page 94

    Removing and replacing a FRU When installing: Make sure that connector 6 is firmly attached. Step Screw (quantity) Torque M2.5 x 6 mm, Yellow (1) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 95

    Removing and replacing a FRU Step Screw (quantity) Torque M2.0 x 3.5 mm, Silver (2) 0.294 Nm (3 kgfcm) Step Screw (quantity) Torque M2.0 x 3.5 mm, Silver (1) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 96: Ibm Integrated Bluetooth With 56k Modem (bmdc)

    Removing and replacing a FRU When installing: Make sure that connectors 14 and 15 are firmly attached. IBM Integrated Bluetooth with 56K Modem (BMDC) For machine type 2681, 2682, 2683, 2722, 2723, 2724 Following illustrations show the BMDC. (continued) ThinkPad R40...

  • Page 97

    Removing and replacing a FRU When installing: Make sure that antenna jack 17 is firmly attached. Note: When unplugging the Bluetooth antenna jack 17 , do not pull the cable; it might snap. Unplug the jack by pulling a tab with your fingers. ThinkPad R40...

  • Page 98: 1120 Fan Assembly

    Removing and replacing a FRU 1120 Fan assembly For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 Step Screw (quantity) Torque M2 × 13 mm, Silver (4) 0.294 Nm (3 kgfcm) When installing: Make sure that the connector 2 is...

  • Page 99: 1130 Cpu

    Removing and replacing a FRU 1130 CPU For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1120 Fan assembly” on page 94 Note: There are two types of CPU socket.

  • Page 100

    Removing and replacing a FRU When installing: Place the CPU on the CPU socket ( 1 ), and then rotate the head of the screw (A) in the direction of arrow 2 to secure the CPU. Note: When replacing the CPU, you must replace the thermal pad FRU 5022BZ4023A also.

  • Page 101: 1140 Bluetooth Antenna Assembly

    Removing and replacing a FRU 1140 Bluetooth antenna assembly For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 For machine type 2681, 2682, 2683, 2722, 2723, 2724 Note: Some models do not have the Bluetooth antenna.

  • Page 102: 1150 Lcd Assembly

    Removing and replacing a FRU 1150 LCD assembly For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1110 Communication daughter card (CDC)”...

  • Page 103

    Removing and replacing a FRU Step Screw (quantity) Torque M2.5 × 6 mm, Yellow (1) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 104

    Removing and replacing a FRU Step Screw (quantity) Torque M2.0 × 3.5 mm, Silver (2) 0.294 Nm (3 kgfcm) M2.5 × 8.5 mm, Black (4) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 105

    Removing and replacing a FRU ThinkPad R40...

  • Page 106

    Removing and replacing a FRU When installing: Make sure that the antenna cables are routed along the cable holder as shown in this figure, and then attach the LCD assembly to the base cover by securing the screws. ThinkPad R40...

  • Page 107: 1160 Keyboard Bezel

    Removing and replacing a FRU 1160 Keyboard bezel For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1150 LCD assembly”...

  • Page 108

    Removing and replacing a FRU If the ThinkPad computer you are servicing has the touch pad, detach the connector a before removing the screws. When installing: If the ThinkPad computer you are servicing has the touch pad, make sure that the connector a is firmly attached. (continued) ThinkPad R40...

  • Page 109

    Removing and replacing a FRU Remove the keyboard bezel in the direction of arrow 2 . ThinkPad R40...

  • Page 110

    Removing and replacing a FRU For machine type 2684, 2685 Step Screw (quantity) Torque M2.5 × 8.5 mm, Black (6) 0.294 Nm (3 kgfcm) M2.5 × 6 mm, Yellow (3) 0.294 Nm (3 kgfcm) (continued) ThinkPad R40...

  • Page 111

    Removing and replacing a FRU Remove the keyboard bezel in the direction of arrow 2 . ThinkPad R40...

  • Page 112: 1170 Speaker Assembly And Microphone Cable

    Removing and replacing a FRU 1170 Speaker assembly and microphone cable For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1150 LCD assembly” on page 98 v “1160 Keyboard bezel”...

  • Page 113: 1180 System Board

    Removing and replacing a FRU 1180 System board For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1150 LCD assembly”...

  • Page 114

    Removing and replacing a FRU v System board without IBM security chip Begin by checking the FRU number of the system board, and be sure to use the correct system board FRU for the computer. For the FRU numbers, see “Parts list” on page 134.

  • Page 115

    Removing and replacing a FRU For machine type 2684, 2685 v System board without IBM security chip Begin by checking the FRU number of the system board, and be sure to use the correct system board FRU for the computer. For the FRU numbers, see “Parts list” on page 134.

  • Page 116

    Removing and replacing a FRU For machine type 2681, 2682, 2683, 2722, 2723, 2724 Step Screw (quantity) Torque M2.5 × 6 mm, Yellow (2) 0.294 Nm (3 kgfcm) 1 + 1a M2.5 × 6 mm, Yellow (3) 0.294 Nm (3 kgfcm) Note: To remove the system board, the lever a must be pulled out.

  • Page 117

    Removing and replacing a FRU When installing: v Attach the system board so that the two small projections on the base cover fit into the holes provided. v Make sure that the lever a must be pulled out. Note: When replacing the system board, you must replace the thermal pad FRU 5022BZ4023A also.

  • Page 118

    Removing and replacing a FRU For machine type 2684, 2685 Step Screw (quantity) Torque M2.5 × 6 mm, Yellow (2) 0.294 Nm (3 kgfcm) 1 + 1a M2.5 × 6 mm, Yellow (3) 0.294 Nm (3 kgfcm) ThinkPad R40...

  • Page 119

    Removing and replacing a FRU When installing: v Attach the system board so that the two small projections on the base cover fit into the holes provided. Note: When replacing the system board, you must replace the thermal pad FRU 5022BZ4023A also. ThinkPad R40...

  • Page 120: 1190 Hard-disk Drive Slot

    Removing and replacing a FRU 1190 Hard-disk drive slot For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1070 Backup battery” on page 81 v “1090 PC Card slot assembly”...

  • Page 121: 2000 Ultrabay Plus Guide Rail

    Removing and replacing a FRU 2000 Ultrabay Plus guide rail For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1150 LCD assembly”...

  • Page 122

    Removing and replacing a FRU Step Screw (quantity) Torque M2 × 13 mm, Silver (1) 0.294 Nm (3 kgfcm) M2.0 × 3.5 mm, Silver (1) 0.294 Nm (3 kgfcm) When installing: Attach the Ultrabay Plus guide rail so that the two small projections on the ultrabay device connector fit into the holes a provided, and then secure the screws.

  • Page 123: 2010 I/o Bracket

    Removing and replacing a FRU 2010 I/O Bracket For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1020 Ultrabay Plus device” on page 65 v “1030 Hard-disk drive” on page 66 v “1040 DIMM” on page 68 v “1050 Mini PCI adapter”...

  • Page 124: 2020 Lcd Front Bezel

    Removing and replacing a FRU 2020 LCD front bezel For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1150 LCD assembly”...

  • Page 125: 2030 Inverter Card

    Removing and replacing a FRU 2030 Inverter card For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover” on page 87 v “1150 LCD assembly”...

  • Page 126: 2040 Lcd Panel And Lcd Cable Assembly

    Removing and replacing a FRU 2040 LCD panel and LCD cable assembly For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover”...

  • Page 127

    Removing and replacing a FRU When installing the LCD panel, do the following: v Place the FPC connector under the black antenna cable. v Make sure that the antenna cables are firmly routed to fit to the cable guides of the LCD cover. v Make sure that the antenna cables are not pinched under the LCD panel.

  • Page 128: 2050 Antenna Assembly, Hinges, And Lcd Cover

    Removing and replacing a FRU 2050 Antenna assembly, hinges, and LCD cover For access, remove these FRUs, in order: v “1010 Battery pack” on page 64 v “1050 Mini PCI adapter” on page 70 v “1060 Keyboard” on page 73 v “1100 Hinge cover”...

  • Page 129

    Removing and replacing a FRU To install the antenna assembly, do as follows: 1. Make sure that the antenna assembly and hinges are firmly attached; there are some projections ( a ) on the hinges to fix the antenna assembly into place. And then, route the gray cable (MAIN) as in this figure.

  • Page 130

    Removing and replacing a FRU 2. Route the black cable (AUX) as in figures 4 and 5 . 3. Secure the antenna assembly and hinges with screws to the LCD cover. ThinkPad R40...

  • Page 131: Locations

    Locations Locations Front view for 2681, 2682, 2683, 2722, 2723, 2724 Bluetooth/Wireless LAN status indicator (on some models) System status indicators Power status indicators Power switch Ultrabay Plus latch Ultrabay Plus status indicator Ultrabay Plus device eject lever Ultrabay Plus Note: The Ultrabay Plus accepts several storage devices, such as a CD-ROM, a DVD drive, or...

  • Page 132

    Locations ThinkPad R40...

  • Page 133: Rear View For 2681, 2682, 2683, 2722, 2723, 2724

    Locations Rear view for 2681, 2682, 2683, 2722, 2723, 2724 Power status indicators Bluetooth status indicator (on some models) S-Video-out connector Universal serial bus (USB) connector Ethernet connector Modem connector External-monitor connector Parallel connector AC power connector Security keyhole ThinkPad R40...

  • Page 134: Bottom View For 2681, 2682, 2683, 2722, 2723, 2724

    Locations Bottom view for 2681, 2682, 2683, 2722, 2723, 2724 Battery pack Battery pack latches DIMM slots Docking connector Mini PCI card slot PC Card slots PC Card eject buttons IEEE 1394 (on some models) USB connector Stereo headphone jack Microphone jack Hard-disk drive LCD latches...

  • Page 135: Front View For 2684, 2685

    Locations Front view for 2684, 2685 Wireless LAN status indicator (on some models) System status indicators Power status indicators Power switch Optical storage drive in the fixed bay Built-in microphone TrackPoint pointing stick TrackPoint buttons Access IBM button Volume control buttons ThinkPad R40...

  • Page 136: Rear View For 2684, 2685

    Locations Rear view for 2684, 2685 Power status indicators Universal serial bus (USB) connector Ethernet connector Modem connector External-monitor connector Parallel connector AC power connector Security keyhole ThinkPad R40...

  • Page 137: Bottom View For 2684, 2685

    Locations Bottom view for 2684, 2685 Battery pack Battery pack latches DIMM slots Mini PCI card slot PC Card slots PC Card eject buttons USB connector Stereo headphone jack Microphone jack Hard-disk drive LCD latches Built-in mono speaker ThinkPad R40...

  • Page 138: Parts List

    Parts list Parts list R40 series model matrix The R40 series includes several models. The following table summarizes the characteristics of each model, to help you determine which FRU in the part list meets your need. For machine type 2681, 2682, 2683, 2722, 2723, 2724, 2896, 2897 Model Mini PCI...

  • Page 139

    Parts list Model Mini PCI device 2681–C3x P4 1.9G 14.1 in, — 2681–M4x P4 2.0G ATI M6 16MB/ Memory 256MB/ HDD 20GB 2681–26x Cel 1.6G 14.1 in, CDROM — 2681–29x 802.11b 2681–24x — 2681–22x CDROM 2681–41x, 4Ex Cel 1.8G 2682–4Bx Ready 2681–44x, 46x Combo...

  • Page 140

    Parts list Model Mini PCI device 2683–FAx P4 2.0G 14.1 in, Ready 2682–FAx, F9x 2681–M7x 2682–FEx Cisco 2896–FZU Open 2682–G9x 15 in, XGA Ready 2681–F9x, FAx, 14.1 in, 2681–F8x, MFx CDROM 2681–MCx — 2681–G8x 15 in, XGA Ready 2681–G9x, G2x 2681–GGx Blank Bezel...

  • Page 141

    Parts list Model Mini PCI device 2681–CFx, C6x P4 1.9G 14.1 in, Combo Ready 2681–C5x CDROM 2681–C4x 2681–D5x 15 in, XGA CDROM 2681–FFx, P4 2.0G 14.1 in, Combo M6G, MJx, 2681–M5x — 2681–MRx, CDROM 2681–MQx 802.11b 2681–FDx, FCx, MDx, 2681–FBx, Ready M8x, MKx 2681–F1x...

  • Page 142

    Parts list Model Mini PCI device 2681–2Ux Cel 1.6G 14.1 in, Open Ready 2681–3Ux 15 in, XGA 2681–4Tx Cel 1.8G 14.1 in, Blank Bezel 2681–4Ux Open 2681–5Ux 15 in, XGA 2681–MVx P4 2.0G 14.1 in, Blank Bezel 2681–FTx Open 2681–JTx P4 2.2G 2722–2Yx PM 1.3G...

  • Page 143

    Parts list Model Mini PCI device 2681–DHx P4 1.9G 15 in, XGA Ready 2681–DGx CDROM 802.11b 2681–DJx — 2681–DKx Combo 802.11b 2681–D7x Ready 2681–DMx CDROM — 2681–ELx, EPx 15 in, Combo Ready SXGA+ 2681–G6x P4 2.0G 14.1 in, Blank Bezel 2681–F4x Combo 2681–MGx...

  • Page 144

    Parts list Model Mini PCI device 2681–JJx, J3x, P4 2.2G 14.1 in, Ready JKx, JPx, JMx, 2681–J6x CDROM 2681–J4x, JFx, Combo 2681–J1x 802.11b 2681–JGx 2682–KEx 15 in, XGA 2681–K3x Ready 2682–KFx, KDx, KFx, KKx, 2681–KMx Cisco 2681–KCx, Combo Ready KLx, PAG 2681–KNx, K8x Blank Bezel...

  • Page 145

    Parts list Model Mini PCI device 2724–3Px PM 1.3G 14.1 in, Combo 802.11a/b 2723–3Px, 3Lx 2724–3Xx 802.11b 2723–3Xx 2897–34U 2722–3Jx Ready 2722–3Cx 2723–58x, 15 in, XGA 2722–5Ax, 58x, 2723–5Tx Cisco 2722–5Jx, 5Nx Combo Ready 2897–55U Open 2897–54U 802.11b 2723–6Lx, 6Px 15 in, 802.11a/b 2724–6Px...

  • Page 146

    Parts list Model Mini PCI device 2681–P4x P4 2.4G 15 in, XGA Blank 802.11b Bezel 2681–Q2x, 15 in, Combo QBx, Q3x SXGA 2681–QCx Ready 2681–Q6x 802.11a/b 2897–GWU PM 1.3G 15 in, SXGA+ 2723–GBx PM 1.5G 802.11b 2722–GCx, 2722–GDx 802.11a/b 2722–G3x Ready ATI M7 32MB/ Memory Open/ HDD Open 2681–2Tx...

  • Page 147

    Parts list For machine type 2684, 2685 Model Mini PCI device Integrated shared/ Memory 128MB/ HDD 20GB 2684–22x Cel 1.7G 13.3 in, CDROM Open 2685–22x 2684–23x 2684–43x 14.1 in, 2684–4Tx, 42x, CDROM 4Ux, 46x 2684–4Cx 802.11b 2684–A2x P4 1.8G 13.3 in, Open 2684–A3x 2684–B2x, B6x...

  • Page 148: Overall

    Parts list Overall For machine type 2681, 2682, 2683, 2896 ThinkPad R40...

  • Page 149

    Parts list v Each FRU is available for all types or model, unless specific types or models are specified. v A CRU (Customer Replaceable Units) is identified by a single asterisk (*) or two asterisks (**) in the CRU ID column.

  • Page 150

    Parts list No. FRU See “Miscellaneous parts” on page 169. KBD bezel Middle cover ASM (15 in TFT) 46P3104 KBD bezel Middle cover ASM (13/14 in 46P3105 TFT) KBD bezel Upper case (15 in TFT) 91P9153 KBD bezel Upper case (13/14 in TFT) 91P9154 CD-ROM TEAC CD-224E-C 27L3436...

  • Page 151

    Parts list No. FRU 13 Lower Case w/ label IIPC 46P3108 —wireless (15 in TFT) M/T 2681 Lower Case w/ label Korea 46P3109 —wireless (15 in TFT) M/T 2681 Lower Case w/ label Taiwan 46P3110 —wireless (15 in TFT) M/T 2681 Lower Case w/ label W/W 46P3111 —wireless (13/14 in TFT) M/T 2681...

  • Page 152

    Parts list No. FRU 13 Lower Case w/ label W/W 91P8584 —wireless (13/14 in TFT) M/T 2683 Lower Case w/ label EMEA 91P8585 —wireless (13/14 in TFT) M/T 2683 Lower Case w/ label IIPC 91P8586 —wireless (13/14 in TFT) M/T 2683 Lower Case w/ label Korea 91P8587 —wireless (13/14 in TFT) M/T 2683...

  • Page 153

    Parts list No. FRU 14 Bluetooth antenna assembly 91P6806 depending on the model 15 DIMM — 128MB 10K0029 DIMM — 256MB 10K0031 DIMM — 512MB 10K0033 16 802.11b Cisco Wireless Card (Sherman 26P8496 III) — North America 802.11b Cisco Wireless Card (Sherman 26P8498 III) —...

  • Page 154

    Parts list No. FRU 20 PC card slot (15 in TFT) 46P3100 PC card slot (13/14 in TFT) 46P3101 21 Fan ASM 46P3099 22 HDD w/ tray and screws 20GB Hitachi 08K9827 HDD w/ tray and screws 20GB Fujitsu 92P6000 HDD w/ tray and screws 30GB Hitachi 92P6056 HDD w/ tray and screws 30GB Fujitsu...

  • Page 155

    Parts list For machine type 2722, 2723, 2724, 2892, 2893, 2897 ThinkPad R40...

  • Page 156

    Parts list No. FRU See “Miscellaneous parts” on page 169. KBD bezel Middle cover ASM (15 in TFT) 46P3104 KBD bezel Middle cover ASM (13/14 in 46P3105 TFT) KBD bezel Upper case (15 in TFT) 91P9153 KBD bezel Upper case (13/14 in TFT) 91P9154 CD-ROM TEAC CD-224E-C 27L3436...

  • Page 157

    Parts list No. FRU 13 Lower Case w/ label EMEA 91P9597 —wireless (13/14 in TFT) M/T 2722 Lower Case w/ label IIPC 91P9598 —wireless (13/14 in TFT) M/T 2722 Lower Case w/ label Korea 91P9599 —wireless (13/14 in TFT) M/T 2722 Lower Case w/ label Taiwan 91P9600 —wireless (13/14 in TFT) M/T 2722...

  • Page 158

    Parts list No. FRU 13 Lower case w/ label kit W/W 91P9735 (15 in TFT) M/T 2722 Lower case w/ label kit W/W 91P9736 (13/14 in TFT) M/T 2722 Lower case w/ label kit W/W 91P9737 (15 in TFT) M/T 2723 Lower case w/ label kit W/W 91P9738 (13/14 in TFT) M/T 2723...

  • Page 159

    Parts list No. FRU 16 802.11b Wireless Card (Calexico-b) 91P7293 — W/W 802.11b Wireless Card (Calexico-b) 91P7267 — xxA xxC xxG xxK xxS 802.11b Cisco Wireless Card (Sherman 26P8496 III) — North America 802.11b Cisco Wireless Card (Sherman 26P8498 III) —...

  • Page 160

    Parts list No. FRU 23 Hard-disk drive cover (15 in TFT) 46P3116 Hard-disk drive cover (13/14 in TFT) 46P3117 24 Keyboard** (see “Keyboard” on page 165.) 25 Pointing stick cap set 91P8898 26 Hinge cap 46P3096 — Modem cable w/o core 91P6798 —...

  • Page 161

    Parts list For machine type 2684, 2685 ThinkPad R40...

  • Page 162

    Parts list No. FRU See “Miscellaneous parts” on page 169. KBD bezel Middle cover ASM (13/14 in 46P3105 TFT) KBD bezel Upper case (13/14 in TFT) 91P9628 CD-ROM TEAC CD-224E-C (Bare) 13N6710 CD-ROM HLDS CRN-8245B (Bare) 08K9841 DVD MKE SR-8177 (Bare) 08K9845 DVD Hitachi GDR-8081N (Bare) 08K9847...

  • Page 163

    Parts list No. FRU 13 Lower Case w/ label EMEA 91P9631 —no wireless (13/14 in TFT) M/T 2684 Lower Case w/ label IIPC 91P9632 —no wireless (13/14 in TFT) M/T 2684 Lower Case w/ label Korea 91P9633 —no wireless (13/14 in TFT) M/T 2684 Lower Case w/ label Taiwan 91P9634 —no wireless (13/14 in TFT) M/T 2684...

  • Page 164

    Parts list No. FRU 18 Hard-disk guide rail assembly 91P9640 19 PC card slot (13/14 in TFT) 46P3101 20 Fan ASM 46P3099 21 HDD w/ tray and screws 20GB Hitachi 08K9827 HDD w/ tray and screws 20GB Fujitsu 92P6000 HDD w/ tray and screws 40GB Hitachi 08K9828 HDD w/ tray and screws 40GB Fujitsu 92P6001...

  • Page 165: Lcd Frus

    Parts list LCD FRUs ThinkPad R40...

  • Page 166: 13/14 In. Tft

    Parts list 13/14 in. TFT For machine type 2681, 2682, 2683 LCD Bezel ASM (13 in TFT) 46P3092 LCD Bezel ASM (14 in TFT) 46P3091 LCD Rear Cover ASM (13/14 in 91P9157 TFT)-Wireless LCD Rear Cover ASM (13/14 in TFT)- 91P9159 no Wireless LCD Hinge/bracket kit w/ antenna (13/14...

  • Page 167: 15 In. Tft

    Parts list LCD Panel ASM 14 in (LG) 11P8283 LCD Panel ASM 14 in (Samsung) 11P8364 LCD Panel ASM 14 in (DBU) 92P6641 LCD Panel ASM 14 in (Hydis) 93P5546 For machine type 2684, 2685 LCD Bezel ASM (13 in TFT) 91P9627 LCD Bezel ASM (14 in TFT) 91P9626...

  • Page 168

    Parts list LCD Hinge/bracket kit w/ antenna 46P3093 LCD Hinge/bracket kit 91P8632 LCD Cable ASM (XGA, wireless 30P) 08K4067 LCD Cable ASM (XGA, no-wireless 20P) 91P6789 LCD Cable ASM (SXGA+, wireless 30P) 08K4070 LCD Inverter/LED card 26P8400 LCD Inverter card no-wireless 26P8413 LCD Panel ASM XGA (LGP) 11P8310/...

  • Page 169: Keyboard

    Parts list Keyboard Language (NMB) (Chicony) Arabic 08K4743 08K4771 Belgian 08K4740 08K4768 Chinese, Traditional 08K4754 08K4782 Czech 08K4748 08K4776 Danish 08K4737 08K4765 Dutch 08K4734 08K4762 English, U.K. 08K4732 08K4760 English, U.S. 08K4729 08K4757 French, Canadian 08K4730/ 08K4758/ 93P4739 93P4740 French, European 08K4733 08K4761 German...

  • Page 170: Recovery Cds

    Parts list Recovery CDs For Windows 2000 Professional Windows 2000 Professional is preinstalled as the operating system in some models. For machine type 2681, 2682, 2683 Language CRUID Arabic 01R8329 Chinese, Simplified 01R8620 Chinese, Traditional 01R8617 Chinese, Traditional (Hong Kong S.A.R.) 01R8623 Czech 01R8330...

  • Page 171: For Windows Xp Home Edition

    Parts list For Windows XP Home Edition Windows XP Home Edition is preinstalled as the operating system in some models. For machine type 2681, 2682, 2683, 2722, 2723, 2724 Language CRUID Arabic 01R8429 Chinese, Simplified 01R8621 Chinese, Traditional 01R8618 Chinese, Traditional (Hong Kong S.A.R.) 01R8624 Czech 01R8430...

  • Page 172: For Windows Xp Professional

    Parts list For Windows XP professional Windows XP Professional is preinstalled as the operating system in some models. For machine type 2681, 2682, 2683, 2684, 2685, 2722, 2723, 2724 Language CRUID Arabic 01R8529 Chinese, Simplified 01R8622 Chinese, Traditional 01R8619 Chinese, Traditional (Hong Kong S.A.R.) 01R8625 Czech 01R8530...

  • Page 173: Miscellaneous Parts

    Parts list Miscellaneous parts For machine type 2681, 2682, 2683, 2722, 2723, 2724 Screw kit: 46P3125 v M2.0 × 3.5 mm, Silver #1 (20) v M2.0 × 4.5 mm, 0.6T Yellow #0 (5) v M2.5 × 5 mm, Black #1 (10) v M2.5 ×...

  • Page 174

    Parts list System miscellaneous parts kit: 91P8635 v (a) Plate, CDC (1) v (b) Cable, Modem (1) v (c) Plate, Thermal Brookdale (1) v (d) Plate, Thermal Video Chip (1) v Pad, Thermal for Brookdale (1) v Pad, Thermal for Video Chip (1) v Plate, Reinforce HDD (1) v Label, Caution RTC Battery (1) v Screw, M2.0 ×...

  • Page 175

    Parts list For machine type 2684, 2685 Screw kit: 46P3125 v M2.0 × 3.5 mm, Silver #1 (20) v M2.0 × 4.5 mm, 0.6T Yellow #0 (5) v M2.5 × 5 mm, Black #1 (10) v M2.5 × 6 mm, Silver #1 (15) v M2.5 ×...

  • Page 176: Ac Adapters

    Parts list System miscellaneous parts kit: 91P8635 v (a) Plate, CDC (1) v (b) Cable, Modem (1) v (c) Plate, Thermal Brookdale (1) v (d) Plate, Thermal Video Chip (1) v Pad, Thermal for Brookdale (1) v Pad, Thermal for Video Chip (1) v Plate, Reinforce HDD (1) v Label, Caution RTC Battery (1) v Screw, M2.0 ×...

  • Page 177: Telephone Cable

    Parts list Telephone cable Telephone cable (Australia) 27L0467 Telephone cable (Austria) 27L0449 Telephone cable (BE/BK/BS/BD/BF) 27L0451 Telephone cable (DK/DE/PO) 27L0447 Telephone cable (FI/NO/NS) 27L0446 Telephone cable (France) 27L0443 Telephone cable (Germany) 27L0441 Telephone cable (Italy) 27L0448 Telephone cable (ND/NU) 27L0444 Telephone cable (SF/SI/SG/SE) 27L0462 Telephone cable (Spain)

  • Page 178: Optional Frus

    Parts list Optional FRUs Ultrabay Plus devices For machine type 2681, 2682, 2683, 2722, 2723, 2724 ThinkPad Multi-Burner Ultrabay 2000 Drive 22P7015 * Diskette drive (TEAC) 08K9606 * Diskette drive (SONY) 08K9607 * 2nd HDD adapter 08K6067 * Ultrabay Plus battery, Li-Ion (SANYO) 02K6817 * Ultrabay Plus battery, Li-Ion (SANYO) 02K6818 *...

  • Page 179

    Parts list Main battery Li-Ion (6cell) Sanyo 92P0988 * Main battery Li-Ion (6cell) Panasonic 92P0990 * ThinkPad R40...

  • Page 180: Common Parts List

    Parts list Common parts list Tools Triconnector wrap plug 72X8546 PC test card 35G4703 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 Torque screwdriver 05K4695 5 mm socket wrench 05K4694 Screwdriver 27L8126 1/4″ Hex, Torx TR7 thru TR10 Tamper Resistant Set 00P6967 Magnetic tipped screwdriver 4″...

  • Page 181: Power Cords (thinkpad Mini Dock)

    Parts list Region Switzerland 76H3528 * Power cords (ThinkPad Mini Dock) IBM power cords for a specific country or region are usually available only in that country or region: For 2-pin power cords: Region Canada, U.S. 13H5264 * Japan 13H5273 * Argentina 36L8870 * Brazil...

  • Page 182: Notices

    Notices Notices References in this publication to IBM products, programs, or services do not imply that IBM intends to make these available in all countries in which IBM operates. Any reference to an IBM product, program, or service is not intended to state or imply that only that IBM product, program, or service may be used.

  • Page 183

    Notices ThinkPad R40...

  • Page 184

    Part Number: 13N6183 Printed in Korea (1P) P/N: 13N6183...

Comments to this Manuals

Symbols: 0
Latest comments: